Performance analysis of a Kalina cycle for a central receiver solar thermal power plant with direct steam generation

Abstract Solar thermal power plants have attracted increasing interest in the past few years – with respect to both the design of the various plant components, and extending the operation hours by employing different types of storage systems. One approach to improve the overall plant efficiency is to use direct steam generation with water/steam as both the heat transfer fluid in the solar receivers and the cycle working fluid. This enables operating the plant with higher turbine inlet temperatures. Available literature suggests that it is feasible to use ammonia-water mixtures at high temperatures without corroding the equipment by using suitable additives with the mixture. The purpose of the study reported here was to investigate if there is any benefit of using a Kalina cycle for a direct steam generation, central receiver solar thermal power plant with high live steam temperature (450 °C) and pressure (over 100 bar). Thermodynamic performance of the Kalina cycle in terms of the plant exergy efficiency was evaluated and compared with a simple Rankine cycle. The rates of exergy destruction for the different components in the two cycles were also calculated and compared. The results suggest that the simple Rankine cycle exhibits better performance than the Kalina cycle when the heat input is only from the solar receiver. However, when using a two-tank molten-salt storage system as the primary source of heat input, the Kalina cycle showed an advantage over the simple Rankine cycle because of about 33 % reduction in the storage requirement. The solar receiver showed the highest rate of exergy destruction for both the cycles. The rates of exergy destruction in other components of the cycles were found to be highly dependent on the amount of recuperation, and the ammonia mass fraction and pressure at the turbine inlet.

[1]  Chul Ho Han,et al.  Effects of ammonia concentration on the thermodynamic performances of ammonia–water based power cycles , 2012 .

[2]  Roman Adinberg.  Simulation analysis of thermal storage for concentrating solar power , 2011 .

[3]  E. Stefanakos,et al.  A REVIEW OF THERMODYNAMIC CYCLES AND WORKING FLUIDS FOR THE CONVERSION OF LOW-GRADE HEAT , 2010 .

[4]  Paul M. Mathias,et al.  Effective utilization of equations of state for thermodynamic properties in process simulation , 1984 .

[5]  R. Petela.  Exergy of undiluted thermal radiation , 2003 .

[6]  Fredrik Haglind,et al.  Feasibility of using ammonia-water mixture in high temperature concentrated solar power plants with direct vapour generation , 2014 .

[7]  谢安俊,et al.  模拟软件—ASPEN PLUS , 1995 .

[8]  Costante Mario Invernizzi,et al.  Heat recovery from Diesel engines: A thermodynamic comparison between Kalina and ORC cycles , 2010 .

[9]  Fredrik Haglind,et al.  System analysis and optimisation of a Kalina split-cycle for waste heat recovery on large marine diesel engines , 2014 .

[10]  Mounir B. Ibrahim,et al.  A Kalina Cycle Application for Power Generation , 1993 .

[11]  Markus Eck,et al.  Direct steam generation in parabolic troughs: Final results and conclusions of the DISS project , 2004 .

[12]  M. He,et al.  A review of research on the Kalina cycle , 2012 .

[13]  T. Bauer,et al.  Thermal energy storage for direct steam generation , 2011 .

[14]  Mehmet Kanoglu,et al.  Thermodynamic and economic analysis and optimization of power cycles for a medium temperature geothermal resource , 2014 .

[15]  Frank P. Incropera,et al.  Fundamentals of Heat and Mass Transfer , 1981 .

[16]  A. Abdel-azim.  Fundamentals of Heat and Mass Transfer , 2011 .

[17]  Eva Thorin,et al.  Ammonia–water power cycles for direct-fired cogeneration applications , 1998 .

[18]  Zhifeng Wang,et al.  Energy and exergy analysis of solar power tower plants , 2011 .

[19]  Fredrik Haglind,et al.  Energy and exergy analysis of the Kalina cycle for use in concentrated solar power plants with direct steam generation , 2014 .

[20]  P. Nag,et al.  Exergy analysis of the Kalina cycle , 1998 .

[21]  S. C. Kaushik,et al.  Energy and exergy analysis and optimization of Kalina cycle coupled with a coal fired steam power plant , 2013 .

[22]  Yiping Dai,et al.  Parametric analysis and optimization of a Kalina cycle driven by solar energy , 2013 .

[23]  Electo Eduardo Silva Lora,et al.  Exergetic and economic comparison of ORC and Kalina cycle for low temperature enhanced geothermal system in Brazil , 2013 .

[24]  M. M. Rahman,et al.  A supercritical Rankine cycle using zeotropic mixture working fluids for the conversion of low-grade , 2011 .