Thermodynamic Analysis and Sizing of a Small Scale Solar Thermal Power System Based on Organic Rankine Cycle

This paper presents the feasibility analysis of a small-scale low-temperature solar organic Rankine cycle power system. The heat transfer fluid for running the organic Rankine cycle system is hot water with a temperature of 120 °C provided by an array of evacuated tube solar collectors. The performance of the solar organic Rankine cycle system was investigated using two different working fluids over a wide range of the evaporation temperature. Technical and economic indicators such as the required solar collector aperture area, the total heat transfer surface area of the heat exchangers and the volume flow ratio between the outlet and inlet of the expander are among the key parameters used to evaluate the solar organic Rankine cycle. Thermolib toolbox 5.2 in conjunction with MATLAB/Simulink was used to predict the variation of the system performance. The results showed that the solar organic Rankine cycle system is able to achieve an overall system efficiency of 6.75% using a relatively low-temperature heat source. The results also showed that the solar organic Rankine cycle system requires smaller evacuated tube solar collector and heat exchanger areas when R245fa is used as the working fluid.

[1]  Aaas News,et al.  Book Reviews , 1893, Buffalo Medical and Surgical Journal.

[2]  Wei Yu,et al.  Dynamic modelling and validation of a commercial scale geothermal organic rankine cycle power plant , 2016 .

[3]  Ulli Drescher,et al.  Fluid selection for the Organic Rankine Cycle (ORC) in biomass power and heat plants , 2007 .

[4]  Farid Chejne,et al.  A technical, economical and market review of organic Rankine cycles for the conversion of low-grade heat for power generation , 2012 .

[5]  Hong Guang Zhang,et al.  Performance analysis of a novel system combining a dual loop organic Rankine cycle (ORC) with a gasoline engine , 2012 .

[6]  H. Müller-Steinhagen,et al.  Solar thermal power plants , 2009 .

[7]  Markus Preißinger,et al.  Low grade waste heat recovery with subcritical and supercritical Organic Rankine Cycle based on natural refrigerants and their binary mixtures , 2015 .

[8]  V. Maizza,et al.  Unconventional working fluids in organic Rankine-cycles for waste energy recovery systems , 2001 .

[9]  Khaled Hossin,et al.  Performance Evaluation for a 10 kW Solar Organic Rankine Cycle Power System to Operate in the UK Climate Conditions , 2015 .

[10]  Ibrahim Dincer,et al.  Development and analysis of a solar and wind energy based multigeneration system , 2015 .

[11]  Daniele Fiaschi,et al.  Thermodynamic analysis of two micro CHP systems operating with geothermal and solar energy , 2012 .

[12]  T. Kiatsiriroat,et al.  Thermodynamic performance analysis of a R245fa organic Rankine cycle (ORC) with different kinds of heat sources at evaporator , 2019, Case Studies in Thermal Engineering.

[13]  Bertrand F. Tchanche,et al.  Fluid selection for a low-temperature solar organic Rankine cycle , 2009 .

[14]  S. Quoilin,et al.  Performance and design optimization of a low-cost solar organic Rankine cycle for remote power generation , 2011 .

[15]  George Papadakis,et al.  Exergy analysis of micro-organic Rankine power cycles for a small scale solar driven reverse osmosis desalination system , 2010 .

[16]  T. L. Bergman,et al.  PRINCIPLES OF HEAT AND MASS TRANSFER SEVENTH EDITION , 2013 .

[17]  Ben-Ran Fu,et al.  Performance of a 250 kW Organic Rankine Cycle System for Off-Design Heat Source Conditions , 2014 .

[18]  E. Stefanakos,et al.  A REVIEW OF THERMODYNAMIC CYCLES AND WORKING FLUIDS FOR THE CONVERSION OF LOW-GRADE HEAT , 2010 .

[19]  Nicola Pearsall,et al.  Statistical investigation of the optimal averaging time for solar irradiance on horizontal and vertical surfaces in the UK , 2000 .

[20]  Ennio Macchi,et al.  Efficiency Prediction for Axial-Flow Turbines Operating with Nonconventional Fluids , 1981 .

[21]  Marco Badami,et al.  Preliminary design and controlling strategies of a small-scale wood waste Rankine Cycle (RC) with a reciprocating steam engine (SE) , 2009 .

[22]  Lourdes García-Rodríguez,et al.  Analysis and optimization of the low-temperature solar organic Rankine cycle (ORC) , 2010 .

[23]  Adrienne S. Lavine,et al.  Principles of Heat and Mass Transfer , 2018 .

[24]  Jiang Wang,et al.  Performance evaluation of a low-temperature solar Rankine cycle system utilizing R245fa , 2010 .

[25]  Vincent Lemort,et al.  Techno-economic survey of Organic Rankine Cycle (ORC) systems , 2013 .

[26]  Li Jing,et al.  Design and analysis of a novel low-temperature solar thermal electric system with two-stage collectors and heat storage units , 2011 .

[27]  Wang Lipeng,et al.  Performance analysis and working fluids selection of solar powered organic Rankine-vapor compression ice maker , 2013 .

[28]  Andreas Schuster,et al.  Energetic and economic investigation of Organic Rankine Cycle applications , 2009 .

[29]  Noboru Yamada,et al.  Study on thermal efficiency of low- to medium-temperature organic Rankine cycles using HFO−1234yf , 2012 .

[30]  Guo Tao,et al.  Performance comparison and parametric optimization of subcritical Organic Rankine Cycle (ORC) and transcritical power cycle system for low-temperature geothermal power generation , 2011 .

[31]  Li Zhao,et al.  A review of working fluid and expander selections for organic Rankine cycle , 2013 .

[32]  Mortaza Yari,et al.  Utilization of waste heat from GT-MHR for power generation in organic Rankine cycles. , 2010 .