The effect of electrolyte composition on the electroreduction of CO2 to CO on Ag based gas diffusion electrodes.

The electroreduction of CO2 to C1-C2 chemicals can be a potential strategy for utilizing CO2 as a carbon feedstock. In this work, we investigate the effect of electrolytes on the electroreduction of CO2 to CO on Ag based gas diffusion electrodes. Electrolyte concentration was found to play a major role in the process for the electrolytes (KOH, KCl, and KHCO3) studied here. Several fold improvements in partial current densities of CO (jCO) were observed on moving from 0.5 M to 3.0 M electrolyte solution independent of the nature of the anion. jCO values as high as 440 mA cm(-2) with an energy efficiency (EE) of ≈ 42% and 230 mA cm(-2) with EE ≈ 54% were observed when using 3.0 M KOH. Electrochemical impedance spectroscopy showed that both the charge transfer resistance (Rct) and the cell resistance (Rcell) decreased on moving from a 0.5 M to a 3.0 M KOH electrolyte. Anions were found to play an important role with respect to reducing the onset potential of CO in the order OH(-) (-0.13 V vs. RHE) < HCO3(-) (-0.46 V vs. RHE) < Cl(-) (-0.60 V vs. RHE). A decrease in Rct upon increasing electrolyte concentration and the effect of anions on the cathode can be explained by an interplay of different interactions in the electrical double layer that can either stabilize or destabilize the rate limiting CO2˙(-) radical. EMIM based ionic liquids and 1 : 2 choline Cl urea based deep eutectic solvents (DESs) have been used for CO2 capture but exhibit low conductivity. Here, we investigate if the addition of KCl to such solutions can improve conductivity and hence jCO. Electrolytes containing KCl in combination with EMIM Cl, choline Cl, or DESs showed a two to three fold improvement in jCO in comparison to those without KCl. Using such mixtures can be a strategy for integrating the process of CO2 capture with CO2 conversion.

[1]  Wolfgang Ziegler,et al.  Modern Aspects Of Electrochemistry , 2016 .

[2]  Yu Zhang,et al.  Effect of Chloride Anions on the Synthesis and Enhanced Catalytic Activity of Silver Nanocoral Electrodes for CO2 Electroreduction , 2015 .

[3]  Paul J. A. Kenis,et al.  Influence of dilute feed and pH on electrochemical reduction of CO2 to CO on Ag in a continuous flow electrolyzer , 2015 .

[4]  M. Kanan,et al.  Pd-catalyzed electrohydrogenation of carbon dioxide to formate: high mass activity at low overpotential and identification of the deactivation pathway. , 2015, Journal of the American Chemical Society.

[5]  Mert Atilhan,et al.  Deep Eutectic Solvents: Physicochemical Properties and Gas Separation Applications , 2015 .

[6]  T. R. Shippert,et al.  Observational determination of surface radiative forcing by CO2 from 2000 to 2010 , 2015, Nature.

[7]  Christos T. Maravelias,et al.  A general framework for the assessment of solar fuel technologies , 2015 .

[8]  P. Král,et al.  Robust carbon dioxide reduction on molybdenum disulphide edges , 2014, Nature Communications.

[9]  Etosha R. Cave,et al.  Insights into the electrocatalytic reduction of CO₂ on metallic silver surfaces. , 2014, Physical chemistry chemical physics : PCCP.

[10]  J. Brennecke,et al.  Switching the reaction course of electrochemical CO₂ reduction with ionic liquids. , 2014, Langmuir : the ACS journal of surfaces and colloids.

[11]  J. Glass,et al.  Polyethylenimine-enhanced electrocatalytic reduction of CO₂ to formate at nitrogen-doped carbon nanomaterials. , 2014, Journal of the American Chemical Society.

[12]  Sichao Ma,et al.  Silver supported on titania as an active catalyst for electrochemical carbon dioxide reduction. , 2014, ChemSusChem.

