CFD and experimental studies of solids hold-up distribution and circulation patterns in gas–solid fluidized beds

Abstract The hydrodynamics of a gas–solid fluidized bed was studied using a combination of experiments and CFD simulations. Experiments were conducted with polypropylene particles (710–1000 μm in diameter) as solid phase and air as gas phase. A multifluid Eulerian model incorporating the kinetic theory for solid particles is used to simulate the gas–solid flow. Momentum exchange coefficient was calculated using the Gidaspow drag model. Effects of gas velocity, type of sparger, presence of draft tube on solid hold-up distribution and solid circulation pattern have been investigated. The presented experimental data and comparison with CFD predictions provide useful basis for further work on understanding bubbling fluidized beds.

[1]  van den Cm Bleek,et al.  Eulerian simulations of bubbling behaviour in gas-solid fluidised beds , 1998 .

[2]  W. C. Mih.  An empirical shear stress equation for general solid-fluid mixture flows , 1993 .

[3]  David G. Schaeffer,et al.  Instability in the evolution equations describing incompressible granular flow , 1987 .

[4]  A. P. Baskakov,et al.  A study of pressure fluctuations in a bubbling fluidized bed , 1986 .

[5]  S. Savage,et al.  The effects of an impact velocity dependent coefficient of restitution on stresses developed by sheared granular materials , 1986 .

[6]  D. Geldart,et al.  Gas fluidization technology , 1986 .

[7]  Dimitri Gidaspow,et al.  Hydrodynamics of Fiuidizatlon and Heat Transfer: Supercomputer Modeling , 1986 .

[8]  Gerhart Eigenberger,et al.  Applicability of the standard k–ε turbulence model to the dynamic simulation of bubble columns. Part II:: Comparison of detailed experiments and flow simulations , 1999 .

[9]  Christine M. Hrenya,et al.  Effects of particle‐phase turbulence in gas‐solid flows , 1997 .

[10]  Dimitri Gidaspow,et al.  Computation of flow patterns in circulating fluidized beds , 1990 .

[11]  P. Foscolo,et al.  Generalized friction factor and drag coefficient correlations for fluid-particle interactions , 1985 .

[12]  M. Syamlal,et al.  Simulation of granular layer inversion in liquid fluidized beds , 1988 .

[13]  Bjørn H. Hjertager,et al.  An experimental and numerical study of flow patterns in a circulating fluidized bed reactor , 1996 .

[14]  Vivek V. Ranade,et al.  Single jet fluidized beds: Experiments and CFD simulations with glass and polypropylene particles , 2007 .

[15]  Jc Jaap Schouten,et al.  Scale-up of chaotic fluidized bed hydrodynamics , 1996 .

[16]  J. X. Bouillard,et al.  Hydrodynamics of erosion of heat exchanger tubes in fluidized bed combustors , 1989 .

[17]  Rajamani Krishna,et al.  Comparative analysis of CFD models of dense gas–solid systems , 2001 .

[18]  A. Almstedt,et al.  Experimental validation of CFD models for fluidized beds: Influence of particle stress models, gas phase compressibility and air inflow models , 2006 .

[19]  T. G. Cowling,et al.  The mathematical theory of non-uniform gases , 1939 .

[20]  Rajamani Krishna,et al.  Validation of the Eulerian simulated dynamic behaviour of gas-solid fluidised beds , 1999 .

[21]  Timothy J. O'Hern,et al.  Gamma-densitometry tomography of gas holdup spatial distribution in industrial-scale bubble columns , 1995 .

[22]  Xiaojun Bao,et al.  Computational fluid dynamics (CFD) modeling of spouted bed: Assessment of drag coefficient correlations , 2006 .

[23]  A. Kantzas,et al.  Validation of Bubble Properties of a Bubbling Fluidized Bed Reactor Using CFD with Imaging Experiments , 2005 .

[24]  Robert W. Lyczkowski,et al.  Numerical simulation and experimental validation of solids flows in a bubbling fluidized bed , 1999 .

[25]  Wei Ge,et al.  CFD simulation of concurrent-up gas-solid flow in circulating fluidized beds with structure-dependent drag coefficient , 2003 .

[26]  Jianmin Ding,et al.  Three-dimensional kinetic theory modeling of hydrodynamics and erosion in fluidized beds , 1992 .

[27]  Yong Jin,et al.  Modeling the hydrodynamics of downer reactors based on kinetic theory , 1999 .

[28]  J. Werther,et al.  Local bubble gas hold-up and expansion of gas/solid fluidized beds , 1986 .

[29]  S. Ergun.  Fluid flow through packed columns , 1952 .

[30]  Jam Hans Kuipers,et al.  Critical comparison of hydrodynamic models for gas-solid fluidized beds - Part I: bubbling gas-solid fludized beds operated with a jet , 2005 .

