Grain boundaries in CdTe thin film solar cells: a review

The current state of knowledge on the impact of grain boundaries in CdTe solar cells is reviewed with emphasis being placed on working cell structures. The role of the chemical composition of grain boundaries as well as growth processes are discussed, along with characterisation techniques such as electron beam induced current and cathodoluminescence, which are capable of extracting information on a level of resolution comparable to the size of the grain boundaries. Work which attempts to relate grain boundaries to device efficiency is also assessed and gaps in the current knowledge are highlighted.

[1]  Sylvain Marsillac,et al.  Study of the influence of annealing on the properties of CBD-CdS thin films , 2003 .

[2]  P. Selvaraj,et al.  High efficiency CSS CdTe solar cells , 2000 .

[3]  J. Sites,et al.  Cadmium Telluride Solar Cells , 2011 .

[4]  J. Venables,et al.  Nucleation and growth of thin films , 1984 .

[5]  W. Jaegermann,et al.  Physical characterization of thin‐film solar cells , 2004 .

[6]  K. Durose,et al.  EBIC and luminescence mapping of CdTe/CdS solar cells , 2000 .

[7]  W. Jaegermann,et al.  Growth regimes of CdTe deposited by close-spaced sublimation for application in thin film solar cells , 2007 .

[8]  N. Romeo,et al.  Polycrystalline CdTe thin films for photovoltaic applications , 2006 .

[9]  D. Albin,et al.  Fabrication procedures and process sensitivities for CdS/CdTe solar cells , 1999 .

[10]  S. Irvine,et al.  MOCVD of thin film photovoltaic solar cells—Next-generation production technology? , 2008 .

[11]  M. Young,et al.  Dependence of carrier lifetime on Cu-contacting temperature and ZnTe:Cu thickness in CdS/CdTe thin film solar cells☆ , 2009 .

[12]  P. Dawson,et al.  Photoluminescence spectroscopy and decay time measurements of polycrystalline thin film CdTe/CdS solar cells , 2000 .

[13]  Y. Shim,et al.  Grain growth, anomalous scaling, and grain boundary grooving in polycrystalline CdTe thin films , 2014 .

[14]  S. Irvine,et al.  In situ deposition of cadmium chloride films using MOCVD for CdTe solar cells , 2007 .

[15]  R. Reedy,et al.  Single-crystal CdTe solar cells with Voc greater than 900 mV , 2014 .

[16]  D. Lane,et al.  Sulphur diffusion in cadmium telluride thin films part 2: modelling grain-boundary diffusion , 2003 .

[17]  David Cahen,et al.  Understanding the Beneficial Role of Grain Boundaries in Polycrystalline Solar Cells from Single‐Grain‐Boundary Scanning Probe Microscopy , 2006 .

[18]  K. Durose,et al.  A low-cost non-toxic post-growth activation step for CdTe solar cells , 2014, Nature.

[19]  C. Wolden,et al.  The roles of ZnTe buffer layers on CdTe solar cell performance , 2016 .

[20]  D. Kuciauskas,et al.  Quantitative determination of grain boundary recombination velocity in CdTe by combination of cathodoluminescence measurements and numerical simulations , 2015, 2015 IEEE 42nd Photovoltaic Specialist Conference (PVSC).

[21]  M. Young,et al.  CdCl2 treatment, S diffusion, and recombination in polycrystalline CdTe , 2006 .

[22]  M. Al‐Jassim,et al.  Quantitative Determination of Grain-Boundary Recombination Velocity in CdTe by Cathodoluminescence Measurements and Numerical Simulations , 2015, IEEE Journal of Photovoltaics.

[23]  Andreas Klein,et al.  CdTe thin film solar cells: Interrelation of nucleation, structure, and performance , 2009 .

[24]  G. Feuillet,et al.  Local band bending and grain-to-grain interaction induced strain nonuniformity in polycrystalline CdTe films , 2014 .