[13]  T. Meyer,et al.  Nanostructured tin catalysts for selective electrochemical reduction of carbon dioxide to formate. , 2014, Journal of the American Chemical Society.

[14]  Jiujun Zhang,et al.  A review of catalysts for the electroreduction of carbon dioxide to produce low-carbon fuels. , 2014, Chemical Society reviews.

[15]  Paul J. A. Kenis,et al.  Efficient Electrochemical Flow System with Improved Anode for the Conversion of CO2 to CO , 2014 .

[16]  J. Hansen,et al.  Assessing “Dangerous Climate Change”: Required Reduction of Carbon Emissions to Protect Young People, Future Generations and Nature , 2013, PloS one.

[17]  B. A. Rosen,et al.  Renewable and metal-free carbon nanofibre catalysts for carbon dioxide reduction , 2013, Nature Communications.

[18]  Michel Dupuis,et al.  Frontiers, opportunities, and challenges in biochemical and chemical catalysis of CO2 fixation. , 2013, Chemical reviews.

[19]  John L DiMeglio,et al.  Selective conversion of CO2 to CO with high efficiency using an inexpensive bismuth-based electrocatalyst. , 2013, Journal of the American Chemical Society.

[20]  Paul J. A. Kenis,et al.  Electrochemical conversion of CO2 to useful chemicals: current status, remaining challenges, and future opportunities , 2013 .

[21]  Fikile R. Brushett,et al.  The Effects of Catalyst Layer Deposition Methodology on Electrode Performance , 2013 .

[22]  R. Masel,et al.  Monolayers of choline chloride can enhance desired electrochemical reactions and inhibit undesirable ones , 2013 .

[23]  P. Kenis,et al.  Nanoparticle Silver Catalysts That Show Enhanced Activity for Carbon Dioxide Electrolysis , 2013 .

[24]  Paul J. A. Kenis,et al.  Effect of Cations on the Electrochemical Conversion of CO2 to CO , 2013 .

[25]  Matthew W. Kanan,et al.  Aqueous CO2 reduction at very low overpotential on oxide-derived Au nanoparticles. , 2012, Journal of the American Chemical Society.

[26]  Sichao Ma,et al.  Nitrogen-based catalysts for the electrochemical reduction of CO2 to CO. , 2012, Journal of the American Chemical Society.

[27]  Haifeng Dong,et al.  Carbon capture with ionic liquids: overview and progress , 2012 .

[28]  Matthew W. Kanan,et al.  Tin oxide dependence of the CO2 reduction efficiency on tin electrodes and enhanced activity for tin/tin oxide thin-film catalysts. , 2012, Journal of the American Chemical Society.

[29]  W. Marsden.  I and J , 2012 .

[30]  F. Ke,et al.  Electrochemical Reduction of Carbon Dioxide I. Effects of the Electrolyte on the Selectivity and Activity with Sn Electrode , 2012 .

[31]  P. Kenis,et al.  Quantitative Analysis of Single-Electrode Plots to Understand In-Situ Behavior of Individual Electrodes , 2012 .

[32]  Eric J. Dufek,et al.  Influence of Electrolytes and Membranes on Cell Operation for Syn-Gas Production , 2012 .

[33]  Eric J. Dufek,et al.  Operation of a Pressurized System for Continuous Reduction of CO2 , 2012 .

[34]  P. Kenis,et al.  Ionic Liquid–Mediated Selective Conversion of CO2 to CO at Low Overpotentials , 2011, Science.

[35]  Eric J. Dufek,et al.  Bench-scale electrochemical system for generation of CO and syn-gas , 2011 .

[36]  P. Kenis,et al.  Prospects of CO2 Utilization via Direct Heterogeneous Electrochemical Reduction , 2010 .

[37]  Emily Barton Cole,et al.  Using a one-electron shuttle for the multielectron reduction of CO2 to methanol: kinetic, mechanistic, and structural insights. , 2010, Journal of the American Chemical Society.

