Reverse Electrodialysis with saline waters and concentrated brines: a laboratory investigation towards technology scale-up

Abstract The use of concentrated brines and brackish water as feed solutions in reverse electrodialysis represents a valuable alternative to the use of river/sea water, allowing the enhancement of power output through the increase of driving force and reduction of internal stack resistance. Apart from a number of theoretical works, very few experimental investigations have been performed so far to explore this possibility. In the present work, two RED units of different size were tested using artificial saline solutions. The effects of feed concentration, temperature and flowrate on process performance parameters were analysed, adopting two different sets of membranes. These experiments allowed to identify the most favourable conditions for maximising the power output within the presently investigated range, i.e. 0.1 M NaCl as diluate and 5 M NaCl as concentrate at 40 °C. Under these conditions a power density equal to 12 W/m2cell_pair was reached, among the highest so far reported in the literature. Increasing the unit size a slight reduction in power density was observed. These results indicate new directions for a successful scale-up and development of the Reverse Electrodialysis technology.

[1]  G. J. Harmsen,et al.  Reverse electrodialysis : Performance of a stack with 50 cells on the mixing of sea and river water , 2009 .

[2]  Kitty Nijmeijer,et al.  Micro-structured membranes for electricity generation by reverse electrodialysis , 2014 .

[3]  Michael Papapetrou,et al.  REAPOWER – USE OF DESALINATION BRINE FOR POWER PRODUCTION THROUGH REVERSE ELECTRODIALYSIS , 2015 .

[4]  Dc Kitty Nijmeijer,et al.  Power generation using profiled membranes in reverse electrodialysis , 2011 .

[5]  M. Elimelech,et al.  Membrane-based processes for sustainable power generation using water , 2012, Nature.

[6]  Joseph Jagur-Grodzinski,et al.  Novel process for direct conversion of free energy of mixing into electric power , 1986 .

[7]  Marian Turek,et al.  Power production from coal-mine brine utilizing reversed electrodialysis , 2008 .

[8]  A. Albanese,et al.  Investigation of electrode material – redox couple systems for reverse electrodialysis processes. Part II: Experiments in a stack with 10–50 cell pairs , 2013 .

[9]  Alessandro Galia,et al.  Investigation of electrode material – Redox couple systems for reverse electrodialysis processes. Part I: Iron redox couples , 2012 .

[10]  Andrea Cipollina,et al.  Integrated production of fresh water, sea salt and magnesium from sea water , 2012 .

[11]  P. M. Biesheuvel,et al.  Direct power production from a water salinity difference in a membrane-modified supercapacitor flow cell. , 2010, Environmental science & technology.

[12]  D. Brogioli.  Extracting renewable energy from a salinity difference using a capacitor. , 2009, Physical review letters.

[13]  Rien Herber,et al.  Upscale potential and financial feasibility of a reverse electrodialysis power plant , 2014 .

[14]  J. Post,et al.  Salinity-gradient power : Evaluation of pressure-retarded osmosis and reverse electrodialysis , 2007 .

[15]  R. Audinos,et al.  Electrodialyse inverse. Etude de l'energie electrique obtenue a partir de deux solutions de salinites differentes , 1983 .

[16]  Enrico Drioli,et al.  Probing membrane and interface properties in concentrated electrolyte solutions , 2014 .

[17]  E. Brauns.  Towards a worldwide sustainable and simultaneous large-scale production of renewable energy and potable water through salinity gradient power by combining reversed electrodialysis and solar power? , 2008 .

[18]  Andrea Cipollina,et al.  Modelling the Reverse ElectroDialysis process with seawater and concentrated brines , 2012 .

[19]  F. Helfferich,et al.  Ion-exchange membrane separation processes (Membrane science and technology series, vol. 9), H. Strathmann. Elsevier, Amsterdam (2004), ISBN: 044450236-X , 2005 .

[20]  Kitty Nijmeijer,et al.  Influence of multivalent ions on renewable energy generation in reverse electrodialysis , 2014 .

[21]  R. E. Pattle.  Production of Electric Power by mixing Fresh and Salt Water in the Hydroelectric Pile , 1954, Nature.

[22]  Lasse Murtomäki,et al.  Ionic transport processes , 2008 .

[23]  J. Weinstein,et al.  Electric Power from Differences in Salinity: The Dialytic Battery , 1976, Science.

[24]  Michele Ciofalo,et al.  CFD prediction of concentration polarization phenomena in spacer-filled channels for reverse electrodialysis , 2014 .

[25]  Kitty Nijmeijer,et al.  Doubled power density from salinity gradients at reduced intermembrane distance. , 2011, Environmental science & technology.

[26]  J. Veerman,et al.  Reducing power losses caused by ionic shortcut currents in reverse electrodialysis stacks by a validated model , 2008 .

[27]  Dc Kitty Nijmeijer,et al.  Experimentally obtainable energy from mixing river water, seawater or brines with reverse electrodialysis , 2014 .

[28]  Ramato Ashu Tufa,et al.  Potential of brackish water and brine for energy generation by salinity gradient power-reverse electrodialysis (SGP-RE) , 2014 .

[29]  Marian Turek,et al.  Renewable energy by reverse electrodialysis , 2007 .

[30]  Giorgio Micale,et al.  A simulation tool for analysis and design of reverse electrodialysis using concentrated brines , 2015 .

[31]  Michael Papapetrou,et al.  Analysis and simulation of scale-up potentials in reverse electrodialysis , 2015 .

[32]  Jon G. Pharoah,et al.  Improved electrode systems for reverse electro-dialysis and electro-dialysis , 2012 .

[33]  Matthias Wessling,et al.  Ion conductive spacers for increased power generation in reverse electrodialysis , 2010 .

[34]  B. R. Staples.  Activity and osmotic coefficients of aqueous alkali metal nitrites , 1981 .

[35]  N Lakshminarayanaiah,et al.  Transport phenomena in artificial membranes. , 1965, Chemical reviews.