Feasibility of Detecting Natural Frequencies of Hydraulic Turbines While in Operation, Using Strain Gauges

Nowadays, hydropower plays an essential role in the energy market. Due to their fast response and regulation capacity, hydraulic turbines operate at off-design conditions with a high number of starts and stops. In this situation, dynamic loads and stresses over the structure are high, registering some failures over time, especially in the runner. Therefore, it is important to know the dynamic response of the runner while in operation, i.e., the natural frequencies, damping and mode shapes, in order to avoid resonance and fatigue problems. Detecting the natural frequencies of hydraulic turbine runners while in operation is challenging, because they are inaccessible structures strongly affected by their confinement in water. Strain gauges are used to measure the stresses of hydraulic turbine runners in operation during commissioning. However, in this paper, the feasibility of using them to detect the natural frequencies of hydraulic turbines runners while in operation is studied. For this purpose, a large Francis turbine runner (444 MW) was instrumented with several strain gauges at different positions. First, a complete experimental strain modal testing (SMT) of the runner in air was performed using the strain gauges and accelerometers. Then, the natural frequencies of the runner were estimated during operation by means of analyzing accurately transient events or rough operating conditions.

[1]  MAO Zhongyu,et al.  Structural Characteristic in Prototype Runner of Francis Turbine Analysis , 2016 .

[2]  Eduard Egusquiza Estévez,et al.  Condition monitoring of pump-turbines , 2014 .

[3]  Eduard Egusquiza,et al.  Detection of cavitation in hydraulic turbines , 2006 .

[4]  Alexandre Presas,et al.  Influence of the rotation on the natural frequencies of a submerged-confined disk in water , 2015 .

[5]  Eduard Egusquiza,et al.  Fluid Added Mass Effect in the Modal Response of a Pump-Turbine Impeller , 2009 .

[6]  Eduard Egusquiza,et al.  Dynamic Analysis of Francis Runners - Experiment and Numerical Simulation , 2009 .

[7]  Alexandre Presas,et al.  Detection and analysis of part load and full load instabilities in a real Francis turbine prototype , 2017 .

[8]  J. Slavič,et al.  The mass normalization of the displacement and strain mode shapes in a strain experimental modal analysis using the mass-change strategy , 2013 .

[9]  Alexandre Presas,et al.  Dynamic response of the MICA runner. Experiment and simulation , 2017 .

[10]  X. Escalera,et al.  Experimental investigation of added mass effects on a Francis turbine runner in still water , 2006 .

[11]  Chirag Trivedi,et al.  Fluid-structure interactions in Francis turbines : A perspective review , 2017 .

[12]  Hiroshi Tanaka,et al.  Vibration Behavior and Dynamic Stress of Runners of Very High Head Reversible Pump-turbines , 2011 .

[13]  R. P. Saini,et al.  Study of cavitation in hydro turbines—A review , 2010 .

[14]  Tetsuya Morisaki,et al.  Influence of the boundary conditions on the natural frequencies of a Francis turbine , 2016 .

[15]  D. Newland.  Wavelet Analysis of Vibration: Part 1—Theory , 1994 .

[16]  N Ruchonnet,et al.  Fatigue analyses of the prototype Francis runners based on site measurements and simulations , 2014 .

[17]  Eduard Egusquiza,et al.  Failure investigation of a large pump-turbine runner , 2012 .

[18]  Xin Liu,et al.  A review on fatigue damage mechanism in hydro turbines , 2016 .

[19]  Bernd Nennemann,et al.  Challenges in Dynamic Pressure and Stress Predictions at No-Load Operation in Hydraulic Turbines , 2014 .

[20]  M. Dubas.  Über die Erregung infolge der Periodizität von Turbomaschinen , 1984 .

[21]  Emiliano Mucchi,et al.  On the comparison between displacement modal testing and strain modal testing , 2015 .

[22]  Eduard Egusquiza,et al.  Monitoring of Rotor-Stator Interaction in Pump-Turbine Using Vibrations Measured with On-Board Sensors Rotating with Shaft , 2014 .

[23]  D. J. Ewins,et al.  Modal Testing: Theory and Practice , 1984 .

[24]  Philippe Bocher,et al.  Impact of startup scheme on Francis runner life expectancy , 2010 .

[25]  Jiri Koutnik,et al.  Dynamic stresses in a Francis model turbine at deep part load , 2017 .

[26]  Eduard Egusquiza,et al.  Experimental investigation of added mass effects on a hydrofoil under cavitation conditions , 2013 .

[27]  Chirag Trivedi,et al.  A review on fluid structure interaction in hydraulic turbines: A focus on hydrodynamic damping , 2017 .

[28]  Ilmar F. Santos,et al.  Frequencies in the Vibration Induced by the Rotor Stator Interaction in a Centrifugal Pump Turbine , 2007 .

[29]  Alexandre Presas,et al.  Experimental study on the added mass and damping of a disk submerged in a partially fluid-filled tank with small radial confinement , 2014 .

[30]  F. Avellan,et al.  Numerical simulation of fluid added mass effect on a francis turbine runner , 2007 .

[31]  Reza N. Jazar.  Advanced Vibrations: A Modern Approach , 2012 .

[32]  Alexandre Presas,et al.  Condition monitoring of pump-turbines. New challenges , 2015 .

[33]  Eduard Egusquiza,et al.  Analysis of the dynamic response of pump-turbine impellers. Influence of the rotor , 2016 .

[34]  Gustavo Urquiza,et al.  A Fatigue Analysis of a Hydraulic Francis Turbine Runner , 2012 .

[35]  Hideo Ohashi,et al.  Case Study of Pump Failure Due to Rotor-Stator Interaction , 1994 .

[36]  Alexandre Presas,et al.  Power swing generated in Francis turbines by part load and overload instabilities , 2017 .

[37]  Bernd Nennemann,et al.  Stress predictions in a Francis turbine at no-load operating regime , 2016 .

[38]  Alexandre Presas,et al.  On the detection of natural frequencies and mode shapes of submerged rotating disk-like structures from the casing , 2015 .

[39]  Grant,et al.  HYdropower plants PERformance and flexiBle Operation towards Lean integration of new renewable Energies , 2020 .

[40]  Alexandre Presas,et al.  Feasibility of Using PZT Actuators to Study the Dynamic Behavior of a Rotating Disk due to Rotor-Stator Interaction , 2014, Sensors.

[41]  Alexandre Presas,et al.  Numerical study on the influence of acoustic natural frequencies on the dynamic behaviour of submerged and confined disk-like structures , 2017 .