Particle launch to 19 km/s for micro-meteoroid simulation using enhanced three-stage light gas gun hypervelocity launcher techniques

Abstract Particle launch experiments were performed to study application of the enhanced hypervelocity launcher (EHVL), i.e. the third-stage addition to the two-stage gun, for launching micron to millimeter sized particulates at velocities unobtainable with a standard two-stage light gas gun launch. Three types of particles or fliers were tested along with several barrel designs. For micron scale particles fine-grain polycrystalline ceramics were impacted and fractured, launching particulate clouds at velocities of 15 km/s. Multiple titanium particles ∼400 μm diameter embedded in plastic were “shotgun” launched to velocities of 10 km/s. Flier plates of 3 mm diameter by 1 mm thick Ti6Al4V were launched to 19 km/s. All experiments used a second-stage projectile with graded density facing impacting a flier in an impact generated acceleration reservoir. This paper describes the modification and adaptation of the Sandia EHVL to provide micrometeoroid simulation capabilities.

[1]  L. Chhabildas,et al.  Seeking radio emissions from hypervelocity micrometeoroid impacts: Early experimental results from the ground , 2006 .

[2]  L. M. Barker,et al.  Launch capabilities to over 10 km/s , 1992 .

[3]  J. M. McGlaun,et al.  CTH: A three-dimensional large deformation, strong shock wave physics code , 1988 .

[4]  M. Knudson,et al.  Techniques to Launch Projectile Plates to Very High Velocities , 2005 .

[5]  L. N. Kmetyk,et al.  Enhanced hypervelocity launcher - capabilities to 16 km/s , 1995 .

[6]  Lalit C. Chhabildas,et al.  Spectral measurements of hypervelocity impact flash , 2006 .

[7]  Lalit C. Chhabildas,et al.  Shock-induced vaporization in metals , 2006 .

[8]  L. Chhabildas,et al.  Strength properties of coors AD995 alumina in the shocked state , 2003 .

[9]  F. Schäfer,et al.  Hypervelocity impact research - acceleration technology and applications - , 2001 .

[10]  D. Grady.  Dynamic properties of ceramic materials , 1995 .

[11]  D. Grady,et al.  Impact failure and fragmentation properties of metals , 1998 .

[12]  Lalit C. Chhabildas,et al.  An impact technique to accelerate flier plates to velocities over 12 km/s , 1993 .

[13]  S. Aigner,et al.  Launcher technology, in-flight velocity measurement and impact diagnostics at the TUM/LRT , 1987 .

[14]  L. M. Barker.  HIGH-PRESSURE QUASI-ISENTROPIC IMPACT EXPERIMENTS**This work performed at Sandia National Laboratories supported by the U. S. Department of Energy under contract number DE-AC04-76DP00789. , 1984 .