Robotic direct reading device with spatial, temporal, and PID sensors for laboratory VOC exposure assessment

Abstract This study evaluated a novel robotic direct reading method that used a real-time location system to measure the spatial-concentration distribution of volatile organic compounds (VOCs) in a chemistry laboratory. The CEMWIP II is a custom-made sensor that measures VOCs, temperature, humidity, and location, sending data wirelessly in real time to a remote location for display and storage. In this study, the CEMWIP II device was mounted on a robotic platform to create a CEMWIP II-mobile platform. The autonomous mobile platform was released from a corner of the room and allowed to travel randomly along an open floor with the goal of characterizing the spatial distribution of VOCs and identifying their sources in the laboratory. The experiment consisted of 12 runs made of permutations of four corner release sites and four beaker locations, with two beakers containing water and two containing the solvent acetone. The autonomous mobile platform was tasked with locating the two beakers of acetone. The sensor had a detection limit of 100 ppb and the confidence of detecting a source within a 1.46 m2 area was p = 0.0005 by ANOVA. The CEMWIP II-mobile platform was able to measure the spatial distribution of VOCs within a laboratory that were associated with open solvent containers.

[1]  Scott A Henn,et al.  Task- and Time-Dependent Weighting Factors in a Retrospective Exposure Assessment of Chemical Laboratory Workers , 2007, Journal of occupational and environmental hygiene.

[2]  J. da Silva.  DNA damage induced by occupational and environmental exposure to miscellaneous chemicals. , 2016, Mutation research.

[3]  G. Sakorafas,et al.  Hepatitis caused by occupational chronic exposure to trichloroethylene. , 2004, Acta gastro-enterologica Belgica.

[4]  Raffaella Corvi,et al.  Comet assay in reconstructed 3D human epidermal skin models—investigation of intra- and inter-laboratory reproducibility with coded chemicals , 2013, Mutagenesis.

[5]  Pavlos A Kassomenos,et al.  Measurements of benzene and formaldehyde in a medium sized urban environment. Indoor/outdoor health risk implications on special population groups , 2009, Environmental monitoring and assessment.

[6]  S. Batterman,et al.  Levels and sources of volatile organic compounds in homes of children with asthma. , 2014, Indoor air.

[7]  N. Cherry,et al.  Occupation and male infertility: glycol ethers and other exposures , 2008, Occupational and Environmental Medicine.

[9]  Y. Nagasawa,et al.  Solvent Use in Private Research Laboratories in Japan: Comparison with the Use in Public Research Laboratories and on Production Floors in Industries , 2014, Journal of occupational health.

[10]  Jay-young Yu,et al.  Dimethylacetamide-induced hepatic injuries among spandex fibre workers , 2007, Clinical toxicology.

[11]  Y. Hiasa,et al.  Occupational liver injury due to N,N-dimethylformamide in the synthetics industry. , 2009, Internal medicine.

[12]  E. Varanda,et al.  Urinary Mutagenicity in Chemical Laboratory Workers Exposed to Solvents , 2008, Journal of occupational health.

[13]  N. Simcox,et al.  Exposure to volatile organic compounds in healthcare settings , 2014, Occupational and Environmental Medicine.

[14]  R. Basu,et al.  A meta-analysis of occupational trichloroethylene exposure and liver cancer , 2007, International archives of occupational and environmental health.

[15]  L. Hou,et al.  Environmental chemical exposures and human epigenetics. , 2012, International journal of epidemiology.

[16]  M Gissler,et al.  Laboratory work and adverse pregnancy outcomes. , 2010, Occupational medicine.

[17]  S. Batterman,et al.  Personal exposure to mixtures of volatile organic compounds: modeling and further analysis of the RIOPA data. , 2014, Research report.

[18]  F. Thiesen,et al.  Evaluation of genotoxicity and oxidative damage in painters exposed to low levels of toluene. , 2012, Mutation research.

[19]  G. Kennedy.  Toxicology of dimethyl and monomethyl derivatives of acetamide and formamide: a second update , 2012, Critical reviews in toxicology.

[20]  Paul Schulte,et al.  Synthetic biology and occupational risk , 2017, Journal of occupational and environmental hygiene.

[21]  D. Prá,et al.  DNA damage and cytotoxicity in pathology laboratory technicians exposed to organic solvents. , 2016, Anais da Academia Brasileira de Ciencias.

[22]  C. Boewer,et al.  Epidemiological study on the hepatotoxicity of occupational toluene exposure , 1988, International archives of occupational and environmental health.

[23]  Mark Peplow,et al.  How dangerous is chemistry? , 2006, Nature.

[24]  J. Stoker,et al.  The Department of Health and Human Services. , 1999, Home healthcare nurse.

[25]  Ruiguang Song,et al.  Guidelines for air sampling and analytical method development and evaluation (May 1995). Technical report , 1994 .

[26]  W. McKinney,et al.  Aerosol characterization and pulmonary responses in rats after short-term inhalation of fumes generated during resistance spot welding of galvanized steel , 2017, Toxicology reports.

[27]  Laurent Perrin,et al.  Investigation and Analysis of an Explosion in a Research Laboratory at a French University , 2014 .

[28]  Notes from the Field: Acute Sulfuryl Fluoride Poisoning in a Family - Florida, August 2015. , 2016, MMWR. Morbidity and mortality weekly report.

[29]  M. Krasowski,et al.  Toxicology laboratory analysis and human exposure to p-chloroaniline , 2009, Clinical toxicology.