The bridge between the materials and devices of thermoelectric power generators

While considerable efforts have been made to develop and improve thermoelectric materials, research on thermoelectric modules is at a relatively early stage because of the gap between material and device technologies. In this review, we discuss the cumulative temperature dependence model to reliably predict the thermoelectric performance of module devices and individual materials for an accurate evaluation of the p–n configuration compared to the conventional model used since the 1950s. In this model, the engineering figure of merit and engineering power factor are direct indicators, and they exhibit linear correlations to efficiency and output power density, respectively. To reconcile the strategy for high material performance and the thermomechanical reliability issue in devices, a new methodology is introduced by defining the engineering thermal conductivity. Beyond thermoelectric materials, the device point of view needs to be actively addressed before thermoelectric generators can be envisioned as power sources.

[1]  Z. Ren,et al.  Engineering Thermal Conductivity for Balancing Between Reliability and Performance of Bulk Thermoelectric Generators , 2016 .

[2]  H. Middleton,et al.  Design, assembly and characterization of silicide-based thermoelectric modules , 2016 .

[3]  A. Shakouri,et al.  Thermoelectric topping cycles with scalable design and temperature dependent material properties , 2016 .

[4]  Weishu Liu,et al.  Efficiency and output power of thermoelectric module by taking into account corrected Joule and Thomson heat , 2015 .

[5]  Xinbing Zhao,et al.  Realizing high figure of merit in heavy-band p-type half-Heusler thermoelectric materials , 2015, Nature Communications.

[6]  J. Goodenough,et al.  Effects of ball milling on microstructures and thermoelectric properties of higher manganese silicides , 2015 .

[7]  Zhifeng Ren,et al.  Relationship between thermoelectric figure of merit and energy conversion efficiency , 2015, Proceedings of the National Academy of Sciences.

[8]  Yaniv Gelbstein,et al.  Functional Graded Germanium–Lead Chalcogenide‐Based Thermoelectric Module for Renewable Energy Applications , 2015 .

[9]  G. J. Snyder,et al.  Dense dislocation arrays embedded in grain boundaries for high-performance bulk thermoelectrics , 2015, Science.

[10]  Kenneth McEnaney,et al.  High thermoelectric conversion efficiency of MgAgSb-based material with hot-pressed contacts , 2015 .

[11]  A. Yamamoto,et al.  Measurement and simulation of thermoelectric efficiency for single leg. , 2015, The Review of scientific instruments.

[12]  Z. Ren,et al.  Current progress and future challenges in thermoelectric power generation: From materials to devices , 2015 .

[13]  Qian Zhang,et al.  Enhancement of Thermoelectric Performance of n‐Type PbSe by Cr Doping with Optimized Carrier Concentration , 2015 .

[14]  Zhifeng Ren,et al.  n-type thermoelectric material Mg2Sn0.75Ge0.25 for high power generation , 2015, Proceedings of the National Academy of Sciences.

[15]  Zhifeng Ren,et al.  Study on thermoelectric performance by Na doping in nanostructured Mg 1-x Na x Ag 0.97 Sb 0.99 , 2015 .

[16]  K. Mossi,et al.  Effect of various leg geometries on thermo-mechanical and power generation performance of thermoelectric devices , 2014 .

[17]  Zhifeng Ren,et al.  Investigating the thermoelectric properties of p-type half-Heusler Hfx(ZrTi)1−xCoSb0.8Sn0.2 by reducing Hf concentration for power generation , 2014 .

[18]  T. Tritt,et al.  Synthesis and thermoelectric performance of a p-type Bi0.4Sb1.6Te3 material developed via mechanical alloying , 2014 .

[19]  M. Kanatzidis,et al.  Broad temperature plateau for thermoelectric figure of merit ZT>2 in phase-separated PbTe0.7S0.3 , 2014, Nature Communications.

[20]  Kenneth McEnaney,et al.  High thermoelectric performance of MgAgSb-based materials , 2014 .

[21]  Minoru Taya,et al.  Design of segmented thermoelectric generator based on cost-effective and light-weight thermoelectric alloys , 2014 .

[22]  H. Hsu,et al.  Thermoelectric Properties of Nano/microstructured p-Type Bi0.4Sb1.6Te3 Powders Fabricated by Mechanical Alloying and Vacuum Hot Pressing , 2014, Journal of Electronic Materials.

[23]  B. Cho,et al.  A wearable thermoelectric generator fabricated on a glass fabric , 2014 .

[24]  M. Kanatzidis,et al.  Ultralow thermal conductivity and high thermoelectric figure of merit in SnSe crystals , 2014, Nature.

[25]  M. Taya,et al.  Design of linear shaped thermoelectric generator and self-integration using shape memory alloy , 2014 .

[26]  Mats Söderström,et al.  Electricity generation from low-temperature industrial excess heat—an opportunity for the steel industry , 2014 .

