Separation of CO2 from CH4 by using gas–liquid membrane contacting process

Abstract The separation of carbon dioxide (CO 2 ) from methane (CH 4 ) by using a gas–liquid membrane contactor was studied in order to confirm the potential of the process. The experiments were performed in a membrane contactor constructed with 0.2 μm pore size microporous PVDF hollow fibers. Pure water, aqueous sodium hydroxide (NaOH) solution and aqueous monoethanolamine (MEA) solution were employed as the absorbents. Sodium chloride (NaCl) was also used as an additive in the NaOH aqueous solution. The effects of operating parameters such as the gas and liquid velocity, concentration of NaOH solution, absorbent temperature, and NaCl concentration on the CO 2 flux were investigated along with the mass transfer analysis of the process. In addition, the impacts of the flow pattern and the membrane module packing density as well as the long-term performance were also investigated, aiming to obtain a full picture and a deep insight on the system. It was found that the CO 2 flux was enhanced by the increase of NaOH solution concentration, NaOH solution temperature and the CO 2 volume fraction in the feed stream, but the increase of water temperature resulted in decreasing the CO 2 flux. The retentate selectivity obtained in this work was not satisfactory due to the laboratory scale of the membrane module used. However, the percentage of CH 4 recovery was very high, suggesting that no significant CH 4 loss took place during the operation. Counter-current flow mode took the advantage of higher mass transfer over co-current one, and the CO 2 flux increased with increasing membrane module packing density. Long-term performance tests showed that the NaOH solution was more suitable than other absorbents to be applied to the PVDF microporous hollow fiber contactors, as the NaOH aqueous solution can provide a higher separation performance and the CO 2 flux was kept almost unchanged over a long period of operation. Furthermore, the PVDF membrane gave the membrane resistance around 22% of the total resistance for pure CO 2 absorption in water.

[1]  A. E. Jansen,et al.  CO2 separation with polyolefin membrane contactors and dedicated absorption liquids: performances and prospects , 2002 .

[2]  J. Navaza,et al.  Density and Viscosity of Aqueous Solutions of Sodium Dithionite, Sodium Hydroxide, Sodium Dithionite + Sucrose, and Sodium Dithionite + Sodium Hydroxide + Sucrose from 25 °C to 40 °C , 1996 .

[3]  V. Teplyakov,et al.  Computer design of recycle membrane contactor systems for gas separation , 2007 .

[4]  Matthias Wessling,et al.  Composite hollow fiber gas–liquid membrane contactors for olefin/paraffin separation , 2004 .

[5]  Rong Wang,et al.  Influence of membrane wetting on CO2 capture in microporous hollow fiber membrane contactors , 2005 .

[6]  Rong Wang,et al.  Modeling and experimental study of CO2 absorption in a hollow fiber membrane contactor , 2006 .

[7]  V. Chen,et al.  Shell-side mass transfer performance of randomly packed hollow fiber modules , 2000 .

[8]  Eric Favre,et al.  Carbon dioxide recovery from post-combustion processes: Can gas permeation membranes compete with absorption? , 2007 .

[9]  Geert Versteeg,et al.  Solubility and diffusivity of acid gases (carbon dioxide, nitrous oxide) in aqueous alkanolamine solutions , 1988 .

[10]  A. Schumpe,et al.  Estimation of gas solubilities in salt solutions at temperatures from 273 K to 363 K , 1996 .

[11]  Paitoon Tontiwachwuthikul,et al.  Using polypropylene and polytetrafluoroethylene membranes in a membrane contactor for CO2 absorption , 2006 .

[12]  Edward L Cussler,et al.  Microporous hollow fibers for gas absorption : II. Mass transfer across the membrane , 1985 .

[13]  Chun Cao,et al.  Chemical cross-linking modification of 6FDA-2,6-DAT hollow fiber membranes for natural gas separation , 2003 .

[14]  Zhi Wang,et al.  Experiments and simulation of CO2 removal by mixed amines in a hollow fiber membrane module , 2006 .

[15]  Rong Wang,et al.  Effect of membrane structure on mass-transfer in the membrane gas–liquid contacting process using microporous PVDF hollow fibers , 2006 .

[16]  S. A. Stern,et al.  Hybrid processes for the removal of acid gases from natural gas , 1998 .

[17]  Ming-Chien Yang,et al.  Designing hollow‐fiber contactors , 1986 .

[18]  H. Kumazawa,et al.  Chemical kinetics of the reaction of carbon dioxide with ethanolamines in nonaqueous solvents , 1985 .

[19]  Rong Wang,et al.  Modeling of CO2 capture by three typical amine solutions in hollow fiber membrane contactors , 2004 .

[20]  S. A. Stern,et al.  Polymers for gas separations: the next decade , 1994 .

[21]  Edward L Cussler,et al.  Microporous hollow fibers for gas absorption. I. Mass transfer in the liquid , 1985 .

[22]  Kamalesh K. Sirkar,et al.  Other New Membrane Processes , 1992 .

[23]  Marcel Mulder,et al.  Basic Principles of Membrane Technology , 1991 .

[24]  Kamalesh K. Sirkar,et al.  Gas absorption studies in microporous hollow fiber membrane modules , 1993 .

[25]  K. Sirkar,et al.  Membrane‐based absorption of VOCs from a gas stream , 1996 .

[26]  Matthias Wessling,et al.  Super selective membranes in gas-liquid membrane contactors for olefin/paraffin separation , 2004 .

[27]  Jing-liang Li,et al.  Review of CO2 absorption using chemical solvents in hollow fiber membrane contactors , 2005 .

[28]  Tai‐Shung Chung,et al.  Development of asymmetric 6FDA-2,6DAT hollow fiber membranes for CO2/CH4 separation. Part 2. Suppression of plasticization , 2003 .

[29]  George P. Sakellaropoulos,et al.  A study of mass transfer resistance in membrane gas–liquid contacting processes , 2006 .

[30]  A. Górak,et al.  Kinetics of the gas-liquid reaction between carbon dioxide and hydroxide ions , 2002 .

[31]  H. A. Rangwala.  Absorption of carbon dioxide into aqueous solutions using hollow fiber membrane contactors , 1996 .

[32]  Kefa Cen,et al.  Experimental study on the separation of CO2 from flue gas using hollow fiber membrane contactors without wetting , 2007 .

[33]  F. Chenlo,et al.  Kinematic viscosity and water activity of aqueous solutions of glycerol and sodium chloride , 2004 .