Reverse osmosis desalination: water sources, technology, and today's challenges.

Reverse osmosis membrane technology has developed over the past 40 years to a 44% share in world desalting production capacity, and an 80% share in the total number of desalination plants installed worldwide. The use of membrane desalination has increased as materials have improved and costs have decreased. Today, reverse osmosis membranes are the leading technology for new desalination installations, and they are applied to a variety of salt water resources using tailored pretreatment and membrane system design. Two distinct branches of reverse osmosis desalination have emerged: seawater reverse osmosis and brackish water reverse osmosis. Differences between the two water sources, including foulants, salinity, waste brine (concentrate) disposal options, and plant location, have created significant differences in process development, implementation, and key technical problems. Pretreatment options are similar for both types of reverse osmosis and depend on the specific components of the water source. Both brackish water and seawater reverse osmosis (RO) will continue to be used worldwide; new technology in energy recovery and renewable energy, as well as innovative plant design, will allow greater use of desalination for inland and rural communities, while providing more affordable water for large coastal cities. A wide variety of research and general information on RO desalination is available; however, a direct comparison of seawater and brackish water RO systems is necessary to highlight similarities and differences in process development. This article brings to light key parameters of an RO process and process modifications due to feed water characteristics.

[1]  Menachem Elimelech,et al.  Calcium sulfate (gypsum) scaling in nanofiltration of agricultural drainage water , 2002 .

[2]  P. Glueckstern,et al.  Optimization of boron removal in old and new SWRO systems , 2003 .

[3]  H. Al-Barwani,et al.  Sensitivity of hypersaline Arabian Gulf to seawater desalination plants , 2007 .

[4]  A. M. Helal,et al.  Economic feasibility of alternative designs of a PV-RO desalination unit for remote areas in the United Arab Emirates , 2008 .

[5]  Veronique Bonnelye,et al.  Reverse osmosis on open intake seawater: pre-treatment strategy , 2004 .

[6]  H. Farag,et al.  Feed salinity and cost-effectiveness of energy recovery in reverse osmosis desalination , 1998 .

[7]  Yoram Cohen,et al.  Low-pressure RO membrane desalination of agricultural drainage water , 2003 .

[8]  M. Murakami.  Managing Water for Peace in the Middle East: Alternative Strategies , 1995 .

[9]  Chanhyuk Park,et al.  Variation and prediction of membrane fouling index under various feed water characteristics , 2006 .

[10]  N B Munro,et al.  Drinking-water standards. , 1986, Environmental science & technology.

[11]  J. Cavard,et al.  Comparison of three antiscalants, as applied to the treatment of water from the River Oise☆ , 2002 .

[12]  J. E. Blank,et al.  The real cost of desalted water and how to reduce it further , 2007 .

[13]  Bryce S. Richards,et al.  System Design and Performance Testing of a Hybrid Membrane – Photovoltaic Desalination System , 2010 .

[14]  N. Vlachakis,et al.  Energy consumption and membrane replacement cost for seawater RO desalination plants , 2003 .

[15]  J. Otero,et al.  Three independent ways to obtain information on pore size distributions of nanofiltration membranes , 2008 .

[16]  P.A.C. Bonné,et al.  Scaling control of RO membranes and direct treatment of surface water , 2000 .

[17]  Jamal O. Jaber,et al.  Brackish groundwater treatment by reverse osmosis in Jordan , 2004 .

[18]  Essam E.A. Ghafour.  Enhancing RO system performance utilizing antiscalants , 2003 .

[19]  Andrea I. Schäfer,et al.  Social aspects of a solar-powered desalination unit for remote Australian communities , 2007 .

[20]  Integrated Membrane Desalination Systems Potential Benefits of Combined Technology , .

[21]  Daniel A. Okun,et al.  Guidelines for water reuse. , 1992 .

[22]  U. Merten,et al.  Flow Relationships in Reverse Osmosis , 1963 .

[23]  Kelley Oj.  Agency for International Development. , 1973 .

[24]  William T. Andrews,et al.  A twelve-year history of large scale application of work-exchanger energy recovery technology☆ , 2001 .

[25]  Jolanta Bohdziewicz,et al.  The application of reverse osmosis and nanofiltration to the removal of nitrates from groundwater , 1999 .

