Pretreatment and Fractionation of Corn Stover by Soaking In Ethanol and Aqueous Ammonia

A new process for pretreatment of lignocellulosic biomass, designated the soaking in ethanol and aqueous ammonia (SEAA) process, was developed to improve hemicellulose preservation in solid form. In the SEAA process, an aqueous ammonia solution containing ethanol is used. Corn stover was treated with 15 wt.% ammonia at 1:9 solid–liquid ratio (by weight) at 60 °C for 24 h with ethanol added at 1, 5, 20, and 49 wt.% (balance was water). The extents by which xylan was solubilized with no ethanol and with ethanol added at 1, 5, 20, and 49 wt.% of the total liquid were 17.2%, 16.7%, 14.5%, 10.4%, and 6.3% of the original xylan, respectively. Thus, at the highest ethanol concentration used the loss of hemicellulose to the liquid phase was reduced by 63%. The digestibility of glucan and xylan in the pretreated corn stover samples by cellulase was not affected by ethanol addition of up to 20 wt.%. The enzymatic digestibility of the corn stover treated with 49 wt.% ethanol added was lower than the digestibility of the sample treated with no ethanol addition. Thus, based on these results, 20 wt.% was found to be the optimum ethanol concentration for use in the SEAA process for pretreatment of corn stover.

[1]  Bryce J. Stokes,et al.  Biomass as Feedstock for A Bioenergy and Bioproducts Industry: The Technical Feasibility of a Billion-Ton Annual Supply , 2005 .

[2]  K. Réczey,et al.  Fractionation and utilisation of corn fibre carbohydrates , 2005 .

[3]  Y. Y. Lee,et al.  Pretreatment of corn stover by soaking in aqueous ammonia at moderate temperatures , 2007, Applied biochemistry and biotechnology.

[4]  R. Sun,et al.  Fractional isolation, physico-chemical characterization and homogeneous esterification of hemicelluloses from fast-growing poplar wood , 2001 .

[5]  Kati Réczey,et al.  Corn fiber as a raw material for hemicellulose and ethanol production , 2007 .

[6]  M. Holtzapple,et al.  Fundamental factors affecting biomass enzymatic reactivity , 2000, Applied biochemistry and biotechnology.

[7]  Teodoro Espinosa-Solares,et al.  Macroscopic mass and energy balance of a pilot plant anaerobic bioreactor operated under thermophilic conditions , 2006, Applied biochemistry and biotechnology.

[8]  Sheryl A. Martin,et al.  Breaking the Biological barriers to Cellulosic Ethanol: A Joint Research Agenda , 2006 .

[9]  Amie D. Sluiter,et al.  Determination of Structural Carbohydrates and Lignin in Biomass , 2004 .

[10]  Y Y Lee,et al.  Pretreatment of corn stover by aqueous ammonia. , 2003, Bioresource technology.

[11]  Run-Cang Sun,et al.  Fractional separation and physico-chemical analysis of lignins from the black liquor of oil palm trunk fibre pulping , 2001 .

[12]  A. A. Shatalov,et al.  Ethanol-Enhanced Alkaline Pulping of Arundo donax L. Reed: Influence of Solvent on Pulp Yield and Quality , 2002 .

[13]  R. Sun,et al.  Isolation and characterisation of cellulose obtained by a two-stage treatment with organosolv and cyanamide activated hydrogen peroxide from wheat straw , 2004 .

[14]  Y. Y. Lee,et al.  Pretreatment of corn stover by soaking in aqueous ammonia , 2005, Applied biochemistry and biotechnology.

[15]  J. R. Hess,et al.  Cellulosic biomass feedstocks and logistics for ethanol production , 2007 .

[16]  C. Mooney.  Substrate factors limiting the enzymatic hydrolysis of softwood substrates , 1998 .

[17]  B. Dale,et al.  Global potential bioethanol production from wasted crops and crop residues , 2004 .