Scalant Removal at Acidic pH for Maximum Ammonium Recovery

One option for new nitrogen sources is industrial liquid side streams containing ammonium nitrogen (NH4-N). Unfortunately, NH4-N often exists in low concentrations in large water volumes. In order to achieve a highly concentrated NH4-Nsolution, scalant removal is needed. In this study, scalant removal by precipitation was investigated. At alkali pH, sodium carbonate (Na2CO3) was used as a precipitation chemical while at acidic pH, the chemical used was oxalic acid (C2H2O4). At alkali pH, high Na2CO3 dose was needed to achieve low content of calcium, which, with sulphate, formed the main scalant in the studied mine water. NH4-N at alkali pH was in the form of gaseous ammonia but it stayed well in the solution during pre-treatment for nanofiltration (NF) and reverse osmosis (RO). However, it was not rejected sufficiently, even via LG SW seawater RO membrane. At acidic pH with CaC2O4 precipitation, NF90 was able to be used for NH4-N concentration up to the volume reduction factor of 25. Then, NH4-N concentration increased from 0.17 g/L to 3 g/L. NF270 produced the best fluxes for acid pre-treated mine water, but NH4-N rejection was not adequate. NF90 membrane with mine water pre-treated using acid was successfully verified on a larger scale using the NF90-2540 spiral wound element.

[1]  J. Heikkinen,et al.  Wastewater Purification with Nutrient and Carbon Recovery in a Mobile Resource Container , 2021, Membranes.

[2]  Oluwaseun O. Ogunbiyi,et al.  Sustainable brine management from the perspectives of water, energy and mineral recovery: A comprehensive review , 2021 .

[3]  D. Kralj,et al.  Effect of pH and Type of Stirring on the Spontaneous Precipitation of CaCO3 at Identical Initial Supersaturation, Ionic Strength and a(Ca2+)/a(CO32−) Ratio , 2021, Crystals.

[4]  H. Spanjers,et al.  Recovery and applications of ammoniacal nitrogen from nitrogen-loaded residual streams: A review. , 2021, Journal of environmental management.

[5]  A. Seco,et al.  Economic analysis of the scale-up and implantation of a hollow fibre membrane contactor plant for nitrogen recovery in a full-scale wastewater treatment plant , 2021 .

[6]  J. Tester,et al.  Efficient ammonia recovery from wastewater using electrically conducting gas stripping membranes , 2020, Environmental Science: Nano.

[7]  H. Shon,et al.  Ammonia recovery from human urine as liquid fertilizers in hollow fiber membrane contactor: Effects of permeate chemistry , 2020 .

[8]  A. Verma,et al.  Metal Recovery Using Oxalate Chemistry: A Technical Review , 2019, Industrial & Engineering Chemistry Research.

[9]  C. Valderrama,et al.  Liquid fertilizer production by ammonia recovery from treated ammonia-rich regenerated streams using liquid-liquid membrane contactors , 2019, Chemical Engineering Journal.

[10]  J. P. van der Hoek,et al.  Nitrogen Recovery from Wastewater: Possibilities, Competition with Other Resources and Adaptation Pathways , 2018, Prime Archives in Sustainability.

[11]  Soheil Aghajanian,et al.  Precipitation of calcium carbonate in highly alkaline solution through carbonated water , 2019 .

[12]  J. Heikkinen,et al.  Sulphate removal from mine water with chemical, biological and membrane technologies. , 2018, Water science and technology : a journal of the International Association on Water Pollution Research.

[13]  Z. Ji,et al.  Trash to treasure: Seawater pretreatment by CO2 mineral carbonation using brine pretreatment waste of soda ash plant as alkali source , 2017 .

[14]  Chuyang Y. Tang,et al.  Experimental Aspects of Scaling Control in Membrane Filtration of Mine Water , 2017, Mine Water and the Environment.

[15]  Zhang Yan,et al.  Mechanism studies of a CO2 participant softening pretreatment process for seawater desalination , 2016 .

[16]  Ahmad Fauzi Ismail,et al.  A review on RO membrane technology: Developments and challenges , 2015 .

[17]  Jutta Laine-Ylijoki,et al.  Nitrogen compounds at mines and quarries: Sources, behaviour and removal from mine and quarry waters - Literature study , 2015 .

[18]  B. Ubbink.  Controlled Precipitation of Calcium Carbonate in Spatial Dimension with Multiple Calcium Chloride and Sodium Carbonate Pulses , 2013 .

[19]  R. Keiski,et al.  Concentration of ammonium and nitrate from mine water by reverse osmosis and nanofiltration , 2009 .

[20]  Daniel I. Massé,et al.  The use of membranes for the treatment of manure: a critical literature review , 2007 .

[21]  Ji-Whan Ahn,et al.  Effect of the pH and Basic Additives on the Precipitation of Calcium Carbonate during Carbonation Reaction , 2007 .

[22]  Albert J. Heber,et al.  AMMONIA EMISSIONS FROM ANIMAL FEEDING OPERATIONS , 2006 .

[23]  Sylvia H. Larsson,et al.  Enzymatic degradation of oxalic acid for prevention of scaling , 2002 .

[24]  V. Vančura.  Gaseous Loss of Nitrogen from Plant-Soil Systems , 1985 .

[25]  J. R. Simpson,et al.  Gaseous Loss of Nitrogen from Plant-Soil Systems , 1983, Developments in Plant and Soil Sciences.