Darcy's law‐based models for liquid absorption in polymer wicks

Wicking of liquids in polymer wicks made of sintered polymer beads is studied experimentally where three different polymer wicks (made from polycarbonate, polyethylene, and polypropylene) and three different well-characterized liquids (hexadecane, decane, and dodecane) are used to plot the mass of wicked liquid as a function of time. The experimental results are compared with the predictions from the Washburn equation as well as a Darcy's law-based formulation. The suction pressure needed to pull the liquid up a wick in the formulation is modeled using a new energy balance (EB) method and a capillary method. In the former, the released surface energy during wetting is equated to the viscous losses during liquid motion; in the latter, the suction pressure is obtained by treating the wick pore-space as a bundle of capillary tubes. The Darcy's law-based formulation also considers the effect of gravity in its predictions. The newly proposed EB method in conjunction with gravity yields the most satisfying predictions. All parameters used in the proposed model were measured independently and no fitting parameters were used. The success of this method is especially notable for a large-pore polypropylene wick where it was the only model to predict the final steady-state height for the liquid column. © 2007 American Institute of Chemical Engineers AIChE J, 2007

[1]  T. Young.  III. An essay on the cohesion of fluids , 1805, Philosophical Transactions of the Royal Society of London.

[2]  Richard Lucas,et al.  Ueber das Zeitgesetz des kapillaren Aufstiegs von Flüssigkeiten , 1918 .

[3]  E. W. Washburn.  The Dynamics of Capillary Flow , 1921 .

[4]  F. Fowkes.  Role of Surface Active Agents in Wetting , 1953 .

[5]  J. Szekely,et al.  The rate of capillary penetration and the applicability of the washburn equation , 1971 .

[6]  J. Bear.  Dynamics of Fluids in Porous Media , 1975 .

[7]  S. Chwastiak,et al.  A wicking method for measuring wetting properties of carbon yarns , 1973 .

[8]  J. G. Williams,et al.  Liquid flow through aligned fiber beds , 1974 .

[9]  S. H. Davis,et al.  On the motion of a fluid-fluid interface along a solid surface , 1974, Journal of Fluid Mechanics.

[10]  E. B. Dussan,et al.  LIQUIDS ON SOLID SURFACES: STATIC AND DYNAMIC CONTACT LINES , 1979 .

[11]  J. Berg,et al.  The effect of surfactants on wicking flow in fiber networks , 1988 .

[12]  R. Skalak,et al.  THE HISTORY OF POISEUILLE'S LAW , 1993 .

[13]  A. R. Ganji,et al.  Introduction to Engineering Experimentation , 1995 .

[14]  Suresh G. Advani,et al.  Wicking across a Fiber-Bank , 1996 .

[15]  E. Kissa,et al.  Wetting and Wicking , 1996 .

[16]  S. Russell,et al.  Apparatus and Method for the Assessment of In-plane Anisotropic Liquid Absorption in Nonwoven Fabrics , 2000 .

[17]  B. Miller.  Critical Evaluation of Upward Wicking Tests , 2000 .

[18]  J. Jeong.  Slip boundary condition on an idealized porous wall , 2001 .

[19]  J. Parlange,et al.  Anomalous water absorption in porous materials , 2003 .

[20]  Ningtao Mao,et al.  Anisotropic liquid absorption in homogeneous two-dimensional nonwoven structures , 2003 .

[21]  P. Gane,et al.  Absorption Rate and Volume Dependency on the Complexity of Porous Network Structures , 2004 .

[22]  W. Wakeham,et al.  The Viscosity and Density of n-Dodecane and n-Octadecane at Pressures up to 200 MPa and Temperatures up to 473 K , 2004 .