Influence of halon replacements on laminar flame speeds and extinction limits of hydrocarbon flames

Abstract The influence of some halon replacements as the fire suppressants on premixed and non-premixed hydrocarbon flames was experimentally and numerically investigated. Unstretched flame speeds and extinction stretch rates of methane/air and propane/air flames with the addition of different loadings of C 2 HF 5 (HFC-125), C 2 HF 3 Cl 2 (HCFC-123), and C 3 H 2 F 3 Br (2-BTP) were measured for a range of fuel/air equivalence ratios. Experiments were conducted using the counterflow technique at ambient temperature and pressure. A newly-developed kinetic model, which was based on a C 1 ‒C 4 hydrocarbon model and agent-inhibition sub-models, was used to compare with the measured flame speeds and extinction stretch rates. Good agreement was obtained regarding the laminar flame speeds. For the extinction rate of the non-premixed flames, the absolute experimental data were over-predicted uniformly for the entire range of conditions examined, although the model correctly predicted the trends of increasing extinction stretch rates with the increasing fuel/(N 2 +agent) molar ratio. Since this new kinetic model was tested against the extinction limits for the first time, the optimization of the rate constants of the reaction(s) regarding the flame extinction is expected. Significant thermal expansion was detected in larger and brighter flames when the different agents were added to the neat mixture. This observation provided new experimental evidence of the fuel-like properties of the inhibitor. Despite the difference in the fuel type, C 2 HF 5 and C 3 H 2 F 3 Br were found to be less effective at reducing the flame speeds of the lean flames as compared to that of the rich flames. However, C 2 HF 3 Cl 2 reduced the flame speeds for all of the investigated mixture conditions. Thermodynamic equilibrium calculations were performed to interpret the behavior of these fire suppressants in hydrocarbon flames. The extinction data for non-premixed flames revealed that the resistance of the agents to extinction decreases in the order of C 2 HF 5 , C 2 HF 3 Cl 2 , and C 3 H 2 F 3 Br, which is consistent with the suppression effect on flame speed.

[1]  M. Z. Haq,et al.  Laminar burning velocity and Markstein lengths of methane–air mixtures , 2000 .

[2]  Xishi Wang,et al.  A New Type of BTP/Zeolites Nanocomposites as Mixed-phase Fire Suppressant: Preparation, Characterization, and Extinguishing Mechanism Discussion , 2010 .

[3]  J. C. Leylegian,et al.  Laminar flame speeds and oxidation kinetics of tetrachloromethane , 1998 .

[4]  Junfu Lu,et al.  Effects of inert dilution on the propagation and extinction of lean premixed syngas/air flames , 2015 .

[5]  V. Babushok,et al.  Influence of water vapor on hydrocarbon combustion in the presence of hydrofluorocarbon agents , 2015 .

[6]  Bradley A. Williams,et al.  Intermediate species profiles in low pressure premixed flames inhibited by fluoromethanes , 1999 .

[7]  M. Metghalchi,et al.  Laminar burning velocity of propane-air mixtures at high temperature and pressure , 1980 .

[8]  H. Phylaktou,et al.  Fluorinated halon replacement agents in explosion inerting , 2015 .

[9]  J. C. Leylegian,et al.  Experiments and Numerical Simulation on the Laminar Flame Speeds of Dichloromethane and Trichloromethane , 1998 .

[10]  Valeri I. Babushok,et al.  Inhibition of Premixed Methane–Air Flames by Fluoroethanes and Fluoropropanes , 1998 .

[11]  Tim Edwards,et al.  Ignition and extinction of non-premixed flames of single-component liquid hydrocarbons, jet fuels, and their surrogates , 2007 .

[12]  Yang Zhang,et al.  Laminar flame speed studies of lean premixed H2/CO/air flames , 2014 .

[13]  Gregory T. Linteris,et al.  Premixed flame inhibition by CF3Br and C3H2F3Br (2-BTP) , 2016 .

[14]  C. Law,et al.  Laminar burning velocities of trifluoromethane-methane mixtures : Experiment and numerical simulation , 1998 .

[15]  Gregory T. Linteris,et al.  Inhibition of premixed methane-air flames by fluoromethanes , 1996 .