[31]  D. Jeffrey,et al.  Kinetic theories for granular flow: inelastic particles in Couette flow and slightly inelastic particles in a general flowfield , 1984, Journal of Fluid Mechanics.

[32]  Todd Pugsley,et al.  Simulation and experimental validation of a freely bubbling bed of FCC catalyst , 2003 .

[33]  Nobusuke Kobayashi,et al.  A study on the behavior of bubbles and solids in bubbling fluidized beds , 2000 .

[34]  K. E. Starling,et al.  Equation of State for Nonattracting Rigid Spheres , 1969 .

[35]  A. Kantzas,et al.  CFD Modeling and Validation of Bubble Properties for a Bubbling Fluidized Bed , 2005 .

[36]  Jam Hans Kuipers,et al.  Measurements of solids concentration and axial solids velocity in gas-solid two-phase flows. , 1996 .

[37]  R. W. Lyczkowski,et al.  Hydrodynamics of fluidization in a semicircular bed with a jet , 1984 .

[38]  R. D. Lanauze,et al.  A circulating fluidised bed , 1976 .

[39]  Hans Enwald,et al.  Fluid dynamics of a pressurized fluidized bed: comparison between numerical solutions from two-fluid models and experimental results , 1999 .

[40]  Jinghai Li,et al.  Discrete simulations of heterogeneous structure and dynamic behavior in gas-solid fluidization , 1999 .

[41]  B. T. Chao,et al.  A novel radioactive particle tracking facility for measurement of solids motion in gas fluidized beds , 1985 .

[42]  J. Kuipers,et al.  A numerical model of gas-fluidized beds , 1992 .

[43]  Paola Lettieri,et al.  CFD Simulations of Gas Fluidized Beds Using Alternative Eulerian-Eulerian Modelling Approaches , 2002 .

[44]  D. Zhang,et al.  High-resolution three-dimensional numerical simulation of a circulating fluidized bed , 2001 .

[45]  P. Agarwal,et al.  Mixing of homogeneous solids in bubbling fluidized beds: Theoretical modelling and experimental investigation using digital image analysis , 1993 .

[46]  Martin J Rhodes,et al.  Pressure Effects on Gas-Solid Fluidized Bed Behavior , 2003 .

[47]  Dimitri Gidaspow,et al.  Fluidization in Two-Dimensional Beds with a Jet. 2. Hydrodynamic Modeling , 1983 .

[48]  Ulrich Renz,et al.  Eulerian simulation of bubble formation at a jet in a two-dimensional fluidized bed , 1997 .

[49]  Rajamani Krishna,et al.  Using CFD for scaling up gas–solid bubbling fluidised bed reactors with Geldart A powders , 2001 .

[50]  R. Jackson,et al.  Gas‐particle flow in a vertical pipe with particle‐particle interactions , 1989 .

[51]  J. Grace.  Contacting modes and behaviour classification of gas—solid and other two-phase suspensions , 1986 .

[52]  Dimitri Gidaspow,et al.  Collisional viscosity of FCC particles in a CFB , 1996 .

[53]  Mridul Gautam,et al.  Computer simulation of bubbles in large-particle fluidized beds , 1998 .

[54]  John R. Grace,et al.  Verification and validation of CFD models and dynamic similarity for fluidized beds , 2004 .

[55]  Paola Lettieri,et al.  2D and 3D CFD Simulations of Bubbling Fluidized Beds Using Eulerian-Eulerian Models , 2003 .

[56]  D. Gidaspow,et al.  A bubbling fluidization model using kinetic theory of granular flow , 1990 .

[57]  C.R.E. de Oliveira,et al.  A study of bubbling and slugging fluidised beds using the two-fluid granular temperature model , 2001 .

[58]  Tron Solberg,et al.  A three-dimensional simulation of gas/particle flow and ozone decomposition in the riser of a circulating fluidized bed , 2004 .

[59]  Gerhart Eigenberger,et al.  Applicability of the standard k–ε turbulence model to the dynamic simulation of bubble columns: Part I. Detailed numerical simulations , 1999 .

[60]  F. Taghipour,et al.  Experimental and computational study of gas¿solid fluidized bed hydrodynamics , 2005 .

[61]  Jam Hans Kuipers,et al.  Critical comparison of hydrodynamic models for gas-solid fluidized beds - Part II: freely bubbling gas-solid fluidized beds , 2005 .

[62]  Yonghao Zhang,et al.  Continuum modelling of granular particle flow with inelastic inter-particle collisions , 2003 .

[63]  Jam Hans Kuipers,et al.  Hydrodynamic Modeling of Gas/Particle Flows in Riser Reactors , 1996 .