[25]  H. Hwang,et al.  Oxygen doping in close-spaced-sublimed CdTe thin films for photovoltaic cells , 1986 .

[26]  Xiaonan Li,et al.  Enhanced performance of CdS/CdTe thin-film devices through temperature profiling techniques applied to close-spaced sublimation deposition , 1996, Conference Record of the Twenty Fifth IEEE Photovoltaic Specialists Conference - 1996.

[27]  Jie Zhou,et al.  Nanostructured CdS:O film: preparation, properties, and application , 2004 .

[28]  X. S. Wu,et al.  Effects of oxidation and CdCl2 treatment on the electronic properties of CdTe polycrystalline films , 2015 .

[29]  Martin A. Green,et al.  Solar cell efficiency tables (Version 61) , 2022, Progress in Photovoltaics: Research and Applications.

[30]  Maxim Abashin,et al.  Nanoscale imaging of photocurrent and efficiency in CdTe solar cells. , 2014, ACS nano.

[31]  K. M. Jones,et al.  Grain boundary character and recombination properties in CdTe thin films , 2013, 2013 IEEE 39th Photovoltaic Specialists Conference (PVSC).

[32]  Ş. Oktik,et al.  Transmission electron microscopy of CdTe/CdS based solar cells , 1996 .

[33]  H. Guthrey,et al.  Cathodoluminescence Analysis of Grain Boundaries and Grain Interiors in Thin-Film CdTe , 2014, IEEE Journal of Photovoltaics.

[34]  Sidney R. Cohen,et al.  Direct evidence for grain-boundary depletion in polycrystalline CdTe from nanoscale-resolved measurements , 2003 .

[35]  H. Guthrey,et al.  Recombination by grain-boundary type in CdTe , 2015 .

[36]  H. Moutinho,et al.  Microtexture of chloride treated CdTe thin films deposited by CSS technique , 2008 .

[37]  A. Rockett,et al.  Direct observation of electrical properties of grain boundaries in sputter-deposited CdTe using scan-probe microwave reflectivity based capacitance measurements , 2015 .

[38]  Suhuai Wei,et al.  Research strategies toward improving thin-film CdTe photovoltaic devices beyond 20% conversion efficiency , 2013 .

[39]  M. Burgelman,et al.  Interdiffusion of CdS and CdTe in screenprinted and sintered CdS-CdTe solar cells , 1991, The Conference Record of the Twenty-Second IEEE Photovoltaic Specialists Conference - 1991.

[40]  M. Scarpulla,et al.  Characterization of Sputtered CdTe Thin Films with Electron Backscatter Diffraction and Correlation with Device Performance , 2015, Microscopy and Microanalysis.

[41]  G. Feuillet,et al.  Effects of island coalescence on the compensation mechanisms in chlorine doped polycrystalline CdTe , 2007 .

[42]  B. Hamadani,et al.  Local electrical characterization of cadmium telluride solar cells using low-energy electron beam , 2013 .

[43]  Mowafak Al-Jassim,et al.  Grain-boundary-enhanced carrier collection in CdTe solar cells. , 2014, Physical review letters.

[44]  M. Al‐Jassim,et al.  Cathodoluminescence of Cu diffusion in CdTe thin films for CdTe/CdS solar cells , 2002 .

[45]  G. Conibeer,et al.  Sulfur diffusion in cadmium telluride thin films: Part 1: the grain boundary diffusion coefficient , 2003 .

[46]  S. Irvine,et al.  Increased conversion efficiency in cadmium telluride photovoltaics by luminescent downshifting with quantum dot/poly(methyl methacrylate) films , 2015 .

[47]  L. Kazmerski,et al.  Micro through nanostructure investigations of polycrystalline CdTe: correlations with processing and electronic structures , 1994, Proceedings of 1994 IEEE 1st World Conference on Photovoltaic Energy Conversion - WCPEC (A Joint Conference of PVSC, PVSEC and PSEC).

[48]  Suhuai Wei,et al.  Tuning the Fermi level beyond the equilibrium doping limit through quenching: The case of CdTe , 2014 .

