Simultaneous measurement of the solubility of nitrogen and carbon dioxide in polystyrene and of the associated polymer swelling

New experimental results for the solubility of nitrogen and carbon dioxide in polystyrene are reported, accompanied by data on the change in volume of the polymer caused by the sorption process. The two phenomena were measured simultaneously with a combined technique, in which the quantity of penetrating fluid introduced into the system was evaluated by pressure-decay measurements in a calibrated volume, whereas a vibrating-wire force sensor was employed for weighing the polymer sample during sorption inside of the high-pressure equilibrium cell. The use of the two techniques was necessary because the effects of swelling and solubility could not be decoupled in a single gravimetric or pressure-decay measurement. The sorption of nitrogen in polystyrene was studied along three isotherms from 313 to 353 K at pressures up to 70 MPa. The sorption of carbon dioxide was measured along four isotherms from 338 to 402 K up to 45 MPa. The results are compared with values from the literature when possible, although our data extend significantly the pressure ranges of the latter. The uncertainties affecting our measurements with nitrogen are 1 mg of N 2 /g of polystyrene in solubility and 0.1% of the volume of the polymer. For carbon dioxide, the uncertainties are 5 mg of N 2 /g of polystyrene and 0.5% respectively, carbon dioxide being about 1 order of magnitude more soluble than nitrogen.

[1]  H. Masuoka,et al.  Solubilities of carbon dioxide and nitrogen in polystyrene under high temperature and pressure , 1996 .

[2]  E. Beckman,et al.  Generation of microcellular polymeric foams using supercritical carbon dioxide. I: Effect of pressure and temperature on nucleation , 1994 .

[3]  R. D. Venter,et al.  Low density microcellular foam processing in extrusion using CO2 , 1998 .

[4]  W. Wakeham,et al.  The Transport Properties of Carbon Dioxide , 1990 .

[5]  Sumarno,et al.  Solubilities and diffusion coefficients of carbon dioxide and nitrogen in polypropylene, high-density polyethylene, and polystyrene under high pressures and temperatures , 1999 .

[6]  E. Beckman,et al.  Generation of microcellular polymeric foams using supercritical carbon dioxide. II: Cell growth and skin formation , 1994 .

[7]  J. W. Barlow,et al.  Plasticization of glassy polymers by CO2 , 1985 .

[8]  Isaac C. Sanchez,et al.  Statistical thermodynamics of fluid mixtures , 1976 .

[9]  Chul B. Park,et al.  The effect of talc on cell nucleation in extrusion foam processing of polypropylene with CO2 and isopentane , 1998 .

[10]  T. Chow.  Molecular Interpretation of the Glass Transition Temperature of Polymer-Diluent Systems , 1980 .

[11]  A. Pádua,et al.  Simultaneous measurement of the solubility of gases in polymers and of the associated volume change , 2000 .

[12]  Richard T. Jacobsen,et al.  Thermodynamic Properties of Nitrogen from the Freezing Line to 2000 K at Pressures to 1000 MPa , 1986 .

[13]  B. Briscoe,et al.  Gas-induced damage in elastomeric composites , 1990 .

[14]  Wolf R. Vieth,et al.  Dual sorption theory , 1976 .

[15]  Zhiyi Zhang,et al.  Anin situ study of plasticization of polymers by high-pressure gases , 1998 .

[16]  W. R. Murray,et al.  Cell nucleation in solid-state polymeric foams: evidence of a triaxial tensile failure mechanism , 1999 .

[17]  I. Sanchez,et al.  Statistical Thermodynamics of Polymer Solutions , 1978 .

[18]  M. Paulaitis,et al.  Swelling and sorption in polymer-CO2 mixtures at elevated pressures , 1987 .

[19]  Y. Handa,et al.  Plasticization of Polystyrene by High Pressure Gases: A Calorimetric Study , 1994 .

[20]  Jinhuan Wu,et al.  Development of HFC blowing agents. Part II: Expanded polystyrene insulating boards , 1998 .

[21]  K. Stephan,et al.  Viscosity and Thermal Conductivity of Nitrogen for a Wide Range of Fluid States , 1987 .

[22]  Benny D. Freeman,et al.  Hydrocarbon and fluorocarbon solubility and dilation in poly(dimethylsiloxane): Comparison of experimental data with predictions of the Sanchez–Lacombe equation of state , 1999 .

[23]  Isaac C. Sanchez,et al.  An elementary molecular theory of classical fluids. Pure fluids , 1976 .