[26]  S. O. Pérez Báez,et al.  Development of the most adequate pre-treatment for high capacity seawater desalination plants with open intake , 2005 .

[27]  Volker Horstmann,et al.  Small scale photovoltaic desalination for rural water supply - demonstration plant in Gran Canaria , 1998 .

[28]  V. S. Vaidhyanathan,et al.  Transport phenomena , 2005, Experientia.

[29]  R. Service,et al.  Desalination Freshens Up , 2006, Science.

[30]  P. Glueckstern,et al.  Boron removal in brackish water desalination systems , 2007 .

[31]  Yoram Cohen,et al.  Non-thermal Process for Recovering Reverse Osmosis Concentrate : Process Chemistry and Kinetics , 2003 .

[32]  C. V. Vedavyasan.  Pretreatment trends — an overview , 2007 .

[33]  Antonio Piacentino,et al.  Energy saving with MSF-RO series desalination plants , 2003 .

[34]  Donald R Paul.  The role of membrane pressure in reverse osmosis , 1972 .

[35]  Pascal Jaouen,et al.  Brackish groundwater treatment by nanofiltration, reverse osmosis and electrodialysis in Tunisia: performance and cost comparison , 2007 .

[36]  Nicos X. Tsiourtis.  Desalination and the environment , 2001 .

[37]  Bryce S. Richards,et al.  System design and performance testing of a hybrid membrane — photovltaic desalination system , 2005 .

[38]  Amanda Crawford.  The Future of Desalination in Texas , 2005 .

[39]  Jia Xu,et al.  A pilot study of UF pretreatment without any chemicals for SWRO desalination in China , 2007 .

[40]  P. Glueckstern,et al.  Boron removal from the permeate of a large SWRO plant in Eilat , 2005 .

[41]  Osman A. Hamed,et al.  Overview of hybrid desalination systems — current status and future prospects , 2005 .

[42]  S. Baron,et al.  The economics of desalination , 1966, IEEE Spectrum.

[43]  H. Zidouri,et al.  Desalination of Morocco and presentation of design and operation of the Laayoune seawater reverse osmosis plant , 2000 .

[44]  K. Glucina,et al.  Assessment of UF pretreatment prior RO membranes for seawater desalination , 1999 .

[45]  Vassilis Gekas,et al.  Mass transfer in the membrane concentration polarization layer under turbulent cross flow , 1987 .

[46]  M. Wilf,et al.  Optimization of seawater RO systems design , 2001 .

[47]  R. Tol,et al.  Implications of desalination for water resources in China — an economic perspective , 2004 .

[48]  C. Baird,et al.  The pilot study. , 2000, Orthopedic nursing.

[49]  S. Bouguecha,et al.  Coupling of membrane processes for brackish water desalination , 2007 .

[50]  Gilbert Galjaard,et al.  Monitoring particulate fouling in membrane systems , 1998 .

[51]  Marian Turek,et al.  Seawater desalination and salt production in a hybrid membrane-thermal process , 2003 .

[52]  Mohamed A. Dawoud,et al.  Desalination of brackish groundwater in Egypt , 2003 .

[53]  Seungkwan Hong,et al.  Integrated Membrane Systems , 2000 .

[54]  R. Baker.  Membrane Technology and Applications , 1999 .

[55]  A. Brehant,et al.  Assessment of ultrafiltration as a pretreatment of reverse osmosis membranes for surface seawater desalination , 2003 .

[56]  Maria D. Kennedy,et al.  Applications of the MFI-UF to measure and predict particulate fouling in RO systems , 2003 .

[57]  M. C. Amiri,et al.  Enhancing permeate flux in a RO plant by controlling membrane fouling , 2007 .

[58]  Seong-Yong Moon,et al.  Pilot plant demonstration of energy reduction for RO seawater desalination through a recovery increase , 2007 .

[59]  I. Karagiannis,et al.  Water desalination cost literature: review and assessment , 2008 .

[60]  Frederick Bloetscher,et al.  Defining the Concentrate Disposal Problem & Identifying Potential Solutions , 2006 .

[61]  Chip Harris,et al.  Energy recovery for membrane desalination , 1999 .

