Environmental life cycle assessment of rapeseed straight vegetable oil as self-supply agricultural biofuel

Biofuels are nowadays considered a questionable environmental alternative to fossil fuels. In that context, this work analyses the environmental impacts when introducing rapeseed on the traditional and current wheat and barley agricultural rotation by means of a comparative life cycle assessment (LCA). The introduction of rapeseed, the correctness of its conversion to obtain straight vegetable oil and its use as self-consumption biofuel in tractors are evaluated. Life cycle assessment is used in this work to evaluate the impacts of different considered scenarios. A sensitivity analysis has also been conducted. The results presented show a modest environmental improvement (diminishment of 6 out of the 10 analyzed environmental impacts) when introducing rapeseed to local crop rotations and its partial conversion to oil to be used as fuel in existing diesel engines. Additionally, the ratio between the energy obtained and the total energy input shows moderate positive results when comparing the latter case with the current one. Results from this study can be used to support research and decision making to assess the convenience of introducing alternative fuels in agricultural exploitations.

[1]  Gvidonas Labeckas,et al.  Comparative performance of direct injection diesel engine operating on ethanol, petrol and rapeseed oil blends. , 2009 .

[2]  O. Jolliet,et al.  Harmonisation of Environmental Life Cycle Assessment for Agriculture , 1997 .

[3]  Gvidonas Labeckas,et al.  Performance of direct-injection off-road diesel engine on rapeseed oil , 2006 .

[4]  Daniela Russi,et al.  An integrated assessment of a large-scale biodiesel production in Italy: Killing several birds with one stone? , 2008 .

[5]  Hans-Jürgen Dr. Klüppel,et al.  The Revision of ISO Standards 14040-3 - ISO 14040: Environmental management – Life cycle assessment – Principles and framework - ISO 14044: Environmental management – Life cycle assessment – Requirements and guidelines , 2005 .

[6]  C. Cederberg,et al.  Agricultural land use in life cycle assessment (LCA): case studies of three vegetable oil crops , 2000 .

[7]  K. Thuneke,et al.  Exhaust gas emission characteristics of rapeseed oil fuelled tractors. , 2007 .

[8]  Abul Kalam Hossain,et al.  Plant oils as fuels for compression ignition engines: a technical review and life-cycle analysis , 2010 .

[9]  Christelle Périlhon,et al.  Development of rape seed oil burners for drying and heating , 1998 .

[10]  Prem S. Bindraban,et al.  Can large-scale biofuels production be sustainable by 2020? , 2009 .

[11]  Ilya Gelfand,et al.  Energy efficiency of conventional, organic, and alternative cropping systems for food and fuel at a site in the U.S. Midwest. , 2010, Environmental science & technology.

[12]  Carles M. Gasol,et al.  Life cycle assessment of a Brassica carinata bioenergy cropping system in southern Europe. , 2007 .

[13]  Kari Eränen,et al.  Toward improved catalytic low-temperature NOx removal in diesel-powered vehicles. , 2006, Accounts of chemical research.

[14]  Amy E. Landis,et al.  Evaluating agricultural management practices to improve the environmental footprint of corn-derived ethanol , 2014 .

[15]  Hong Huo,et al.  Life-cycle assessment of energy use and greenhouse gas emissions of soybean-derived biodiesel and renewable fuels. , 2009, Environmental science & technology.

[16]  Yong He,et al.  Study on rapeseed oil as alternative fuel for a single-cylinder diesel engine , 2003 .

[17]  L. Lardon,et al.  Life-cycle assessment of biodiesel production from microalgae. , 2009, Environmental science & technology.

[18]  Simone P. Souza,et al.  Greenhouse gas emissions and energy balance of palm oil biofuel , 2010 .

[19]  Hüseyin Serdar Yücesu,et al.  The potential of using vegetable oil fuels as fuel for diesel engines , 2001 .

[20]  Stefano Pellegrini,et al.  Life-cycle assessment of a 2-MW rated power wind turbine: CML method , 2008 .

[21]  Bhaskar Singh,et al.  Towards a sustainable approach for development of biodiesel from plant and microalgae , 2014 .

[22]  Gayathri Gopalakrishnan,et al.  Biofuels, land, and water: a systems approach to sustainability. , 2009, Environmental science & technology.

[23]  Alberto Bertucco,et al.  Energy profitability analysis for microalgal biocrude production , 2013 .

[24]  A. Antón,et al.  LCA of poplar bioenergy system compared with Brassica carinata energy crop and natural gas in regional scenario , 2009 .

[25]  David D. Hsu,et al.  Life cycle environmental impacts of selected U.S. ethanol production and use pathways in 2022. , 2010, Environmental science & technology.

[26]  Yolanda Cristina Massieu Trigo,et al.  Biofuels , 2015, OECD-FAO Agricultural Outlook 2021-2030.

[27]  O. M. I. Nwafor.  Emission characteristics of diesel engine running on vegetable oil with elevated fuel inlet temperature , 2004 .

[28]  K. Mulder,et al.  Energy Return on Investment: Toward a Consistent Framework , 2008, Ambio.

[29]  Deli Chen,et al.  Simulation of N2O emissions from rain-fed wheat and the impact of climate variation in southeastern Australia , 2008, Plant and Soil.

[30]  Keith A. Smith,et al.  N 2 O release from agro-biofuel production negates global warming reduction by replacing fossil fuels , 2007 .

[31]  J. Lampurlanés,et al.  Alternative crop rotations under Mediterranean no-tillage conditions: biomass, grain yield, and water-use efficiency. , 2009 .

[32]  M. Huijbregts,et al.  Biogenic greenhouse gas emissions linked to the life cycles of biodiesel derived from European rapeseed and Brazilian soybeans , 2008 .

[33]  R. Heijungs,et al.  Life cycle assessment An operational guide to the ISO standards , 2001 .

[34]  Francesco Cherubini,et al.  GHG balances of bioenergy systems – Overview of key steps in the production chain and methodological concerns , 2010 .

[35]  Engracia Madejón,et al.  Effect of long-term conservation tillage on soil biochemical properties in Mediterranean Spanish areas , 2009 .

[36]  Baquero Grau,et al.  Small-scale production of straight vegetable oil from rapeseed and its use as biofuel in the Spanish territory , 2010 .

[37]  O. M. I. Nwafor,et al.  The effect of elevated fuel inlet temperature on performance of diesel engine running on neat vegetable oil at constant speed conditions , 2003 .

[38]  J. Goldemberg,et al.  Are biofuels a feasible option , 2009 .

[39]  Wouter Achten,et al.  Life cycle assessment of a palm oil system with simultaneous production of biodiesel and cooking oil in Cameroon. , 2010, Environmental science & technology.