[16]  James A. Miller,et al.  A Computational Model of the Structure and Extinction of Strained, Opposed Flow, Premixed Methane- , 1988 .

[17]  Yong Jiang,et al.  Combustion promotion and extinction of premixed counterflow methane/air flames by C6F12O fire suppressant , 2016 .

[18]  C. Westbrook.  Inhibition of hydrocarbon oxidation in laminar flames and detonations by halogenated compounds , 1982 .

[19]  Chunsheng Ji,et al.  Propagation and extinction of premixed dimethyl-ether/air flames , 2009 .

[20]  Chung King Law,et al.  Outward propagation, burning velocities, and chemical effects of methane flames up to 60 ATM , 2002 .

[21]  F. Egolfopoulos.  Geometric and radiation effects on steady and unsteady strained laminar flames , 1994 .

[22]  V. Babushok,et al.  Premixed flame inhibition by C2HF3Cl2 and C2HF5 , 2016 .

[23]  De Goey,et al.  The laminar burning velocity of flames propagating in mixtures of hydrocarbons and air measured with the heat flux method , 2004 .

[24]  Wan Ki Chow,et al.  Performance evaluation of water mist with bromofluoropropene in suppressing gasoline pool fires , 2011 .

[25]  Chunsheng Ji,et al.  Propagation and extinction of premixed C5–C12 n-alkane flames , 2010 .

[26]  Gregory T. Linteris,et al.  Stirred reactor calculations to understand unwanted combustion enhancement by potential halon replacements , 2012 .

[27]  P. Sunderland,et al.  Combustion inhibition and enhancement of premixed methane–air flames by halon replacements , 2015 .

[28]  Valeri I. Babushok,et al.  Unwanted combustion enhancement by C6F12O fire suppressant , 2013 .

[29]  T. Tsotsis,et al.  A comparative study on the extinction characteristics of non-premixed dimethyl ether and ethanol flames☆ , 2011 .

[30]  Ning Liu,et al.  Combustion characteristics of alternative gaseous fuels , 2011 .

[31]  Fokion N. Egolfopoulos,et al.  Extinction of premixed flames of practical liquid fuels: Experiments and simulations , 2006 .

[33]  Prankul Middha,et al.  Extinction of premixed H2/air flames: Chemical kinetics and molecular diffusion effects , 2005 .

[34]  Andrew E. Lutz,et al.  OPPDIF: A Fortran program for computing opposed-flow diffusion flames , 1997 .

[35]  Robert J. Moffat,et al.  Describing the Uncertainties in Experimental Results , 1988 .

[36]  Valeri I. Babushok,et al.  Combustion properties of halogenated fire suppressants , 2012 .

[37]  R. J. Kee,et al.  Chemkin-II : A Fortran Chemical Kinetics Package for the Analysis of Gas Phase Chemical Kinetics , 1991 .

[38]  Eric L. Petersen,et al.  Effect of CF3Br on C1–C3 ignition and laminar flame speed: Numerical and experimental evaluation , 2013 .

[39]  Chung King Law,et al.  Further considerations on the determination of laminar flame speeds with the counterflow twin-flame technique , 1994 .

[40]  Valeri I. Babushok,et al.  Hydrocarbon flame inhibition by C3H2F3Br (2-BTP) , 2015 .

[41]  Phillip R. Westmoreland,et al.  Thermochemical and chemical kinetic data for fluorinated hydrocarbons , 1995 .

[42]  Valeri I. Babushok,et al.  A Chemical Kinetic Mechanism for 2-Bromo-3,3,3-trifluoropropene (2-BTP) Flame Inhibition , 2015 .

[43]  G. Faeth,et al.  Effects of Halons and Halon Replacements on Hydrogen-Fueled Laminar Premixed Flames , 2002 .

[44]  Fokion N. Egolfopoulos,et al.  Direct experimental determination of laminar flame speeds , 1998 .

[45]  Chung King Law,et al.  Experimental and numerical determination of laminar flame speeds: Mixtures of C2-hydrocarbons with oxygen and nitrogen. (Reannouncement with new availability information) , 1990 .

[46]  Valeri I. Babushok,et al.  Flame Inhibition by CF3CHCl2 (HCFC-123) , 2014 .