[62]  Subhajyoti Das,et al.  The World's Water 2006-2007 , 2009 .

[63]  Mitsumasa Okada,et al.  Removal of oil pollutants in seawater as pretreatment of reverse osmosis desalination process , 1999 .

[64]  I. Madany,et al.  Impact of a desalination plant on the physical and chemical properties of seawater, Bahrain , 1992 .

[65]  Don W. Green,et al.  Perry's Chemical Engineers' Handbook , 2007 .

[66]  J. G. Wijmans,et al.  The solution-diffusion model: a review , 1995 .

[67]  Amy E. Childress,et al.  Zeta potential of commercial RO membranes: influence of source water type and chemistry , 2001 .

[68]  Bryce S. Richards,et al.  Design considerations for a solar-powered desalination system for remote communities in Australia☆ , 2002 .

[69]  K. Gaid,et al.  Le dessalement des eaux par osmose inverse: l'expérience de Véolia Water , 2007 .

[70]  Sidney Loeb,et al.  Sea Water Demineralization by Means of an Osmotic Membrane , 1963 .

[71]  J. C. Schippers,et al.  The modified fouling index, a method of determining the fouling characteristics of water , 1980 .

[72]  H. Al-Barwani,et al.  Calculating the environmental cost of seawater desalination in the Arabian marginal seas , 2005 .

[73]  Yoram Cohen,et al.  Diagnostic characterization of gypsum scale formation and control in RO membrane desalination of brackish water , 2006 .

[74]  Bradley M. Coffey,et al.  Pilot-scale testing of reverse osmosis using conventional treatment and microfiltration , 2003 .

[75]  K. T. Chuaa,et al.  Pretreatment of seawater : Results of pilot trials in Singapore , 2003 .

[76]  S. G. Yiantsios,et al.  Colloidal fouling of RO membranes: an overview of key issues and efforts to develop improved prediction techniques , 2005 .

[77]  Amy E. Childress,et al.  Effect of humic substances and anionic surfactants on the surface charge and performance of reverse osmosis membranes , 1998 .

[78]  Cyril Jacob,et al.  Seawater desalination: Boron removal by ion exchange technology , 2007 .

[79]  Bruce M. Watson,et al.  Blending and post-treatment protocols for SDWA compliance — Hollywood (FL) water plant , 1995 .

[80]  D. Kolpin,et al.  A national reconnaissance for pharmaceuticals and other organic wastewater contaminants in the United States--II) untreated drinking water sources. , 2008, The Science of the total environment.

[81]  S. Bouguecha,et al.  Small scale desalination pilots powered by renewable energy sources: case studies , 2005 .

[82]  Andrew L. Zydney,et al.  Stagnant film model for concentration polarization in membrane systems , 1997 .

[83]  Steven Walker,et al.  Reverse Osmosis Treatment Facilities: Innovative Post-Treatment Stabilization Solutions , 2007 .

[84]  Noreddine Ghaffour,et al.  Overview of the cost of desalinated water and costing methodologies , 2007 .

[85]  Jack Gilron,et al.  WAIV — wind aided intensified evaporation for reduction of desalination brine volume , 2003 .

[86]  E. von Münch,et al.  Impact of solar energy cost on water production cost of seawater desalination plants in Egypt , 2008 .

[87]  P. Gleick.  The World's Water 2000-2001: The Biennial Report On Freshwater Resources , 1998 .

[88]  Nidal Hilal,et al.  A comprehensive review of nanofiltration membranes:Treatment, pretreatment, modelling, and atomic force microscopy , 2004 .

[89]  Bruno Sauvet-Goichon,et al.  Ashkelon desalination plant — A successful challenge , 2007 .

[90]  Daniel Guevara,et al.  The El Coloso (Chile) reverse osmosis plant , 2007 .

[91]  Thomas Melin,et al.  State-of-the-art of reverse osmosis desalination , 2007 .

[92]  Essam E. Khalil.  Potable water technology development in Egypt , 2001 .

[93]  H. Z. Sarikaya,et al.  Application of the membrane technology to control ammonia in surface water , 2001 .

[94]  Daxin Wang,et al.  Modeling the separation performance of nanofiltration membranes for the mixed salts solution , 2006 .

