A Single-Stage LED Driver Based on Flyback and Modified Class-E Resonant Converters With Low-Voltage Stress

This paper presents a novel integrated-stage light-emitting diode (LED) driver based on Flyback and resonant converters. The Flyback converter realizes power factor correction in the discontinuous conduction mode. The resonant converter is operated as a dc–dc converter to support the LED loads. Moreover, the resonant converter can clearly decrease the drain–source voltage of the active switch and exhibits zero-voltage-switch characteristics. Therefore, a cost-effective MOSFET can be chosen as the main control component that can decrease the cost of the whole system. Compared to a single-active-switch converter (such as Class-E converter), the number of passive components in the resonant converter can be limited to four. Therefore, the power density of the system can be improved drastically. In this paper, a 100-W prototype is presented under the experimental condition to validate the proposed integrated-stage LED driver.

[1]  Xu Ying-chun,et al.  Inductor optimize design for BCM BUCK-PFC in LED driver , 2011, 2011 International Conference on Electric Information and Control Engineering.

[2]  J. M. Alonso,et al.  Analysis, Design, and Experimentation of a Closed-Loop Metal Halide Lamp Electronic Ballast , 2012, IEEE Transactions on Industry Applications.

[3]  Marco A. Dalla Costa,et al.  Microcontroller-Based High-Power-Factor Electronic Ballast to Supply Metal Halide Lamps , 2012, IEEE Transactions on Industrial Electronics.

[4]  Junming Zhang,et al.  Analysis and design considerations of two-stage AC-DC LED driver without electrolytic capacitor , 2014, 2014 IEEE Energy Conversion Congress and Exposition (ECCE).

[5]  K. Yao,et al.  DCM Flyback PFC converter with optimum utilization control of switching cycles , 2015, 2015 IEEE Energy Conversion Congress and Exposition (ECCE).

[6]  Enrico Santi,et al.  Class E resonant inverter optimized design for high frequency (MHz) operation using eGaN HEMTs , 2015, 2015 IEEE Applied Power Electronics Conference and Exposition (APEC).

[7]  Jung-Ik Ha,et al.  Design of GaN transistor-based class E DC-DC converter with resonant rectifier circuit , 2015, 2015 IEEE 3rd Workshop on Wide Bandgap Power Devices and Applications (WiPDA).

[8]  Hoi Lee,et al.  A Wide-Input-Range Efficiency-Enhanced Synchronous Integrated LED Driver With Adaptive Resonant Timing Control , 2016, IEEE Journal of Solid-State Circuits.

[9]  Hiroo Sekiya,et al.  A Class-E Power Amplifier Design Considering MOSFET Nonlinear Drain-to-Source and Nonlinear Gate-to-Drain Capacitances at Any Grading Coefficient , 2016, IEEE Transactions on Power Electronics.

[10]  V. G. Krizhanovski,et al.  High-frequency Class-E power amplifier with shunt filter , 2016, 2016 International Conference Radio Electronics & Info Communications (UkrMiCo).

[11]  Ehsan Adib,et al.  Analysis of the Integrated SEPIC-Flyback Converter as a Single-Stage Single-Switch Power-Factor-Correction LED Driver , 2016, IEEE Transactions on Industrial Electronics.

[12]  Hiroo Sekiya,et al.  Analysis and design of class E power amplifier considering MOSFET parasitic input and output capacitances , 2016, IET Circuits Devices Syst..

[13]  Gun-Woo Moon,et al.  Duty-Ratio-Control-Aided LLC Converter for Current Balancing of Two-Channel LED Driver , 2017, IEEE Transactions on Industrial Electronics.

[14]  Junming Zhang,et al.  A High-Efficiency Quasi-Two-Stage LED Driver With Multichannel Outputs , 2017, IEEE Transactions on Industrial Electronics.

[15]  B. L. Narasimharaju,et al.  Single-stage electrolytic capacitor less non-inverting buck-boost PFC based AC–DC ripple free LED driver , 2017 .

[16]  Suyong Chae,et al.  Single-Stage Buck-Derived LED Driver With Improved Efficiency and Power Factor Using Current Path Control Switches , 2017, IEEE Transactions on Industrial Electronics.

[17]  Hyun-Lark Do,et al.  A Single-Switch AC–DC LED Driver Based on a Boost-Flyback PFC Converter With Lossless Snubber , 2017, IEEE Transactions on Power Electronics.

[18]  Ehsan Adib,et al.  A Single-Stage Single-Switch Soft-Switching Power-Factor-Correction LED Driver , 2017, IEEE Transactions on Power Electronics.

[19]  Jee-Hoon Jung,et al.  PWM and PFM Hybrid Control Method for LLC Resonant Converters in High Switching Frequency Operation , 2017, IEEE Transactions on Industrial Electronics.

[20]  K. I. Hwu,et al.  Nonisolated Two-Phase Interleaved LED Driver With Capacitive Current Sharing , 2018, IEEE Transactions on Power Electronics.

[21]  Lanhua Zhang,et al.  A Single-Stage Integrated Boost-LLC AC–DC Converter With Quasi-Constant Bus Voltage for Multichannel LED Street-Lighting Applications , 2018, IEEE Journal of Emerging and Selected Topics in Power Electronics.