Design Rules for Single-Mode and Polarization-Independent Silicon-on-Insulator Rib Waveguides Using Stress Engineering

There is a trend towards miniaturization of silicon photonic circuits due to superior performance and small cost. Design rules that must be imposed on the geometry of optical waveguides to make them behave as polarization-independent and single-mode devices are well known for waveguides with relatively large cross sections and for some small cross-sectional rib waveguides with vertical sidewalls and an air top cladding. The influence of the top oxide cover on waveguide birefringence was analyzed recently, but only for relatively large cross-sectional waveguides. This paper reports simulations for both single-mode and polarization-independent behavior for small cross-sectional waveguides with variable rib width, etch depth, top oxide cover thickness, and side-wall angle. The results show that the stress-induced effects must be taken into account to satisfy both requirements. Design rules to maintain birefringence-free operation and to satisfy single-mode behavior for small rib silicon-on-insulator (SOI) waveguides are presented.

[1]  A. Vonsovici,et al.  The single-mode condition for semiconductor rib waveguides with large cross section , 1998 .

[2]  B. Timotijevic.  Auto-regressive optical filters in silicon-on-insulator waveguides. , 2007 .

[3]  O. Powell,et al.  Single-mode condition for silicon rib waveguides , 2002 .

[4]  S. Timoshenko,et al.  Theory Of Elasticity. 2nd Ed. , 1951 .

[5]  A. Koster,et al.  Polarization-independent single-mode rib waveguides on silicon-on-insulator for telecommunication wavelengths , 2002 .

[6]  T Kawanishi,et al.  Ultrafast all-optical switching by cross-absorption modulation in silicon wire waveguides. , 2005, Optics express.

[7]  Richard A. Soref,et al.  Silicon waveguided components for the long-wave infrared regionThis article was submitted to the spe , 2006 .

[8]  Graham T. Reed,et al.  Multi-stage racetrack resonator filters in silicon-on-insulator , 2006 .

[9]  G. Mashanovich,et al.  Silicon photonic waveguides for near- and mid-infrared regions , 2007 .

[10]  K. Kawano,et al.  Introduction to optical waveguide analysis : solving Maxwell's equations and the Schrödinger equation , 2001 .

[11]  M. Paniccia,et al.  A continuous-wave Raman silicon laser , 2005, Nature.

[12]  D. Van Thourhout,et al.  Low-loss SOI photonic wires and ring resonators fabricated with deep UV lithography , 2004, IEEE Photonics Technology Letters.

[13]  R. Soref,et al.  Large single-mode rib waveguides in GeSi-Si and Si-on-SiO/sub 2/ , 1991 .

[14]  N. G. Tarr,et al.  Birefringence control using stress engineering in silicon-on-insulator (SOI) waveguides , 2005, Journal of Lightwave Technology.

[15]  Nahum Izhaky,et al.  High-speed optical modulation based on carrier depletion in a silicon waveguide. , 2007, Optics express.

[16]  P. Dumon,et al.  Compact wavelength router based on a Silicon-on-insulator arrayed waveguide grating pigtailed to a fiber array. , 2006, Optics express.

[17]  K. Okamoto,et al.  Stress analysis of optical fibers by a finite element method , 1981 .

[18]  B. Lamontagne,et al.  Eliminating the birefringence in silicon-on-insulator ridge waveguides by use of cladding stress. , 2004, Optics letters.

[19]  Graham T. Reed,et al.  Polarization-independent optical racetrack resonators using rib waveguides on silicon-on-insulator , 2004 .

[20]  M. Huang.  Stress effects on the performance of optical waveguides , 2003 .

[21]  Masanori Koshiba,et al.  Stress analysis method for elastically anisotropic material based optical waveguides and its application to strain-induced optical waveguides , 1999 .

[22]  Masayuki Okuno,et al.  Birefringence control of silica waveguides on Si and its application to a polarization-beam splitter/switch , 1994 .

[23]  Yoshinori Hibino,et al.  Low-loss waveguides written with a femtosecond laser for flexible interconnection in a planar light-wave circuit. , 2005, Optics letters.

[24]  C. Gunn,et al.  CMOS photonics/spl trade/ - SOI learns a new trick , 2005, 2005 IEEE International SOI Conference Proceedings.

[25]  P. Sewell,et al.  The single-mode condition for silicon-on-insulator optical rib waveguides with large cross section , 2004, Journal of Lightwave Technology.

[27]  Andre Delage,et al.  Stress-induced birefringence in silicon-on-insulator (SOI) waveguides , 2004, SPIE OPTO.

[28]  K. Kawano,et al.  Introduction to Optical Waveguide Analysis , 2001 .

[29]  Graham T. Reed,et al.  Silicon Photonic Waveguides , 2008 .

[30]  R. Scarmozzino,et al.  Numerical techniques for modeling guided-wave photonic devices , 2000, IEEE Journal of Selected Topics in Quantum Electronics.