[49]  R. Birkmire,et al.  Interdiffusion of CdS/CdTe thin films: Modeling x-ray diffraction line profiles , 2001 .

[50]  K. Durose,et al.  Early stage growth mechanisms of CdTe thin films deposited by close space sublimation for solar cells , 2011 .

[51]  M. Young,et al.  Study of ZnTe:Cu/Metal Interfaces in CdS/CdTe Phovoltaic Solar Cells , 2003 .

[52]  C. Ferekides,et al.  CdTe thin film solar cells: device and technology issues , 2004 .

[53]  J. Sites,et al.  LBIC analysis of thin-film polycrystalline solar cells , 2005, Conference Record of the Thirty-first IEEE Photovoltaic Specialists Conference, 2005..

[54]  K. Durose,et al.  Characterisation of thin film CdS/CdTe solar cells using electron and optical beam induced current , 1999 .

[55]  J. Granata,et al.  Losses due to polycrystallinity in thin-film solar cells , 1998 .

[56]  G. Robinson,et al.  The effects of CdCl/sub 2/ on CdTe electrical properties using a new theory for grain-boundary conduction , 2000, Conference Record of the Twenty-Eighth IEEE Photovoltaic Specialists Conference - 2000 (Cat. No.00CH37036).

[57]  I. Forbes,et al.  Control of grain size in sublimation-grown CdTe, and the improvement in performance of devices with systematically increased grain size , 2010 .

[58]  High-resolution local current measurement of CdTe solar cells , 2012, 2012 38th IEEE Photovoltaic Specialists Conference.

[59]  W. Jaegermann,et al.  12% efficient CdTe/CdS thin film solar cells deposited by low-temperature close space sublimation , 2011 .

[60]  A. Mascarenhas,et al.  Measuring long-range carrier diffusion across multiple grains in polycrystalline semiconductors by photoluminescence imaging , 2013, Nature Communications.

[61]  M. Al‐Jassim,et al.  Do grain boundaries assist S diffusion in polycrystalline CdS/CdTe heterojunctions? , 2001 .

[62]  C. H. Seager,et al.  The dc voltage dependence of semiconductor grain‐boundary resistance , 1979 .

[63]  U. Reislöhner,et al.  Formation of CdSxTe1–x at the p‐n junction of CdS‐CdTe solar cells , 2009 .

[64]  L. Nasi,et al.  Interface properties of HCF2Cl annealed CdTe thin films for solar cells applications , 2008 .

[65]  Qi Chen,et al.  Planar heterojunction perovskite solar cells via vapor-assisted solution process. , 2014, Journal of the American Chemical Society.

[66]  Y. S. Lin,et al.  Enhanced electrical properties at boundaries including twin boundaries of polycrystalline CdTe thin-film solar cells. , 2015, Physical chemistry chemical physics : PCCP.

[67]  Wanli Yang,et al.  Effects of postdeposition treatments on surfaces of CdTe/CdS solar cells , 2010 .

[68]  J. Méndez-Gamboa,et al.  Nucleation and growth mechanism of CdTe cluster grown on CdS films , 2007 .

[69]  ScienceDirect.  Progress in crystal growth and characterization of materials , 1990 .

[70]  J. Noh,et al.  Chemical management for colorful, efficient, and stable inorganic-organic hybrid nanostructured solar cells. , 2013, Nano letters.

[71]  D. Misra,et al.  Evaluation of Cu Back Contact Related Deep Defects in CdTe Solar Cells , 2012 .

[72]  G. West,et al.  The effect of cadmium chloride treatment on close spaced sublimated cadmium telluride thin film solar cells , 2012, 2012 IEEE 38th Photovoltaic Specialists Conference (PVSC) PART 2.

[73]  S. Johnston,et al.  Resetting the defect chemistry in CdTe , 2015, 2015 IEEE 42nd Photovoltaic Specialist Conference (PVSC).

