Total heat loss as a predictor of physiological response in wildland firefighter gear

In most types of protective clothing heat strain is an important issue. The wildland firefighter clothing system in the USA has seen no major revision over the last decades. In this project the wildland firefighter clothing system was studied at the material and the systems level. On the sweating guarded hot plate and the sweating thermal manikin effects of different base layers (cotton and modacrylic) and meta-aramid outer layers of different fabric weights were evaluated. Then, a human subject trial was performed on a limited set of clothing systems to validate the results from materials and manikin testing. The clothing systems were composed of relevant materials for wildland firefighters with extra configurations added to explore the effects of the highest and lowest levels of protection. All measurement techniques were reverted to a calculation of the total heat loss (THL), as predicted from the hot plate and the manikin and compared to the calculated heat loss from the human subjects. The prediction of the heat strain, based on the sweating guarded hot plate only, gives a large overestimation of the actual heat loss in humans. The currently used standard in the USA that utilizes THL values has no link to actual human heat loss. The manikin showed much better comparison to the human data in absolute terms, but in general underestimated heat loss and showed worse overall correlation to the human heat loss data than the hot plate values.

[1]  Np Cheney,et al.  Project Aquarius 6. Heat Load From Exertion, Weather, and Fire in Men Suppressing Wildland Fires , 1997 .

[2]  George Havenith,et al.  Individual heat stress response , 1997 .

[3]  Ea McCullough,et al.  An Explanation and Comparison of Sweating Hot Plate Standards , 2004 .

[4]  G. Havenith,et al.  Correction of clothing insulation for movement and wind effects, a meta-analysis , 2004, European Journal of Applied Physiology.

[5]  René M. Rossi,et al.  The effect of wind, body movement and garment adjustments on the effective thermal resistance of clothing with low and high air permeability insulation , 2014 .

[6]  George Havenith,et al.  Analytical Study of the Heat Loss Attenuation by Clothing on Thermal Manikins Under Radiative Heat Loads , 2010, International journal of occupational safety and ergonomics : JOSE.

[7]  Jo Stull,et al.  Field Evaluation of Protective Clothing Effects on Fire Fighter Physiology: Predictive Capability of Total Heat Loss Test , 2000 .

[8]  Lucy E. Dorman,et al.  The effects of protective clothing on energy consumption during different activities , 2008, European Journal of Applied Physiology.

[9]  George Havenith,et al.  Evaporative cooling: effective latent heat of evaporation in relation to evaporation distance from the skin. , 2013, Journal of applied physiology.

[10]  Bn Hoschke,et al.  Project Aquarius 13. The Thermal Burden of High Insulation and Encapsulation in Wildland Firefighters' Clothing , 1997 .

[11]  G Havenith,et al.  Heat balance when wearing protective clothing. , 1999, The Annals of occupational hygiene.

[12]  Ken Parsons,et al.  Human Thermal Environments: The Effects of Hot, Moderate, and Cold Environments on Human Health, Comfort and Performance, Second Edition , 2002 .

[13]  George Havenith,et al.  Heat stress in chemical protective clothing: porosity and vapour resistance , 2011, Ergonomics.

[14]  George Havenith,et al.  Clothing ventilation, vapour resistance and permeability index: changes dus to posture, movement and wind , 1990 .

[15]  A. Coca,et al.  Evaluation of Protective Ensemble Thermal Characteristics Through Sweating Hot Plate, Sweating Thermal Manikin, and Human Tests , 2014, Journal of occupational and environmental hygiene.

[16]  J. W. Domitrovich.  Wildland Firefighter Health and Safety , 2011 .

[17]  W. A. Lotens,et al.  Heat transfer from humans wearing clothing , 1993 .