[38]  Siglinda Perathoner,et al.  Towards solar fuels from water and CO2. , 2010, ChemSusChem.

[39]  Devin T. Whipple.  Microfluidic reactor for the electrochemical reduction of carbon dioxide , 2010 .

[40]  V. Srinivasadesikan,et al.  On the Chemical Stabilities of Ionic Liquids , 2009, Molecules.

[41]  I. Katsounaros,et al.  Influence of the concentration and the nature of the supporting electrolyte on the electrochemical reduction of nitrate on tin cathode , 2007 .

[42]  Andrzej Wieckowski,et al.  Electrocatalysis of oxygen reduction and small alcohol oxidation in alkaline media. , 2007, Physical chemistry chemical physics : PCCP.

[43]  O. Petrii,et al.  Exploring the molecular features of cationic catalysis phenomenon: Peroxodisulfate reduction at a mercury electrode , 2005 .

[44]  Xiaogang Zhang,et al.  Electrochemical reduction of CO2 on RuO2/TiO2 nanotubes composite modified Pt electrode , 2005 .

[45]  S Pacala,et al.  Stabilization Wedges: Solving the Climate Problem for the Next 50 Years with Current Technologies , 2004, Science.

[46]  M. Dry,et al.  The Fischer–Tropsch process: 1950–2000 , 2002 .

[47]  O. Magnussen.  Ordered anion adlayers on metal electrode surfaces. , 2002, Chemical reviews.

[48]  Glenn J. Sunley,et al.  High productivity methanol carbonylation catalysis using iridium , 2000 .

[49]  Hans Schulz,et al.  Short history and present trends of Fischer–Tropsch synthesis , 1999 .

[50]  Dan Hancu,et al.  Green processing using ionic liquids and CO2 , 1999, Nature.

[51]  Makiko Kato,et al.  Electrochemical reduction of CO2 on single crystal electrodes of silver Ag(111), Ag(100) and Ag(110) , 1997 .

[52]  Toshio Tsukamoto,et al.  Electrocatalytic process of CO selectivity in electrochemical reduction of CO2 at metal electrodes in aqueous media , 1994 .

[53]  Andrew B. Bocarsly,et al.  A new homogeneous electrocatalyst for the reduction of carbon dioxide to methanol at low overpotential , 1994 .

[54]  Y. Hori,et al.  Product Selectivity Affected by Cationic Species in Electrochemical Reduction of CO2 and CO at a Cu Electrode , 1991 .

[55]  I. S. Kolomnikov,et al.  Carbon dioxide in coordination chemistry and catalysis , 1990 .

[56]  Y. Hori,et al.  Formation of hydrocarbons in the electrochemical reduction of carbon dioxide at a copper electrode in aqueous solution , 1990 .

[57]  H. Schwarz,et al.  Reduction potentials of CO2- and the alcohol radicals , 1989 .

[58]  J. Paul,et al.  Co2 conversion and oxalate stability on alkali promoted metal surfaces: Sodium modified Al(100) , 1988 .

[59]  K. Chandrasekaran,et al.  In-situ spectroscopic investigation of adsorbed intermediate radicals in electrochemical reactions: CO2− on platinum , 1987 .

[60]  Y. Hori,et al.  Electrolytic Reduction of Bicarbonate Ion at a Mercury Electrode , 1983 .

[61]  E. Gonzalez,et al.  Electrolyte effects on oxygen reduction kinetics at platinum: A rotating ring-disc electrode analysis , 1983 .

[62]  Allen J. Bard,et al.  Electrochemical Methods: Fundamentals and Applications , 1980 .

[63]  J. Ulstrup,et al.  A theory of electrode reactions through bridge transition states; bridges with a discrete electronic spectrum , 1972 .

[64]  D. Bodé.  Calculated free energies of absorption of halide and hydroxide ions by mercury, silver, and gold electrodes , 1972 .

[65]  Brian E. Conway,et al.  Modern Aspects of Electrochemistry , 1974 .