Tunnel junction interconnects in GaAs-based multijunction solar cells

Monolithic multijunction solar cell performance and manufacturing can be significantly affected by the scheme used to connect the component subcells. In the authors' recent record GaInP/GaAs tandem solar cells, they developed a GaAs tunnel junction interconnect doped with carbon and selenium that had a specific resistance at zero bias of <1 m/spl Omega/-cm/sup 2/ after annealing at 700/spl deg/C for 15 minutes, the approximate conditions for growing the upper cell in the tandem structure. The specific resistance of the unannealed tunnel junction is about an order of magnitude lower than previously reported results for GaAs tunnel junctions. When incorporated into a solar cell structure, the tunnel junction displays nonideal characteristics, including the absence of a negative resistivity region and poorer conductance for large reverse bias than for similar-magnitude forward bias. These characteristics are shown to originate in a nearby heterojunction formed when the tunnel junction is incorporated in the tandem cell device structure.

[1]  Mark Hopkinson,et al.  Conduction‐band discontinuity in InGaP/GaAs measured using both current‐voltage and photoemission methods , 1992 .

[2]  Sarah R. Kurtz,et al.  29.5%‐efficient GaInP/GaAs tandem solar cells , 1994 .

[3]  Daniel J. Friedman,et al.  Accelerated publication 30.2% efficient GaInP/GaAs monolithic two‐terminal tandem concentrator cell , 1995 .

[4]  T. Makimōto,et al.  Abrupt p‐type doping profile of carbon atomic layer doped GaAs grown by flow‐rate modulation epitaxy , 1987 .

[5]  S. I. Long,et al.  Determination of valence and conduction‐band discontinuities at the (Ga,In) P/GaAs heterojunction by C‐V profiling , 1987 .

[6]  K. Bertness,et al.  In situ observation of surface morphology of InP grown on singular and vicinal (001) substrates , 1994 .

[7]  Alexandre Freundlich,et al.  Very high peak current CBE grown InGaAs tunnel junction for InP/InGaAs tandem cells fabricated on InP, GaAs, and Si substrates , 1993, Conference Record of the Twenty Third IEEE Photovoltaic Specialists Conference - 1993 (Cat. No.93CH3283-9).

[8]  S. M. Sze.  Physics of semiconductor devices /2nd edition/ , 1981 .

[9]  G. Y. Robinson,et al.  Band offset of GaAs/In0.48Ga0.52P measured under hydrostatic pressure , 1991 .

[10]  S. Asher,et al.  Properties and use of cycled grown OMVPE GaAs:Zn, GaAs:Se, and GaAs:Si layers for high-conductance GaAs tunnel junctions , 1992 .

[11]  M. Yamaguchi,et al.  Double Heterostructure GaAs Tunnel Junction for a AlGaAs/GaAs Tandem Solar Cell , 1988 .