A pneumatic micromixer facilitating fluid mixing at a wide range flow rate for the preparation of quantum dots

A novel fluid micromixer based on pneumatic perturbation and passive structures was developed. This micromixer facilitates integration and is applicable to fluid mixing over a wide range of flow rates. The microfluidic mixing device consists of an S-shaped structure with two mixing chambers and two barriers, and two pneumatic chambers designed over the S-shaped channel. The performance of the micromixer for fluids with wide variation of flow rates was significantly improved owing to the integration of the pneumatic mixing components with the passive mixing structures. The mixing mechanism of the passive mixing structures was explored by numerical simulation, and the influencing factors on the mixing efficiency were investigated. The results showed that when using a gas pressure of 0.26 MPa and a 100 μm-thick polydimethylsiloxane (PDMS) pneumatic diaphragm, the mixing of fluids with flow rates ranging from 1 to 650 μL/min was achieved with a pumping frequency of 50 Hz. Fast synthesis of CdS quantum dots was realized using this device. Smaller particles were obtained, and the size distribution was greatly improved compared with those obtained using conventional methods.

[1]  Theodore C Marentis,et al.  Ultrasonic mixing in microfluidic channels using integrated transducers. , 2004, Analytical chemistry.

[2]  Nadine Aubry,et al.  Enhancement of microfluidic mixing using time pulsing. , 2003, Lab on a chip.

[3]  R. Austin,et al.  Hydrodynamic Focusing on a Silicon Chip: Mixing Nanoliters in Microseconds , 1998 .

[4]  S. Yao,et al.  Visualizing millisecond chaotic mixing dynamics in microdroplets: A direct comparison of experiment and simulation. , 2012, Biomicrofluidics.

[5]  Robin H. Liu,et al.  Passive mixing in a three-dimensional serpentine microchannel , 2000, Journal of Microelectromechanical Systems.

[6]  Nadine Aubry,et al.  Electro-hydrodynamic micro-fluidic mixer. , 2003, Lab on a chip.

[7]  Helen Song,et al.  Millisecond kinetics on a microfluidic chip using nanoliters of reagents. , 2003, Journal of the American Chemical Society.

[8]  Norbert Schwesinger,et al.  A modular microfluid system with an integrated micromixer , 1996 .

[9]  Helen Song,et al.  Experimental test of scaling of mixing by chaotic advection in droplets moving through microfluidic channels. , 2003, Applied physics letters.

[10]  H. Goto,et al.  Active micromixer for microfluidic systems using lead‐zirconate‐titanate(PZT)‐generated ultrasonic vibration , 2000, Electrophoresis.

[11]  Eiji Shamoto,et al.  Microfluidic baker's transformation device for three-dimensional rapid mixing. , 2011, Lab on a chip.

[12]  H. Bau,et al.  A minute magneto hydro dynamic (MHD) mixer , 2001 .

[13]  A. Lee,et al.  Alternating droplet generation and controlled dynamic droplet fusion in microfluidic device for CdS nanoparticle synthesis. , 2006, Lab on a chip.

[14]  Q. Fang,et al.  Microfluidic sequential injection analysis system based on polydimethylsiloxane (PDMS) chip with integrated pneumatic-actuated valves , 2012, Science China Chemistry.

[15]  Andrew J deMello,et al.  Microfluidic routes to the controlled production of nanoparticles. , 2002, Chemical communications.

[16]  V Hessel,et al.  An optimised split-and-recombine micro-mixer with uniform chaotic mixing. , 2004, Lab on a chip.

[17]  Tobias Vossmeyer,et al.  CdS Nanoclusters: Synthesis, Characterization, Size Dependent Oscillator Strength, Temperature Shift of the Excitonic Transition Energy, and Reversible Absorbance Shift , 1994 .

[18]  Chun Yang,et al.  Mixing enhancement in microfluidic channel with a constriction under periodic electro-osmotic flow. , 2010, Biomicrofluidics.

[19]  Kee Suk Ryu,et al.  A magnetic microstirrer and array for microfluidic mixing , 2002 .

[20]  Dong-Yol Yang,et al.  Three-dimensionally crossing manifold micro-mixer for fast mixing in a short channel length. , 2011, Lab on a chip.

[21]  I. Mezić,et al.  Chaotic Mixer for Microchannels , 2002, Science.

[22]  Gwo-Bin Lee,et al.  Membrane-activated microfluidic rotary devices for pumping and mixing , 2007, Biomedical microdevices.

[23]  Jin-Woo Choi,et al.  A novel in-plane passive microfluidic mixer with modified Tesla structures. , 2004, Lab on a chip.

[24]  Helen Song,et al.  Formation of droplets and mixing in multiphase microfluidics at low values of the Reynolds and the capillary numbers , 2003 .

[25]  A. Manz,et al.  Microstructure for efficient continuous flow mixing , 1999 .

[26]  T. Park,et al.  Effective mixing in a microfluidic chip using magnetic particles. , 2009, Lab on a chip.

[27]  Che-Hsin Lin,et al.  Microfluidic T-form mixer utilizing switching electroosmotic flow. , 2004, Analytical chemistry.

[28]  Zhangrun Xu,et al.  Fast DNA hybridization on a microfluidic mixing device based on pneumatic driving. , 2011, Talanta.

[29]  Chang-Yu Chen,et al.  Micromixing via recirculatory flow generated by an oscillatory microplate , 2011 .

[30]  Ziliang Cai,et al.  Chaotic mixing in microchannels via low frequency switching transverse electroosmotic flow generated on integrated microelectrodes. , 2010, Lab on a chip.

[31]  S. Quake,et al.  Monolithic microfabricated valves and pumps by multilayer soft lithography. , 2000, Science.

[32]  Nam-Trung Nguyen,et al.  Micromixers?a review , 2005 .