[27]  C. Aneziris,et al.  Improved Thermal Stress Resistance Parameters Considering Temperature Gradients for Bricks in Refractory Linings , 2014 .

[28]  Tiejun Zhu,et al.  Shifting up the optimum figure of merit of p -type bismuth telluride-based thermoelectric materials for power generation by suppressing intrinsic conduction , 2014 .

[29]  Xingyu Gao,et al.  Ultrahigh Thermoelectric Performance by Electron and Phonon Critical Scattering in Cu2Se1‐xIx , 2013, Advanced materials.

[30]  K. Nishio,et al.  Thermoelectric properties and durability at elevated temperatures of impurity doped n-type Mg2Si , 2013 .

[31]  Gang Chen,et al.  Understanding of the contact of nanostructured thermoelectric n-type Bi2Te2.7Se0.3 legs for power generation applications , 2013 .

[32]  Haijun Wu,et al.  Texturation boosts the thermoelectric performance of BiCuSeO oxyselenides , 2013 .

[33]  Gang Chen,et al.  Effect of Hf Concentration on Thermoelectric Properties of Nanostructured N‐Type Half‐Heusler Materials HfxZr1–xNiSn0.99Sb0.01 , 2013 .

[34]  Gang Chen,et al.  Studies on the Bi2Te3–Bi2Se3–Bi2S3 system for mid-temperature thermoelectric energy conversion , 2013 .

[35]  Doug Crane,et al.  TEG On-Vehicle Performance and Model Validation and What It Means for Further TEG Development , 2013, Journal of Electronic Materials.

[36]  Zhifeng Ren,et al.  Thermoelectric property enhancement by Cu nanoparticles in nanostructured FeSb2 , 2013 .

[37]  Shekhar D. Bhame,et al.  Enhanced thermoelectric performance in spark plasma textured bulk n-type BiTe2.7Se0.3 and p-type Bi0.5Sb1.5Te3 , 2013, 1305.2280.

[38]  Minking K. Chyu,et al.  Mathematical modeling and numerical characterization of composite thermoelectric devices , 2013 .

[39]  Hui Wang,et al.  Fast phase formation of double-filled p-type skutterudites by ball-milling and hot-pressing. , 2013, Physical chemistry chemical physics : PCCP.

[40]  Emil Sandoz-Rosado,et al.  On the Thomson effect in thermoelectric power devices , 2013 .

[41]  Ephraim Suhir,et al.  Predicted Thermal Stress in a Multileg Thermoelectric Module (TEM) Design , 2013 .

[42]  Kenneth E. Goodson,et al.  Thermal Cycling, Mechanical Degradation, and the Effective Figure of Merit of a Thermoelectric Module , 2013, Journal of Electronic Materials.

[43]  Kang Sun,et al.  Using the analytic network process (ANP) to determine method of waste energy recovery from engine , 2013 .

[44]  Bekir Sami Yilbas,et al.  Thermodynamics and thermal stress analysis of thermoelectric power generator: Influence of pin geometry on device performance , 2013 .

[45]  Ephraim Suhir,et al.  Assembly Bonded at the Ends: Could Thinner and Longer Legs Result in a Lower Thermal Stress in a Thermoelectric Module Design? , 2012 .

[46]  T. Takabatake,et al.  Thermoelectric properties of type-VIII clathrate Ba8Ga16Sn30 doped with Cu , 2012 .

[47]  Lauryn L. Baranowski,et al.  Concentrated solar thermoelectric generators , 2012 .

[48]  M. Kanatzidis,et al.  High-performance bulk thermoelectrics with all-scale hierarchical architectures , 2012, Nature.

[49]  Qian Zhang,et al.  Heavy doping and band engineering by potassium to improve the thermoelectric figure of merit in p-type PbTe, PbSe, and PbTe(1-y)Se(y). , 2012, Journal of the American Chemical Society.

[50]  Duck-Kyun Choi,et al.  Prediction of reliability on thermoelectric module through accelerated life test and Physics-of-failure , 2011 .

[51]  S. Dou,et al.  Al-doped zinc oxide nanocomposites with enhanced thermoelectric properties. , 2011, Nano letters.

[52]  Gang Chen,et al.  High-performance flat-panel solar thermoelectric generators with high thermal concentration. , 2011, Nature materials.

[53]  Miaofang Chi,et al.  Multiple-filled skutterudites: high thermoelectric figure of merit through separately optimizing electrical and thermal transports. , 2011, Journal of the American Chemical Society.

[54]  Qungui Du,et al.  Thermal Stress Analysis and Structure Parameter Selection for a Bi2Te3-Based Thermoelectric Module , 2011 .

[55]  Gang Chen,et al.  Enhanced thermoelectric figure of merit of p-type half-Heuslers. , 2011, Nano letters.

[56]  Eric S. Toberer,et al.  Composition and the thermoelectric performance of β-Zn4Sb3 , 2010 .

[57]  Zhifeng Ren,et al.  Enhancement of Thermoelectric Figure‐of‐Merit by a Bulk Nanostructuring Approach , 2010 .

