FRICTIONAL FLOW CHARACTERISTICS OF WATER FLOWING THROUGH RECTANGULAR MICROCHANNELS

Experiments were conducted to investigate the flow characteristics of water flowing through rectangular microchannels having hydraulic diameters of 0.133-0.367 mm and H/W ratios of 0.333-1. Experimental results indicated that the laminar flow transition occurred at Reynolds numbers of 200-700. This critical Re for the laminar transition was strongly affected by the hydraulic diameter, decreasing with corresponding decreases in the microchannel. In addition, the size of the transition range was diminished and fully developed turbulent flow also occurred at much lower Re. The friction behavior of both the laminar and turbulent flow was found to depart from the classical thermqfluid correlations. lite friction factor, f, was found to be proportional to Re−1.98 rather than Re for the laminar condition, and proportional to Re−1.72i for turbulent flow. The geometric parameters, hydraulic diameter, and H/W were found to be the most important parameters and had a critical effect on the flow. Generally, increasing...

[1]  P. Debye,et al.  Flow of Liquid Hydrocarbons in Porous Vycor , 1959 .

[2]  John L. Anderson,et al.  Ionic mobility in microcapillaries. A test for anomalous water structures , 1972 .

[3]  R. Shah.  Laminar Flow Forced convection in ducts , 1978 .

[4]  R. Pease,et al.  High-performance heat sinking for VLSI , 1981, IEEE Electron Device Letters.

[5]  W. Little,et al.  Measurement of friction factors for the flow of gases in very fine channels used for microminiature Joule-Thomson refrigerators , 1983 .

[6]  D. Tuckerman.  Heat-transfer microstructures for integrated circuits , 1984 .

[7]  Derek Y. C. Chan,et al.  The drainage of thin liquid films between solid surfaces , 1985 .

[8]  Jay N. Zemel,et al.  Fluid flow in micron and submicron size channels , 1989, IEEE Micro Electro Mechanical Systems, , Proceedings, 'An Investigation of Micro Structures, Sensors, Actuators, Machines and Robots'.

[9]  Patricia McGuiggan,et al.  Liquid to solidlike transitions of molecularly thin films under shear , 1990 .

[10]  J. Zemel,et al.  Liquid transport in micron and submicron channels , 1990 .

[11]  X. Peng,et al.  Experimental investigation on liquid forced-convection heat transfer through microchannels☆ , 1994 .

[12]  G. Peterson,et al.  The effect of thermofluid and geometrical parameters on convection of liquids through rectangular microchannels , 1995 .

[13]  G. Peterson,et al.  Experimental investigation of heat transfer in flat plates with rectangular microchannels , 1995 .