Flow and pressure drop fluctuations in a vertical tube subject to low frequency oscillations

Abstract Heat transfer and other equipment mounted on off-shore platforms may be subjected to low frequency oscillations. The effect of these oscillations, typically in the frequency range of 0.1–1 Hz, on the flow rate and pressure drop in a vertical tube has been studied experimentally in the present work. A 1.75 m-long vertical tube of inner diameter 0.016 m was mounted on a plate and the whole plate was subjected to oscillations in the vertical plane using a mechanical simulator capable of providing low frequency oscillations in the range of 8–30 cycles/min at an amplitude of 0.125 m. The effect of the oscillations on the flow rate and the pressure drop has been measured systematically in the Reynolds number range 500–6500. The induced flow rate fluctuations were found to be dependent on the Reynolds number with stronger fluctuations at lower Reynolds numbers. The effective friction factor, based on the mean pressure drop and the mean flow rate, was also found to be higher than expected. Correlations have been developed to quantify this Reynolds number dependence.

[1]  A. Kurosawa,et al.  Critical heat flux of forced convection boiling in an oscillating acceleration field — III. Reduction mechanism of CHF in subcooled flow boiling , 1984 .

[2]  M. O. Carpinlioglu,et al.  A critical review on pulsatile pipe flow studies directing towards future research topics , 2001 .

[3]  P. Hebrard,et al.  The influence of pulsating flows on orifice plate flowmeters , 1992 .

[4]  M. Gundogdu,et al.  Present State of Art on Pulsatile Flow Theory : Part 1:Laminar and Transitional Flow Regimes , 1999 .

[5]  Daniel Hershey,et al.  Friction factors and pressure drop for sinusoidal laminar flow of water and blood in rigid tubes , 1967 .

[6]  Theodor Sexl,et al.  Über den von E. G. Richardson entdeckten „Annulareffekt“ , 1930 .

[7]  J. Womersley.  Method for the calculation of velocity, rate of flow and viscous drag in arteries when the pressure gradient is known , 1955, The Journal of physiology.

[8]  J. P. Hartnett,et al.  Advances in Heat Transfer , 2003 .

[9]  Naotsugu Isshiki,et al.  Effects of heaving and listing upon thermo-hydraulic performance and critical heat flux of water-cooled marine reactors , 1966 .

[10]  R. Shah.  Laminar Flow Forced convection in ducts , 1978 .

[11]  Hideki Nariai,et al.  Thermal-hydraulic behavior of a marine reactor during oscillations , 1990 .

[12]  Robert J. Moffat,et al.  Describing the Uncertainties in Experimental Results , 1988 .

[13]  E. G. Richardson,et al.  The transverse velocity gradient near the mouths of pipes in which an alternating or continuous flow of air is established , 1929 .

[14]  M. Clamen,et al.  An experimental investigation of flow in an oscillating pipe , 1977, Journal of Fluid Mechanics.

[15]  T. Papanastasiou,et al.  Viscous Fluid Flow , 1999 .

[16]  Toshihisa Ishida,et al.  Effects of ship motions on natural circulation of deep sea research reactor DRX , 2002 .

[17]  A. Kurosawa,et al.  Critical heat flux of forced convection boiling in an oscillating acceleration field. II: Contribution of flow oscillation , 1983 .

[18]  Akira Kurosawa,et al.  Critical heat flux of forced convection boiling in an oscillating acceleration field — I. General trends , 1982 .

[19]  Shigeo Uchida,et al.  The pulsating viscous flow superposed on the steady laminar motion of incompressible fluid in a circular pipe , 1956 .