[58]  P. Ziolkowski,et al.  Estimation of Thermoelectric Generator Performance by Finite Element Modeling , 2010 .

[59]  D Kraemer,et al.  Thermoelectric properties and efficiency measurements under large temperature differences. , 2009, The Review of scientific instruments.

[60]  G. Kotliar,et al.  Peierls distortion as a route to high thermoelectric performance in In4Se3-δ crystals , 2009, Nature.

[61]  K. T. Chau,et al.  Thermoelectric automotive waste heat energy recovery using maximum power point tracking , 2009 .

[62]  Jean-Pierre Fleurial,et al.  Thermoelectric power generation materials: Technology and application opportunities , 2009 .

[63]  D. Vasilevskiy,et al.  Numerical Simulation of the Thermomechanical Behavior of Extruded Bismuth Telluride Alloy Module , 2009 .

[64]  Lidong Chen,et al.  High temperature reliability evaluation of CoSb3/electrode thermoelectric joints , 2009 .

[65]  Hohyun Lee,et al.  Enhanced thermoelectric figure of merit in nanostructured n-type silicon germanium bulk alloy , 2008 .

[66]  Hohyun Lee,et al.  Enhanced thermoelectric figure-of-merit in nanostructured p-type silicon germanium bulk alloys. , 2008, Nano letters.

[67]  L. Bell Cooling, Heating, Generating Power, and Recovering Waste Heat with Thermoelectric Systems , 2008, Science.

[68]  Xinbing Zhao,et al.  High figures of merit and natural nanostructures in Mg2Si0.4Sn0.6 based thermoelectric materials , 2008 .

[69]  Khalid M. Saqr,et al.  Thermal design of automobile exhaust based thermoelectric generators: Objectives and challenges , 2008 .

[70]  M. Dresselhaus,et al.  High-Thermoelectric Performance of Nanostructured Bismuth Antimony Telluride Bulk Alloys , 2008, Science.

[71]  Min Zhou,et al.  Nanostructured AgPb(m)SbTe(m+2) system bulk materials with enhanced thermoelectric performance. , 2008, Journal of the American Chemical Society.

[72]  G. J. Snyder,et al.  Complex thermoelectric materials. , 2008, Nature materials.

[73]  James C. Kellogg,et al.  Energy scavenging for small-scale unmanned systems , 2006 .

[74]  Wing Ng,et al.  Thermoelectric-Based Power System for Unmanned-Air-Vehicle/ Microair-Vehicle Applications , 2004 .

[75]  D. Rowe,et al.  Thermoelectric figure-of-merit under large temperature differences , 2004 .

[76]  M. Kanatzidis,et al.  Cubic AgPbmSbTe2+m: Bulk Thermoelectric Materials with High Figure of Merit , 2004, Science.

[77]  G. J. Snyder,et al.  Thermoelectric efficiency and compatibility. , 2003, Physical review letters.

[78]  P. Vianco,et al.  The compression stress-strain behavior of Sn-Ag-Cu solder , 2003 .

[79]  Z. P. Wang,et al.  Effect of Temperature and Strain Rate on Mechanical Properties of 63Sn/37Pb Solder Alloy , 1999 .

[80]  G. Ravichandran,et al.  Mechanical behaviour of a hot pressed aluminum nitride under uniaxial compression , 1998 .

[81]  Ephraim Suhir,et al.  Stresses in Bi-Metal Thermostats , 1986 .

[82]  D. Hasselman,et al.  Figures-of-merit for the thermal stress resistance of high-temperature brittle materials: a review , 1978 .

[83]  A. Efremov,et al.  Energy calculation of thermoelements with arbitrary temperature dependence of thermoelectric properties of materials by heat balance technique , 1971 .

[84]  J. Sunderland,et al.  The influence of the Thomson effect on the performance of a thermoelectric power generator , 1964 .

[85]  H J Goldsmid,et al.  The performance of bismuth telluride thermojunctions , 1958 .

[86]  Vinayak P. Dravid,et al.  The panoscopic approach to high performance thermoelectrics , 2014 .

[87]  Gang Chen,et al.  Nanostructured Thermoelectric Materials , 2013 .

[88]  Keishi Nishio,et al.  Stress Analysis and Output Power Measurement of an n-Mg2Si Thermoelectric Power Generator with an Unconventional Structure , 2013, Journal of Electronic Materials.

[89]  M. Dresselhaus,et al.  Perspectives on thermoelectrics: from fundamentals to device applications , 2012 .

[90]  Gang Chen,et al.  Recent advances in thermoelectric nanocomposites , 2012 .

[91]  C. Liao,et al.  Evaluation of Diffusion Barrier Between Lead-Free Solder Systems and Thermoelectric Materials , 2011, Journal of Electronic Materials.

[92]  W. Kingery,et al.  Factors Affecting Thermal Stress Resistance of Ceramic Materials , 1955 .