Microalgae-based biodiesel: economic analysis of downstream process realistic scenarios.

Microalgae oil has been identified as a reliable resource for biodiesel production due to its high lipid productivity and potential cultivation in non-fertile locations. However, high scale production of microalgae based biodiesel depends on the optimization of the entire process to be economically feasible. The selected strain, medium, harvesting methods, etc., sorely affects the ash content in the dry biomass which have a direct effect in the lipid content. Moreover, the suitable lipids for biodiesel production, some of the neutral/saponifiable, are only a fraction of the total ones (around 30% dry base biomass in the best case). The present work uses computational tools for the modeling of different scenarios of the harvesting, oil extraction and transesterification. This rigorous modeling approach detects process bottlenecks that could have led to an overestimation of the potentiality of the microalgae lipids as a resource for the biodiesel production.

[1]  Stefan Tangermann,et al.  The Common Agricultural Policy after 2013 , 2012 .

[2]  Gerhard Knothe,et al.  “Designer” Biodiesel: Optimizing Fatty Ester Composition to Improve Fuel Properties† , 2008 .

[3]  Y. Chisti.  Biodiesel from microalgae. , 2007, Biotechnology advances.

[4]  Y. Chisti,et al.  Recovery of microalgal biomass and metabolites: process options and economics. , 2003, Biotechnology advances.

[5]  Richard Turton,et al.  Analysis, Synthesis and Design of Chemical Processes , 2002 .

[6]  Joan Salvadó,et al.  Antifouling microfiltration strategies to harvest microalgae for biofuel. , 2012, Bioresource technology.

[7]  L. Laurens,et al.  Microalgae as biodiesel & biomass feedstocks: Review & analysis of the biochemistry, energetics & economics , 2010 .

[8]  M. Dubé,et al.  Biodiesel production from waste cooking oil: 2. Economic assessment and sensitivity analysis. , 2003, Bioresource technology.

[9]  D. Vandamme,et al.  Flocculation of Chlorella vulgaris induced by high pH: role of magnesium and calcium and practical implications. , 2012, Bioresource technology.

[10]  Mark A. White,et al.  Environmental life cycle comparison of algae to other bioenergy feedstocks. , 2010, Environmental science & technology.

[11]  Joan Salvadó,et al.  Dynamic Microfiltration in Microalgae Harvesting for Biodiesel Production , 2011 .

[12]  R. M. Willis,et al.  Biodiesel production by simultaneous extraction and conversion of total lipids from microalgae, cyanobacteria, and wild mixed-cultures. , 2011, Bioresource technology.

[13]  Joan Salvadó,et al.  Harvesting the microalgae Phaeodactylum tricornutum with polyaluminum chloride, aluminium sulphate, chitosan and alkalinity-induced flocculation , 2011, Journal of Applied Phycology.

[14]  W. J. Dyer,et al.  A rapid method of total lipid extraction and purification. , 1959, Canadian journal of biochemistry and physiology.

[15]  C. Carrington,et al.  Variables affecting the in situ transesterification of microalgae lipids , 2010 .

[16]  Laureano Jiménez,et al.  An automated environmental and economic evaluation methodology for the optimization of a sour water stripping plant , 2013 .

[17]  S. Amin.  Review on biofuel oil and gas production processes from microalgae , 2009 .

[18]  M. Dubé,et al.  Biodiesel production from waste cooking oil: 1. Process design and technological assessment. , 2003, Bioresource technology.

[19]  Ryan Davis,et al.  Techno-economic analysis of autotrophic microalgae for fuel production , 2011 .

[20]  Adam Harvey,et al.  Alkaline in situ transesterification of Chlorella vulgaris , 2012 .

[21]  Mamdouh A. Gadalla,et al.  Evaluation Tool for the Environmental Design of Chemical Processes , 2011 .

[22]  Joan Salvadó,et al.  Lipid extraction methods from microalgal biomass harvested by two different paths: screening studies toward biodiesel production. , 2013, Bioresource technology.

[23]  Gonzalo Guillén-Gosálbez,et al.  Hybrid simulation-optimization based approach for the optimal design of single-product biotechnological processes , 2012, Comput. Chem. Eng..

[24]  Gemma Vicente,et al.  Biodiesel production from biomass of an oleaginous fungus , 2009 .

[25]  P. Nichols,et al.  Fatty acid and lipid composition of 10 species of microalgae used in mariculture , 1989 .

[26]  C. Posten,et al.  Second Generation Biofuels: High-Efficiency Microalgae for Biodiesel Production , 2008, BioEnergy Research.

[27]  Gerrit Brem,et al.  Assessment of a dry and a wet route for the production of biofuels from microalgae: energy balance analysis. , 2011, Bioresource technology.

[28]  Lucas Reijnders,et al.  Do biofuels from microalgae beat biofuels from terrestrial plants? , 2008, Trends in biotechnology.