[95]  Miguel Angel Sanza,et al.  Fujairah reverse osmosis plant: 2 years of operation , 2007 .

[96]  Pierre Aimar,et al.  A unifying model for concentration polarization, gel-layer formation and particle deposition in cross-flow membrane filtration of colloidal suspensions , 2002 .

[97]  M. Mohsen.  Water strategies and potential of desalination in Jordan , 2007 .

[98]  Seungkwan Hong,et al.  Combined influence of membrane surface properties and feed water qualities on RO/NF mass transfer, a pilot study. , 2005, Water research.

[99]  Maria D. Kennedy,et al.  The modified fouling index using ultrafiltration membranes (MFI-UF): characterisation, filtration mechanisms and proposed reference membrane , 2002 .

[100]  H. Winters,et al.  Twenty years experience in seawater reverse osmosis and how chemicals in pretreatment affect fouling of membranes , 1997 .

[101]  M. Abdel-Jawad,et al.  Pilot study of hybrid systems , 1998 .

[102]  Peer C. Kamp,et al.  UF/RO treatment plant Heemskerk: from challenge to full scale application , 2000 .

[103]  Cong-jie Gao,et al.  Study on a novel antifouling polyamide-urea reverse osmosis composite membrane (ICIC-MPD) III. Analysis of membrane electrical properties , 2008 .

[104]  M. A. Mandil,et al.  Future needs for desalination in South Mediterranean countries , 2003 .

[105]  A. Gorenflo,et al.  Nanofiltration of a German groundwater of high hardness and NOM content: performance and costs , 2003 .

[106]  Walid H. Shayya,et al.  Brine disposal from reverse osmosis desalination plants in Oman and the United Arab Emirates , 2001 .

[107]  B. Boegli,et al.  Eastern Municipal Water District RO treatment/saline vegetated wetlands pilot study , 1994 .

[108]  Steven L. Bryant,et al.  Modeling injection well performance during deep-well injection of liquid wastes , 2000 .

[109]  Aliza Ravizky,et al.  Salt production by the evaporation of SWRO brine in Eilat: a success story , 2007 .

[110]  W. Richard Bowen,et al.  Modelling the performance of membrane nanofiltration - critical assessment and model development , 2002 .

[111]  N. P. Isaias,et al.  Experience in reverse osmosis pretreatment , 2001 .

[112]  G. Pearce.  The case for UF/MF pretreatment to RO in seawater applications , 2007 .

[113]  E. Tzen,et al.  Design of a stand alone PV - desalination system for rural areas , 1998 .

[114]  Peter S. Cartwright.  Membranes : A review of membrane technologies for water reuse applications , 2005 .

[115]  Juan A. Reverter,et al.  Las Palmas III — the success story of brine staging , 2001 .

[116]  Mohamed A. Dawoud,et al.  The role of desalination in augmentation of water supply in GCC countries , 2005 .

[117]  Wolfgang Czolkoss,et al.  Pilot tests of Multibore UF membrane at Addur SWRO Desalination Plant, Bahrain , 2007 .

[118]  Shichang Xu,et al.  Experimental studies on dynamic process of energy recovery device for RO desalination plants , 2004 .

[119]  Guy Fipps,et al.  Irrigation Water Quality Standards and Salinity Management Strategies , 2003 .

[120]  Graeme Pearce,et al.  Pretreatment options for large scale SWRO plants: case studies of OF trials at Kindasa, Saudi Arabia, and conventional pretreatment in Spain , 2004 .

[121]  Asam Almulla,et al.  Developments in high recovery brackish water desalination plants as part of the solution to water quantity problems , 2003 .

[122]  Thijs Peters,et al.  Reduction of the energy demand for seawater RO with the pressure exchange systems PES , 2001 .

[123]  P. K. Tewari,et al.  Assessment of an ultrafiltration pre-treatment system for a seawater reverse osmosis plant , 2006 .

[124]  Johannes S. Vrouwenvelder,et al.  Biofouling potential of chemicals used for scale control in RO and NF membranes , 2000 .

[125]  Mika Mänttäri,et al.  Effect of salt mixture concentration on fractionation with NF membranes , 2006 .

