Ion current signal and characteristics of ethanol/gasoline dual fuel HCCI combustion

Ion current (IC) is a novel and feasible method for the diagnosis of in-cylinder combustion. The improvement of IC signal quality and reliability is always a challenge before it is applied as a sensor of engine combustion. In this paper, the characteristics of homogeneous charge compression ignition (HCCI) and IC signal with ethanol/gasoline dual fuel have been presented. The results show that increased ethanol mass fraction XEtOH retards and weakens both combustion and IC signal, with extending the phase difference (ΔθIC) between start of ion current (SOIC) and CA50 (crank angle of 50% heat release). The delayed start of gasoline injection (GSOI) enhances combustion and IC signal, but the effect is declined when XEtOH increases. This result provides a balance achieving both better quality and wider misfiring diagnosis window of IC signal. The CFD simulation results present the differences between in-cylinder local and global ion concentration with different XEtOH and GSOIs. According to the spatial distribution of electrons during the combustion, delayed GSOI causes more concentrated ionization and smaller difference between local and global start of electron appearance (SOEA).

[1]  Haiyong Peng,et al.  Study of low emission homogeneous charge compression ignition (HCCI) engine using combined internal and external exhaust gas recirculation (EGR) , 2006 .

[2]  A. Megaritis,et al.  Effect of inlet valve timing and water blending on bioethanol HCCI combustion using forced induction and residual gas trapping , 2008 .

[3]  Jun Deng,et al.  Effect of Stratification on Ion Distribution in HCCI Combustion Using 3D-CFD with Detailed Chemistry , 2013 .

[4]  Robert W. Dibble,et al.  Combustion Timing in HCCI Engines Determined by Ion-Sensor: Experimental and Kinetic Modeling , 2005 .

[5]  Gregory Thomas Roth,et al.  Ion-Sense-Based Real-Time Combustion Sensing for Closed Loop Engine Control , 2013 .

[6]  Choongsik Bae,et al.  Improvement of DME HCCI engine combustion by direct injection and EGR , 2013 .

[7]  Bertrand Lecointe,et al.  Impact of fuel characteristics on HCCI combustion: Performances and emissions , 2010 .

[8]  T. Echekki,et al.  Complex injection strategies for hydrogen-fueled HCCI engines , 2012 .

[9]  Mustafa Canakci,et al.  Influences of second injection variations on combustion and emissions of an HCCI-DI engine: Experiments and CFD modelling , 2014 .

[10]  Zhen Huang,et al.  Experimental study on the auto-ignition and combustion characteristics in the homogeneous charge compression ignition (HCCI) combustion operation with ethanol/n-heptane blend fuels by port injection , 2006 .

[11]  N. P. Komninos,et al.  An algorithm for the adaptive run-time reduction of chemical mechanisms during HCCI simulation , 2015 .

[12]  Konstantinos Boulouchos,et al.  The autoignition of practical fuels at HCCI conditions: High-pressure shock tube experiments and phenomenological modeling , 2012 .

[13]  Rakesh Kumar Maurya,et al.  Experimental investigation of the effect of the intake air temperature and mixture quality on the combustion of a methanol- and gasoline-fuelled homogeneous charge compression ignition engine , 2009 .

[14]  John E. Dec,et al.  Tailoring HCCI heat-release rates with partial fuel stratification: Comparison of two-stage and single-stage-ignition fuels , 2011 .

[15]  M. Canakci,et al.  Combustion characteristics of a DI-HCCI gasoline engine running at different boost pressures , 2012 .

[16]  Zhijun Wu,et al.  Study on the phase relation between ion current signal and combustion phase in an HCCI combustion engine , 2015 .

[17]  Jacek Hunicz,et al.  An experimental study of negative valve overlap injection effects and their impact on combustion in a gasoline HCCI engine , 2014 .

[18]  R. W. Dibble,et al.  Increasing the signal-to-noise ratio of sparkplug ion sensors through the addition of a potassium acetate fuel additive , 2011 .

[19]  Gregory E. Bogin.  Characterization of ion production using gasoline, ethanol, and N-heptane in a homogeneous charge compression ignition (HCCI) engine , 2008 .