Acoustic measurement of bubble size in an inkjet printhead.

The volume of a bubble in a piezoinkjet printhead is measured acoustically. The method is based on a numerical model of the investigated system. The piezo not only drives the system but it is also used as a sensor by measuring the current it generates. The numerical model is used to predict this current for a given bubble volume. The inverse problem is to infer the bubble volume from an experimentally obtained piezocurrent. By solving this inverse problem, the size and position of the bubble can thus be measured acoustically. The method is experimentally validated with an inkjet printhead that is augmented with a glass connection channel, through which the bubble was observed optically, while at the same time the piezocurrent was measured. The results from the acoustical measurement method correspond closely to the results from the optical measurement.

[1]  Evert Klaseboer,et al.  A collapsing bubble-induced micropump: An experimental study , 2007 .

[2]  Kye-Si Kwon,et al.  A waveform design method for high-speed inkjet printing based on self-sensing measurement , 2007 .

[3]  Katherine W Ferrara,et al.  Acoustic response of compliable microvessels containing ultrasound contrast agents , 2006, Physics in medicine and biology.

[4]  Jianying Cui,et al.  Bubble pulsations between parallel plates. , 2006, The Journal of the Acoustical Society of America.

[5]  Frank E. Talke,et al.  Experimental and theoretical study of wave propagation phenomena in drop-on-demand ink jet devices , 1984 .

[6]  Andrea Prosperetti,et al.  The natural frequency of oscillation of gas bubbles in tubes , 1998 .

[7]  K. Ferrara,et al.  The natural frequency of nonlinear oscillation of ultrasound contrast agents in microvessels. , 2007, Ultrasound in medicine & biology.

[8]  J. F. Dijksman,et al.  Hydrodynamics of small tubular pumps , 1984, Journal of Fluid Mechanics.

[9]  Detlef Lohse,et al.  Air entrapment in piezo-driven inkjet printheads , 2006 .

[10]  K. Hynynen,et al.  Forced linear oscillations of microbubbles in blood capillaries. , 2004, The Journal of the Acoustical Society of America.

[11]  Katherine W. Ferrara,et al.  The natural frequency of nonlinear oscillation of ultrasound contrast agents in microvessels. , 2007, Ultrasound in medicine & biology.

[12]  H. Callen.  Thermodynamics and an Introduction to Thermostatistics , 1988 .

[13]  George M. Homsy,et al.  MODELING SHAPES AND DYNAMICS OF CONFINED BUBBLES , 2006 .

[14]  T. Leighton.  1 – The Sound Field , 1994 .

[15]  L. Shampine,et al.  Solving DDEs in MATLAB , 2001 .

[16]  Detlef Lohse,et al.  Single bubble sonoluminescence , 2002 .

[17]  Detlef Lohse,et al.  Effect of an entrained air bubble on the acoustics of an ink channel. , 2008, The Journal of the Acoustical Society of America.

[18]  A. Prosperetti,et al.  Bubble Dynamics and Cavitation , 1977 .

[19]  P. Zhong,et al.  Dynamics of bubble oscillation in constrained media and mechanisms of vessel rupture in SWL. , 2001, Ultrasound in medicine & biology.

[20]  Andrea Prosperetti,et al.  The ‘acoustic scallop’: a bubble-powered actuator , 2006 .

[21]  Thomas Young,et al.  XIII. Hydraulic investigations, subservient to an intended Croonian Lecture on the motion of the blood , 1808, Philosophical Transactions of the Royal Society of London.

[22]  Andrea Prosperetti,et al.  Entrapped air bubbles in piezo-driven inkjet printing: Their effect on the droplet velocity , 2006 .

[23]  J. Womersley.  Method for the calculation of velocity, rate of flow and viscous drag in arteries when the pressure gradient is known , 1955, The Journal of physiology.

[24]  Andrea Prosperetti,et al.  Growth and collapse of a vapor bubble in a narrow tube , 2000 .

[25]  E. Kimmel,et al.  Gas bubble pulsation in a semiconfined space subjected to ultrasound. , 2001, The Journal of the Acoustical Society of America.

[26]  Paul A Dayton,et al.  Direct observations of ultrasound microbubble contrast agent interaction with the microvessel wall. , 2007, The Journal of the Acoustical Society of America.

[27]  Alexander L. Klibanov,et al.  Ultrasound Contrast Agents: Development of the Field and Current Status , 2002 .