[74]  Angelo Mascarenhas,et al.  Near-field optical beam-induced currents in CdTe∕CdS solar cells: Direct measurement of enhanced photoresponse at grain boundaries , 2004 .

[75]  H. Morgner,et al.  Effect of chlorine activation treatment on electron beam induced current signal distribution of cadmium telluride thin film solar cells , 2013 .

[76]  J. Drayton,et al.  High efficiency, magnetron sputtered CdS/CdTe solar cells , 2004 .

[77]  P. N. Gibson,et al.  Investigation of sulphur diffusion at the CdS/CdTe interface of thin‐film solar cells , 2002 .

[78]  Mowafak Al-Jassim,et al.  Direct evidence of enhanced chlorine segregation at grain boundaries in polycrystalline CdTe thin films via three‐dimensional TOF‐SIMS imaging , 2015 .

[79]  S. G. Kumar,et al.  Physics and chemistry of CdTe/CdS thin film heterojunction photovoltaic devices: fundamental and critical aspects , 2014 .

[80]  D. Cahen,et al.  How Polycrystalline Devices Can Outperform Single‐Crystal Ones: Thin Film CdTe/CdS Solar Cells , 2004 .

[81]  W. A. Pinheiro,et al.  Influence of deposition parameters on the properties of CdTe films deposited by close spaced sublimation , 2006 .

[82]  Martin A. Green,et al.  Solar cell efficiency tables (version 46) , 2015 .

[83]  L. Kranz,et al.  A comprehensive picture of Cu doping in CdTe solar cells , 2013 .

[84]  K. Durose,et al.  A Comparative Study of the Effects of Nontoxic Chloride Treatments on CdTe Solar Cell Microstructure and Stoichiometry , 2015 .

[85]  C. Ferekides,et al.  Effects of thermal stressing on CdTe/CdS solar cells , 2002, Conference Record of the Twenty-Ninth IEEE Photovoltaic Specialists Conference, 2002..

[86]  M. Scarpulla,et al.  The correlation of performance in CdTe photovoltaics with grain boundaries , 2012, 2012 19th IEEE International Symposium on the Physical and Failure Analysis of Integrated Circuits.

[87]  Isik C. Kizilyalli,et al.  27.6% Conversion efficiency, a new record for single-junction solar cells under 1 sun illumination , 2011, 2011 37th IEEE Photovoltaic Specialists Conference.

[88]  Nicola Romeo,et al.  An innovative process suitable to produce high-efficiency CdTe/CdS thin-film modules , 2010 .

[89]  G. Salviati,et al.  A study of the CdTe treatment with a Freon gas such as CHF2Cl , 2008 .

[90]  M. Young,et al.  Post-deposition processing options for high-efficiency sputtered CdS/CdTe solar cells , 2014 .

[91]  K. Durose,et al.  Long Lifetime Hole Traps at Grain Boundaries in CdTe Thin-Film Photovoltaics. , 2015, Physical review letters.

[92]  L. Kranz,et al.  Tailoring Impurity Distribution in Polycrystalline CdTe Solar Cells for Enhanced Minority Carrier Lifetime , 2014 .

[93]  Kelvin G. Lynn,et al.  CdTe solar cells with open-circuit voltage breaking the 1 V barrier , 2016 .

[94]  D. Bonnet,et al.  Dependence of CdS/CdTe thin film solar cell characteristics on the processing conditions , 1996 .

[95]  J. A. Poce-Fatou,et al.  A versatile computer‐controlled high‐resolution LBIC system , 2004 .

[96]  X. Mathew,et al.  Influence of oxygen concentration in the CdCl2 treatment process on the photovoltaic properties of CdTe/CdS solar cells , 2015 .

[97]  G. R. Awan.  Cadmium telluride for solar cells , 1987 .

[98]  K. Durose,et al.  Doping levels, trap density of states and the performance of co-doped CdTe(As,Cl) photovoltaic devices , 2009 .

[99]  M. