Design and Demonstration of Ultra Wide Bandgap AlGaN Tunnel Junctions

Ultra violet light emitting diodes (UV LEDs) face critical limitations in both the injection efficiency and light extraction efficiency due to the resistive and absorbing p-type contact layers. In this work, we investigate the design and application of polarization engineered tunnel junctions for ultra-wide bandgap AlGaN (Al mole fraction higher than 50%) materials towards highly efficient UV LEDs. We demonstrate that polarization-induced 3D charge is beneficial in reducing tunneling barriers especially for high composition AlGaN tunnel junctions. The design of graded tunnel junction structures could lead to low tunneling resistance below 10-3 Ohm cm2 and low voltage consumption below 1 V (at 1 kA/cm2) for high composition AlGaN tunnel junctions. Experimental demonstration of 292 nm emission was achieved through non-equilibrium hole injection into wide bandgap materials with bandgap energy larger than 4.7 eV, and detailed modeling of tunnel junctions shows that they can be engineered to have low resistance, and can enable efficient emitters in the UV-C wavelength range.

[1]  S. Denbaars,et al.  Hybrid tunnel junction contacts to III–nitride light-emitting diodes , 2016 .

[2]  Jared M. Johnson,et al.  Low-resistance GaN tunnel homojunctions with 150 kA/cm2 current and repeatable negative differential resistance , 2016, 1601.04353.

[3]  Michael W. Moseley,et al.  Enhanced light extraction in tunnel junction-enabled top emitting UV LEDs , 2015, 1512.02260.

[4]  Z. Mi,et al.  Alternating-Current InGaN/GaN Tunnel Junction Nanowire White-Light Emitting Diodes. , 2015, Nano letters.

[5]  N. Grandjean,et al.  InGaN based micro light emitting diodes featuring a buried GaN tunnel junction , 2015 .

[6]  S. Rajan,et al.  GaN-based three-junction cascaded light-emitting diode with low-resistance InGaN tunnel junctions , 2015 .

[7]  Christoph Reich,et al.  Effect of heterostructure design on carrier injection and emission characteristics of 295 nm light emitting diodes , 2015 .

[8]  Michael W. Moseley,et al.  Interband tunneling for hole injection in III-nitride ultraviolet emitters , 2015, 1502.02080.

[9]  Norihiko Kamata,et al.  Recent progress and future prospects of AlGaN-based high-efficiency deep-ultraviolet light-emitting diodes , 2014 .

[10]  Michael Wraback,et al.  High power AlGaN ultraviolet light emitters , 2014 .

[11]  S. Kamiyama,et al.  Multijunction GaInN-based solar cells using a tunnel junction , 2014 .

[12]  S. Rajan,et al.  Tunneling-based carrier regeneration in cascaded GaN light emitting diodes to overcome efficiency droop , 2013 .

[13]  G. Verzellesi,et al.  Efficiency droop in InGaN/GaN blue light-emitting diodes: Physical mechanisms and remedies , 2013 .

[14]  Michael Kneissl,et al.  Improved injection efficiency in 290 nm light emitting diodes with Al(Ga)N electron blocking heterostructure , 2013 .

[15]  Han-Youl Ryu,et al.  Investigation of Light Extraction Efficiency in AlGaN Deep-Ultraviolet Light-Emitting Diodes , 2013 .

[16]  Michael Wraback,et al.  270 nm Pseudomorphic Ultraviolet Light-Emitting Diodes with Over 60 mW Continuous Wave Output Power , 2013 .

[17]  Siddharth Rajan,et al.  Low resistance GaN/InGaN/GaN tunnel junctions , 2012, 1211.4905.

[18]  Michael S. Shur,et al.  AlGaN Deep-Ultraviolet Light-Emitting Diodes with External Quantum Efficiency above 10% , 2012 .

[19]  S. Rajan,et al.  Electron gas dimensionality engineering in AlGaN/GaN high electron mobility transistors using polarization , 2012 .

[20]  Debdeep Jena,et al.  Polarization-Induced Hole Doping in Wide–Band-Gap Uniaxial Semiconductor Heterostructures , 2010, Science.

[21]  Monirul Islam,et al.  Robust 290 nm Emission Light Emitting Diodes over Pulsed Laterally Overgrown AlN , 2007 .

[22]  Umesh K. Mishra,et al.  Multi‐color light emitting diode using polarization‐induced tunnel junctions , 2007 .

[23]  H. Temkin,et al.  Si-doped AlxGa1−xN(0.56⩽×⩽1) layers grown by molecular beam epitaxy with ammonia , 2005 .

[24]  Robert Kaplar,et al.  Room-temperature direct current operation of 290 nm light-emitting diodes with milliwatt power levels , 2004 .

[25]  S. Denbaars,et al.  AlGaN/GaN polarization-doped field-effect transistor for microwave power applications - eScholarship , 2004 .

[26]  Jing Li,et al.  Mg acceptor level in AlN probed by deep ultraviolet photoluminescence , 2003 .

[27]  Yoshiki Saito,et al.  RF-Molecular Beam Epitaxy Growth and Properties of InN and Related Alloys , 2003 .

[28]  S. Jeon,et al.  Lateral current spreading in GaN-based light-emitting diodes utilizing tunnel contact junctions , 2001 .

[29]  A. Jauho,et al.  Physica status solidi , 1967, May 16.

[30]  E. Kane,et al.  Thomas-Fermi Approach to Impure Semiconductor Band Structure , 1963 .

[31]  Hideki Hirayama,et al.  Enhanced light extraction in 260 nm light-emitting diode with a highly transparent p-AlGaN layer , 2015 .