A magnet-induced buckled-beam piezoelectric generator for wideband vibration-based energy harvesting

This article presents a magnet-induced buckled-beam piezoelectric generator developed for broadband vibration-based energy harvesting at low frequencies (<60 Hz) and small excitations (<0.5g). The harvester is made of a clamped–clamped piezoelectric beam, with one end movable and subjected to a magnet-induced compressive force. Due to the magnetic force, the beam becomes buckled and bistable. The harvester works as a double-well potential oscillator under excitations, where large-amplitude inter-well oscillation is produced to enhance the energy harvesting functionality. Numerical simulations show that the proposed harvester exhibits strong nonlinearities under harmonic excitations, including snap-through motions, large-amplitude voltage outputs, and broad frequency bandwidth. A prototype harvester is fabricated and experimentally investigated to confirm the findings from numerical simulations. It is observed that for a small base excitation of 0.35g, the harvester can produce a broad frequency bandwidth of 25.0 Hz (24.0–49.0 Hz) to constantly trigger inter-well snap-through motions and to maintain a peak-to-peak voltage of >10 V over a 1.3 MΩ load resistor. For a relatively larger base excitation of 0.5g, such a frequency bandwidth can be further widened to 29.5 Hz.

[1]  Jean W. Zu,et al.  Broadband energy harvesting through a piezoelectric beam subjected to dynamic compressive loading , 2013 .

[2]  Mohammed F. Daqaq,et al.  Relative performance of a vibratory energy harvester in mono- and bi-stable potentials , 2011 .

[3]  B. Mann,et al.  Reversible hysteresis for broadband magnetopiezoelastic energy harvesting , 2009 .

[4]  Adam J. Sneller,et al.  Experimental investigation of a post-buckled piezoelectric beam with an attached central mass used to harvest energy , 2011 .

[5]  Sang-Gook Kim,et al.  DESIGN CONSIDERATIONS FOR MEMS-SCALE PIEZOELECTRIC MECHANICAL VIBRATION ENERGY HARVESTERS , 2005 .

[6]  P. Hagedorn,et al.  A piezoelectric bistable plate for nonlinear broadband energy harvesting , 2010 .

[7]  Daniel J. Inman,et al.  Estimation of Electric Charge Output for Piezoelectric Energy Harvesting , 2004 .

[8]  L. Gammaitoni,et al.  Nonlinear energy harvesting. , 2008, Physical review letters.

[9]  Ephrahim Garcia,et al.  Broadband vibration-based energy harvesting improvement through frequency up-conversion by magnetic excitation , 2010 .

[10]  Y. Shu,et al.  Analysis of power output for piezoelectric energy harvesting systems , 2006 .

[11]  Chee Kiong Soh,et al.  Improving functionality of vibration energy harvesters using magnets , 2012 .

[12]  Bruce W. Alphenaar,et al.  Enhancement of Energy Harvested from a Random Vibration Source by Magnetic Coupling of a Piezoelectric Cantilever , 2010 .

[13]  I. Kovacic,et al.  Potential benefits of a non-linear stiffness in an energy harvesting device , 2010 .

[14]  Daniel J. Inman,et al.  A Distributed Parameter Electromechanical Model for Cantilevered Piezoelectric Energy Harvesters , 2008 .

[15]  B. Mann,et al.  Nonlinear dynamics for broadband energy harvesting: Investigation of a bistable piezoelectric inertial generator , 2010 .

[16]  Just L. Herder,et al.  Bistable vibration energy harvesters: A review , 2013 .

[17]  Nesbitt W. Hagood,et al.  Modelling of Piezoelectric Actuator Dynamics for Active Structural Control , 1990 .

[18]  Ryan L. Harne,et al.  A review of the recent research on vibration energy harvesting via bistable systems , 2013 .

[19]  D. Inman,et al.  A piezomagnetoelastic structure for broadband vibration energy harvesting , 2009 .

[20]  S. Jung,et al.  Energy-harvesting device with mechanical frequency-up conversion mechanism for increased power efficiency and wideband operation , 2010 .

[21]  A. Nayfeh,et al.  Linear and Nonlinear Structural Mechanics , 2002 .

[22]  Mohammed F. Daqaq,et al.  Electromechanical Modeling and Nonlinear Analysis of Axially Loaded Energy Harvesters , 2011 .

[23]  Yang Zhu,et al.  Enhanced buckled-beam piezoelectric energy harvesting using midpoint magnetic force , 2013 .

[24]  Neil D. Sims,et al.  Energy harvesting from the nonlinear oscillations of magnetic levitation , 2009 .

[25]  Henry A. Sodano,et al.  A review of power harvesting using piezoelectric materials (2003–2006) , 2007 .

[26]  Ehab F. El-Saadany,et al.  A wideband vibration-based energy harvester , 2008 .

[27]  S. Priya.  Advances in energy harvesting using low profile piezoelectric transducers , 2007 .

[28]  Shadrach Roundy,et al.  On the Effectiveness of Vibration-based Energy Harvesting , 2005 .