Exergy modeling of a new solar driven trigeneration system

Abstract In this paper, exergy modeling is used to assess the exergetic performance of a novel trigeneration system using parabolic trough solar collectors (PTSC) and an organic Rankine cycle (ORC). Four cases are considered: electrical-power, cooling-cogeneration, heating-cogeneration, and trigeneration. In this trigeneration system a single-effect absorption chiller is utilized to provide the necessary cooling energy and a heat exchanger is utilized to provide the necessary heating energy. The trigeneration system considered is examined using three modes of operation. They are: solar mode during the low-solar radiation time of the day, solar and storage mode during the high-solar radiation time of the day, and storage mode during night time. The storage mode is operated through the heat collected in a thermal storage tank during the solar and storage mode. The exergy efficiencies and exergy destruction rates are examined under the variation of the ORC evaporator pinch point temperature, ORC pump inlet temperature, and turbine inlet pressure. This study reveals that the maximum electrical-exergy efficiency for the solar mode is 7%, for the solar and storage mode is 3.5%, and for the storage mode is 3%. Alternatively, when trigeneration is used, the exergy efficiency increases noticeably. The maximum trigeneration-exergy efficiency for the solar mode is 20%, for solar and storage mode is 8%, and for the storage mode is 7%. Moreover, this study shows that the main sources of exergy destruction rate are the solar collectors and ORC evaporators. Therefore, careful selection and design of these two components are essential to reduce the exergy destructed by them and, thus, increase the exergy efficiencies of the system.

[1]  W. Beckman,et al.  Solar Engineering of Thermal Processes , 1985 .

[2]  Ulf Herrmann,et al.  Two-tank molten salt storage for parabolic trough solar power plants , 2004 .

[3]  Reinhard Radermacher,et al.  Absorption Chillers and Heat Pumps , 1996 .

[4]  Xudong Zhao,et al.  A novel hybrid heat-pipe solar collector/CHP system—Part II: theoretical and experimental investigations , 2004 .

[5]  Fahad A. Al-Sulaiman,et al.  Trigeneration: A comprehensive review based on prime movers , 2011 .

[6]  George Kosmadakis,et al.  Parametric theoretical study of a two-stage solar organic Rankine cycle for RO desalination , 2010 .

[7]  Agustín M. Delgado-Torres,et al.  Comparison of solar technologies for driving a desalination system by means of an organic Rankine cycle , 2007 .

[8]  Li Zhao,et al.  Analysis of zeotropic mixtures used in low-temperature solar Rankine cycles for power generation , 2009 .

[9]  Alberto Coronas,et al.  Modelling and optimisation of solar organic rankine cycle engines for reverse osmosis desalination , 2008 .

[10]  George Papadakis,et al.  Exergy analysis of micro-organic Rankine power cycles for a small scale solar driven reverse osmosis desalination system , 2010 .

[11]  E. Zarza,et al.  INDITEP: The first pre-commercial DSG solar power plant , 2006 .

[12]  D. Y. Goswami,et al.  Organic Working Fluids for a Combined Power and Cooling Cycle , 2005 .

[13]  Li Jing,et al.  Optimization of low temperature solar thermal electric generation with Organic Rankine Cycle in different areas , 2010 .

[14]  S. Kalogirou.  Solar Energy Engineering: Processes and Systems , 2009 .

[15]  B. Zheng,et al.  A combined power and ejector refrigeration cycle for low temperature heat sources , 2010 .

[16]  T. D. Harrison,et al.  Thermal storage experience at the MSSTF and plans for the future , 1980 .

[17]  Sotirios Karellas,et al.  Investigation of an autonomous hybrid solar thermal ORC–PV RO desalination system. The Chalki island case , 2011 .

[18]  A. S. Nafey,et al.  Combined solar organic Rankine cycle with reverse osmosis desalination process: Energy, exergy, and cost evaluations , 2010 .

[19]  M. Valenti.  Storing solar energy in salt , 1995 .

[20]  K. W. Li,et al.  Power Plant System Design , 1985 .

[21]  G. Kosmadakis,et al.  On site experimental evaluation of a low-temperature solar organic Rankine cycle system for RO desalination , 2009 .

[22]  Ibrahim Dincer,et al.  Exergy: Energy, Environment and Sustainable Development , 2007 .

[23]  Fahad A. Al-Sulaiman,et al.  Performance assessment of a novel system using parabolic trough solar collectors for combined cooling, heating, and power production , 2012 .

[24]  Michael Valenti.  The early days of incineration , 1995 .

[25]  Eduardo Zarza,et al.  Parabolic-trough solar collectors and their applications , 2010 .

[26]  D. Kearney,et al.  Survey of Thermal Energy Storage for Parabolic Trough Power Plants , 2002 .

[27]  R. Petela.  Exergy analysis of the solar cylindrical-parabolic cooker , 2005 .

[28]  Lourdes García-Rodríguez,et al.  Solar-powered Rankine cycles for fresh water production , 2007 .

[29]  C. Yaws.  Chemical properties handbook , 1999 .

[30]  M. Valdés,et al.  Solar multiple optimization for a solar-only thermal power plant, using oil as heat transfer fluid in the parabolic trough collectors , 2009 .