[126]  J. J. Morgan,et al.  Aquatic Chemistry: Chemical Equilibria and Rates in Natural Waters , 1970 .

[127]  Chris Mooij.  Hamma Water Desalination Plant : planning and funding , 2007 .

[128]  Eugene R. Reahl.  Half A Century of Desalination With Electrodialysis , 2006 .

[129]  Richard W. Atwater,et al.  The West Basin desalter project: A viable alternative , 1995 .

[130]  Carlo Vandecasteele,et al.  Reuse, treatment, and discharge of the concentrate of pressure-driven membrane processes. , 2003, Environmental science & technology.

[131]  P. Glueckstern.  Design and operation of medium- and small-size desalination plants in remote areas : New perspective for improved reliability, durability and lower costs , 1999 .

[132]  K. A. Matis,et al.  Application of flotation as a pretreatment process during desalination , 2008 .

[133]  Bachir Bouchekima,et al.  Brakish water desalination with heat recovery , 2001 .

[134]  Yoram Cohen,et al.  High recovery membrane desalting of low-salinity brackish water: Integration of accelerated precipitation softening with membrane RO , 2007 .

[135]  R. L. Riley,et al.  Transport properties of cellulose acetate osmotic membranes , 1965 .

[136]  M. Pontie,et al.  Selective demineralization of water by nanofiltration application to the defluorination of brackish water. , 2001, Water research.

[137]  D. Sedlak,et al.  Peer reviewed: understanding microcontaminants in recycled water. , 2000, Environmental science & technology.

[138]  A. Hafez,et al.  Economics of seawater RO desalination in the Red Sea region, Egypt. Part 1. A case study , 2003 .

[139]  R. Tol,et al.  Evaluating the costs of desalination and water transport , 2005 .

[140]  Seong-Ho Hong,et al.  The effect of co-existing ions and surface characteristics of nanomembranes on the removal of nitrate and fluoride , 2001 .

[141]  Christopher J. Gabelich,et al.  Reducing costs for large-scale desalting plants using large-diameter, reverse osmosis membranes , 2006 .

[142]  Yoram Cohen,et al.  A dual-probe approach for evaluation of gypsum crystallization in response to antiscalant treatment , 2004 .

[143]  François Maréchal,et al.  Multi-objective optimization of RO desalination plants , 2008 .

[144]  Donald R Paul,et al.  Reformulation of the solution-diffusion theory of reverse osmosis , 2004 .

[145]  Nidal Hilal,et al.  Nanofiltration of highly concentrated salt solutions up to seawater salinity , 2005 .

[146]  Robert G. J. Edyvean,et al.  An investigation of the biological fouling in the filtration of seawater , 1998 .

[147]  David Hasson,et al.  Inception of CaSO4 scaling on RO membranes at various water recovery levels , 2001 .

[148]  Yoram Cohen,et al.  High-recovery reverse osmosis desalination using intermediate chemical demineralization , 2007 .

[149]  R. Alward,et al.  Water requirements and remote arid areas: the need for small-scale desalination , 1996 .

[150]  B. Blavoux,et al.  Alimentation et origine de la salinité de la source sous-marine de Port-Miou (Marseille–Cassis). Principale émergence d'un réseau karstique hérité du Messinien , 2004 .

[151]  David Hasson,et al.  Simple technique for measuring the concentration polarization level in a reverse osmosis system , 2000 .

[152]  Ata M. Hassan,et al.  A new approach to membrane and thermal seawater desalination processes using nanofiltration membranes (Part 1) , 1998 .

[153]  Yasumoto Magara,et al.  Development of boron reduction system for sea water desalination , 1998 .

[154]  Mohamed Gadalla,et al.  Integrating hybrid systems with existing thermal desalinationplants , 2005 .

[155]  J. Kent Kimes.  The regulation of concentrate disposal in Florida , 1995 .

[156]  Yoram Cohen,et al.  BRINE DISPOSAL FROM LAND BASED MEMBRANE DESALINATION PLANTS: A CRITICAL ASSESSMENT , 2003 .

[157]  L O R I E N,et al.  Attenuation of Wastewater-Derived Contaminants in an Effluent-Dominated River † , 2006 .

