Effect of a Trace Element Addition Strategy on Volatile Fatty Acid Accumulation in Thermophilic Anaerobic Digestion of Food Waste

AbstractPurpose A trace element (TE) supplementation strategy previously shown to be effective in mesophilic conditions was tested for thermophilic digestion of source segregated domestic food waste.MethodsInoculum from a mesophilic anaerobic digester treating municipal wastewater biosolids was successfully acclimated to thermophilic temperature (55 °C) with food waste as a substrate. Four laboratory-scale digesters were maintained at a loading of 2 g VS l−1 day−1 with one pair receiving TE supplementation. Two more pairs of digesters were incrementally loaded to 3 and 4 g VS l−1 day−1, respectively, and also received TE.ResultsAll digesters performed well for the first 3–4 months of operation, but volatile fatty acid (VFA) concentrations in those without TE showed no recovery from an initial small accumulation. On continued operation, VFA concentrations increased in all digesters, especially those at higher loading rates or without TE supplementation, reaching >30 g l−1. Under these meta-stable conditions, a deliberate disturbance to daily feeding (cessation then resumption) led to acetic acid accumulation, a fall in pH and a sharp increase in the ratio of partial to intermediate alkalinity. Increases in VFA corresponded to an increasing total ammonia nitrogen concentration which appeared to become inhibitory at ~2,500 mg N l−1.ConclusionsWhile TE supplementation delayed the onset and reduced the rate of VFA accumulation, it was unable to sustain stable digestion of this substrate in thermophilic conditions.

[1]  H. Tsuno,et al.  Comparison of thermophilic anaerobic digestion characteristics between single-phase and two-phase systems for kitchen garbage treatment. , 2008, Journal of bioscience and bioengineering.

[2]  Charles J Banks,et al.  A pilot-scale comparison of mesophilic and thermophilic digestion of source segregated domestic food waste. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[3]  Samir Kumar Khanal,et al.  Anaerobic Biotechnology for Bioenergy Production , 2008 .

[4]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[5]  S. Heaven,et al.  Anaerobic digestion of source-segregated domestic food waste: performance assessment by mass and energy balance. , 2011, Bioresource technology.

[6]  Richard E Speece,et al.  Anaerobic biotechnology and odor/corrosion control for municipalities and industries , 2007 .

[7]  Andrew G. Hashimoto,et al.  Ammonia inhibition of methanogenesis from cattle wastes , 1986 .

[8]  J. Rintala,et al.  Semi-continuous anaerobic digestion of solid poultry slaughterhouse waste: effect of hydraulic retention time and loading. , 2002, Water research.

[9]  Lei Zhang,et al.  Long-term anaerobic digestion of food waste stabilized by trace elements. , 2012, Waste management.

[10]  Irini Angelidaki,et al.  Anaerobic thermophilic digestion of manure at different ammonia loads: Effect of temperature , 1994 .

[11]  Yu-You Li,et al.  Trace metals requirements for continuous thermophilic methane fermentation of high-solid food waste , 2013 .

[12]  R. Speece,et al.  Comparative process stability and efficiency of anaerobic digestion; mesophilic vs. thermophilic. , 2002, Water research.

[13]  Rafael Borja,et al.  Influence of ammonia concentration on thermophilic anaerobic digestion of cattle manure in upflow anaerobic sludge blanket (UASB) reactors , 1996 .

[14]  D. L. Hawkes,et al.  The mesophilic and thermophilic anaerobic digestion of coffee waste containing coffee grounds , 1996 .

[15]  Sonia Heaven,et al.  Potential errors in the quantitative evaluation of biogas production in anaerobic digestion processes. , 2009, Bioresource technology.

[16]  B. Ahring,et al.  Thermophilic anaerobic digestion of livestock waste: the effect of ammonia , 2004, Applied Microbiology and Biotechnology.

[17]  Samir Kumar Khanal,et al.  Anaerobic Biotechnology for Bioenergy Production: Principles and Applications , 2008 .

[18]  Charles J. Banks.  Anaerobic digestion of solid and high nitrogen content fractions of slaughterhouse wastes , 1994 .

[19]  Xavier Font,et al.  Long term operation of a thermophilic anaerobic reactor: process stability and efficiency at decreasing sludge retention time. , 2010, Bioresource technology.

[20]  Sonia Heaven,et al.  Trace element requirements for stable food waste digestion at elevated ammonia concentrations. , 2012, Bioresource technology.

[21]  S. Sung,et al.  Ammonia inhibition on thermophilic anaerobic digestion. , 2003, Chemosphere.

[22]  [Advances in Biochemical Engineering/Biotechnology] Biomethanation II Volume 82 || Applications of the Anaerobic Digestion Process , 2003 .

[23]  J. C. Converse,et al.  Improved alkalimetric monitoring for anaerobic digestion of high-strength wastes , 1986 .

[24]  S. Uemura,et al.  MINERAL REQUIREMENTS FOR MESOPHILIC AND THERMOPHILIC ANAEROBIC DIGESTION OF ORGANIC SOLID WASTE , 2010 .

[25]  B. Ahring,et al.  Anaerobic digestion of swine manure: Inhibition by ammonia , 1998 .

[26]  Yu-You Li,et al.  High-solid mesophilic methane fermentation of food waste with an emphasis on Iron, Cobalt, and Nickel requirements. , 2012, Bioresource technology.

[27]  Irini Angelidaki,et al.  Anaerobic digestion of slaughterhouse by-products , 2009 .

[28]  Stefan Bertilsson,et al.  Impact of trace element addition on biogas production from food industrial waste--linking process to microbial communities. , 2010, FEMS microbiology ecology.

[29]  S. Heaven,et al.  Anaerobic digestion of two biodegradable municipal waste streams. , 2012, Journal of environmental management.

[30]  Dwayne R.J. Moore.  The Anna Karenina Principle Applied to Ecological Risk Assessments of Multiple Stressors , 2001 .