Advances in SAW Gas Sensors Based on the Condensate-Adsorption Effect

A surface-acoustic-wave (SAW) gas sensor with a low detection limit and fast response for volatile organic compounds (VOCs) based on the condensate-adsorption effect detection is developed. In this sensor a gas chromatography (GC) column acts as the separator element and a dual-resonator oscillator acts as the detector element. Regarding the surface effective permittivity method, the response mechanism analysis, which relates the condensate-adsorption effect, is performed, leading to the sensor performance prediction prior to fabrication. New designs of SAW resonators, which act as feedback of the oscillator, are devised in order to decrease the insertion loss and to achieve single-mode control, resulting in superior frequency stability of the oscillator. Based on the new phase modulation approach, excellent short-term frequency stability (±3 Hz/s) is achieved with the SAW oscillator by using the 500 MHz dual-port resonator as feedback element. In a sensor experiment investigating formaldehyde detection, the implemented SAW gas sensor exhibits an excellent threshold detection limit as low as 0.38 pg.

[1]  Wen Wang,et al.  Advances in SXFA-Coated SAW Chemical Sensors for Organophosphorous Compound Detection , 2011, Sensors.

[2]  W. Wlodarski,et al.  A polyaniline/WO3 nanofiber composite-based ZnO/64° YX LiNbO3 SAW hydrogen gas sensor , 2008 .

[3]  Wojtek Wlodarski,et al.  Layered SAW gas sensor with single-walled carbon nanotube-based nanocomposite coating , 2007 .

[4]  Wojtek Wlodarski,et al.  A ZnO nanorod based layered ZnO/64° YX LiNbO3 SAW hydrogen gas sensor , 2007 .

[5]  R. Kaner,et al.  Polyaniline Nanofiber Based Surface Acoustic Wave Gas Sensors—Effect of Nanofiber Diameter on H 2 Response , 2007 .

[6]  W. Wlodarski,et al.  Polyaniline Nanofiber Based Surface Acoustic Wave Gas Sensors—Effect of Nanofiber Diameter on $\hbox{H}_{2}$ Response , 2007, IEEE Sensors Journal.

[7]  S. Viswanathan,et al.  Ultrahigh-speed chromatography and virtual chemical sensors for detecting explosives and chemical warfare agents , 2005, IEEE Sensors Journal.

[8]  Wojtek Wlodarski,et al.  Numerical calculation of SAW sensitivity: application to ZnO/LiTaO3 transducers , 2004 .

[9]  E. Staples,et al.  Performance evaluation of a surface acoustic wave analyzer to measure vocs in air and water , 2003 .

[10]  E. Staples,et al.  REAL TIME ODOR AND VOC EMISSION MEASUREMENTS ASSOCIATED WITH ENVIRONMENTAL REMEDIATION SITES USING A GC/SAW , 2003 .

[11]  Long Wu,et al.  Viscoelastic properties of polymer films on surface acoustic wave organophosphorous vapor sensors , 2002 .

[12]  R. A. McGill,et al.  The “NRL-SAWRHINO”: a nose for toxic gases , 2000 .

[13]  E. J. Staples.  Dioxin/furan detection and analysis using a SAW based electronic nose , 1998, 1998 IEEE Ultrasonics Symposium. Proceedings (Cat. No. 98CH36102).

[14]  Harald Fuchs,et al.  Improving the SAW gas sensor: device, electronics and sensor layer , 1994 .

[15]  E. Staples,et al.  SAW resonators as vapor sensors , 1990, IEEE Symposium on Ultrasonics.

[16]  H. Wohltjen,et al.  Trace Chemical Vapor Detection Using SAW Delay Line Oscillators , 1987, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[17]  J. F. Vetelino,et al.  A Surface Acoustic Wave Gas Detector , 1982 .

[18]  M. Redwood,et al.  Analysis of Generation and Detection of Surface and Bulk Acoustic Waves by Interdigital Transducers , 1977, IEEE Transactions on Sonics and Ultrasonics.

[19]  M. Lewis.  The Surface Acoustic Wave Oscillator - A Natural and Timely Development of the Quartz Crystal Oscillator , 1974 .

[20]  M. Lewis,et al.  Some Aspects of SAW Oscillators , 1973 .

[21]  G. Farnell.  Svmmetrv Considerations for Elastic Laver Modes Propagating in Anisotropic Piezoelectric Crystals , 1970, IEEE Transactions on Sonics and Ultrasonics.

[22]  B. Auld,et al.  Acoustic fields and waves in solids , 1973 .

[23]  H. F. Tiersten,et al.  Linear Piezoelectric Plate Vibrations , 1969 .

[24]  G. Batchelor,et al.  An Introduction to Fluid Dynamics , 1968 .

[25]  H. Schlichting.  Boundary Layer Theory , 1955 .