Evaluation of optical properties and thermal performances of different greenhouse covering materials

Abstract An inverse method was conducted to obtain the spectral optical properties of four greenhouse covering materials, (Low Density Polyethylene (LDPE), Polyolefin (PO), Polyvinylchloride (PVC) and Fused Silica Glass). Diffuse reflectance and transmittance of the covering materials were measured using spectrophotometric method; the complex index of refraction in the range between 0.22 and 25 μm was deduced by inverse calculation using Radiative Element Method by Ray Emission Model (REM2). At longwave radiation, the optical constants of opaque glass material were found by utilizing Kramers–Kronig method resulting good correlation with results obtained by other investigations. A rigorous model for radiative heat transfer analysis to an agricultural greenhouse was developed. The greenhouse covering material was analyzed as a non-gray one-dimension plane-parallel medium subjected to solar and thermal irradiation using REM2. Specular reflectance and diffuse incident irradiation were treated at the boundary surfaces and absorption and emission were taken into account. Thermal performance was evaluated for the above mentioned covering materials.

[1]  Kirby J. Hanson.  The Radiative Effectiveness of Plastic Films for Greenhouses , 1963 .

[2]  M. Rubin.  Infrared properties of polyethylene terephthalate films , 1982 .

[3]  P. T. Tsilingiris.  Design, analysis and performance of low-cost plastic film large solar water heating systems , 1997 .

[4]  R. Bird,et al.  Simple Solar Spectral Model for Direct and Diffuse Irradiance on Horizontal and Tilted Planes at the Earth's Surface for Cloudless Atmospheres , 1986 .

[5]  I D Nikolov,et al.  Optical plastic refractive measurements in the visible and the near-infrared regions. , 2000, Applied optics.

[6]  Laurent Pilon,et al.  Optical constants of silica glass from extreme ultraviolet to far infrared at near room temperature. , 2007, Applied optics.

[7]  W. J. Lamont.  Plastics: Modifying the Microclimate for the Production of Vegetable Crops , 2005 .

[8]  Shigenao Maruyama,et al.  Theoretical approach of a flat-plate solar collector taking into account the absorption and emission within glass cover layer , 2006 .

[9]  James J. O'Brien,et al.  Measurement of pressure-broadening and lineshift coefficients at 77 and 296 K of methane lines in the 727 nm band using intracavity laser spectroscopy , 1994 .

[10]  J. Okajima,et al.  The Effect of Dispersed State to Control of Radiative Properties of Coatings Pigmented with Nanoparticles , 2012 .

[11]  E. Korte,et al.  Infrared ellipsometric determination of the optical constants of polytetrafluoroethylene , 2003 .

[12]  David B. Tanner,et al.  Method for the determination of the optical properties of highly conjugated pigments , 1993 .

[13]  F. Wooten,et al.  Optical Properties of Solids , 1972 .

[14]  S. Maruyama,et al.  The effect of three-dimensional radiative heat transfer in cloud fields using the radiation element method , 2005 .

[15]  S. Maruyama,et al.  The effects of TiO2 pigmented coatings characteristics on temperature and brightness of a coated black substrate , 2012 .

[16]  Shigenao Maruyama,et al.  Radiation Heat Transfer of Arbitrary Three–Dimensional Absorbing, Emitting and Scattering Media and Specular and Diffuse Surfaces , 1997 .

[17]  M. Brewster.  Thermal Radiative Transfer and Properties , 1992 .

[18]  S. Maruyama,et al.  Infrared Radiative Properties of Thin Polyethylene Coating Pigmented With Titanium Dioxide Particles , 2010 .

[19]  S. Logothetidis,et al.  IR–FUV ellipsometry studies on the optical, electronic and vibrational properties of polymeric membranes , 2004 .

[20]  Zhang Yinping,et al.  A new method for determination of the optical constants and thermal radiation properties of semi-transparent films , 1995 .

[21]  Marcus Nagle,et al.  Experimental and simulated performance of a PV-ventilated solar greenhouse dryer for drying of peeled longan and banana , 2009 .

[22]  K. Ting,et al.  Solar photosynthetically active radiation transmission through greenhouse glazings , 1987 .

[23]  W. Shackleford,et al.  Transmissivity and Absorption of Fused Quartz Between 0.22 mu and 3.5 mu from Room Temperature to 1500 degrees C. , 1971, Applied optics.

[24]  A. Soldera,et al.  Mid-infrared optical properties of a polymer film: comparison between classical molecular simulations, spectrometry, and ellipsometry techniques , 2002 .

[25]  I. Malitson.  Interspecimen Comparison of the Refractive Index of Fused Silica , 1965 .

[26]  M. Modest.  Radiative heat transfer , 1993 .

[27]  S. Maruyama,et al.  A new approach to optimizing pigmented coatings considering both thermal and aesthetic effects , 2009 .

[28]  Jack L. Koenig,et al.  Optical Constant Determination of Thin Polymer Films in the Infrared , 1984 .

[29]  Masud Behnia,et al.  Combined non-gray radiative and conductive heat transfer in solar collector glass cover , 2003 .

[30]  D. C. Larson,et al.  Calculation of the top loss coefficient of a flat-plate collector , 1981 .

[31]  S. Maruyama,et al.  Nongray radiative heat transfer analysis in the anisotropic scattering fog layer subjected to solar irradiation , 2004 .

[32]  Y. Zhang,et al.  A method for measuring thermal radiation properties of semi-transparent materials , 1994 .

[33]  H. Sugaya,et al.  The Measurement of Longwave Radiation Properties upon Plastic Films Used in Greenhouses , 1982 .

[34]  G. Giacomelli,et al.  Greenhouse Covering Systems , 1993 .

[35]  Demetres Briassoulis,et al.  Review Paper (SE—Structures and Environment): Radiometric and Thermal Properties of, and Testing Methods for, Greenhouse Covering Materials , 2000 .

[36]  G. Oreski,et al.  Development of Methods to Determine the Infrared-Optical Properties of Polymer Films , 2008 .

[37]  A. Blaga,et al.  Use of plastics in solar energy applications , 1978 .

[38]  Michael Rubin,et al.  Optical Properties of Soda Lime Silica Glasses , 1985 .

[39]  Norihide Takeyama,et al.  Measurement of refractive indices of 20 optical materials at low temperatures , 2006 .