[158]  J. C. Schippers,et al.  Predicting flux decline of reverse osmosis membranes , 1981 .

[159]  D. DeMarini,et al.  Occurrence, genotoxicity, and carcinogenicity of regulated and emerging disinfection by-products in drinking water: a review and roadmap for research. , 2007, Mutation research.

[160]  Zahid Amjad,et al.  Reverse osmosis : membrane technology, water chemistry & industrial applications , 1993 .

[161]  Masaaki Ando,et al.  Separation performance of a nanofiltration membrane influenced by species and concentration of ions , 2005 .

[162]  Seymour S. Kremen,et al.  Silt density indices (SDI), percent plugging factor (%PF): their relation to actual foulant deposition , 1998 .

[163]  Menachem Elimelech,et al.  Measuring the zeta (electrokinetic) potential of reverse osmosis membranes by a streaming potential analyzer , 1994 .

[164]  E. Delyannis,et al.  Desalination by using alternative energy: Review and state-of-the-art , 2007 .

[165]  Dan Weiner,et al.  Operation experience of a solar- and wind-powered desalination demonstration plant , 2001 .

[166]  Manh Hoang,et al.  An autopsy study of a fouled reverse osmosis membrane element used in a brackish water treatment plant. , 2007, Water research.

[167]  E. G. Darton,et al.  Membrane chemical research: centuries apart☆ , 2000 .

[168]  I. S. Jaber,et al.  Technical and economic evaluation of brackish groundwater desalination by reverse osmosis (RO) process , 2004 .

[169]  Arturo A. Keller,et al.  A stochastic analysis of steady state two‐phase flow in heterogeneous media , 2005 .

[170]  James E. Miller,et al.  Review of Water Resources and Desalination Technologies , 2003 .

[171]  Eric M.V. Hoek,et al.  Modeling concentration polarization in reverse osmosis processes , 2005 .

[172]  O. J. Kelley.  Agency for International Development. , 1973, Proceedings, annual meeting of the United States Animal Health Association.

[173]  M. H. Sorour,et al.  Desalination of agricultural drainage water , 1992 .

[174]  O. Kedem,et al.  Determination of concentration-dependent transport coefficients in nanofiltration: Defining an optimal set of coefficients , 2008 .

[175]  Yasumoto Magara,et al.  Development of reverse osmosis membrane seawater desalination in Japan , 2000 .

[176]  Kandi Venkat Reddy,et al.  Review of MEDRC R&D projects , 2003 .

[177]  Menachem Elimelech,et al.  Theory of concentration polarization in crossflow filtration , 1995 .

[178]  F. Reverberi,et al.  Three year operational experience of a spiral-wound SWRO system with a high fouling potential feed water , 2007 .

[179]  Jean-Philippe Nicot,et al.  Self-sealing evaporation ponds for small inland desalination facilities and containment equivalence concepts in Texas , 2009 .

[180]  G Amy,et al.  Transport of target anions, chromate (Cr (VI)), arsenate (As (V)), and perchlorate (ClO4-), through RO, NF, and UF membranes. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[181]  Yoram Cohen,et al.  Morphometric characterization of calcium sulfate dihydrate (gypsum) scale on reverse osmosis membranes , 2005 .

[182]  David Hasson,et al.  Characterization of the effectiveness of silica anti-scalants , 2003 .

[183]  Akili D. Khawaji,et al.  A 13.3 MGD seawater RO desalination plant for Yanbu Industrial City , 2007 .

[184]  B. Freeman,et al.  Highly chlorine-tolerant polymers for desalination. , 2008, Angewandte Chemie.

[185]  Mualla Öner,et al.  The influence of polyelectrolytes architecture on calcium sulfate dihydrate growth retardation , 1998 .

[186]  Mark Wilf,et al.  The effect of feed ionic strength on salt passage through reverse osmosis membranes , 2005 .

[187]  Bart Van der Bruggen,et al.  Distillation vs. membrane filtration: overview of process evolutions in seawater desalination , 2002 .

[188]  P. Glueckstern,et al.  The impact of R&D on new technologies, novel design concepts and advanced operating procedures on the cost of water desalination , 2001 .

[189]  L. García-Rodríguez.  Renewable energy applications in desalination: state of the art , 2003 .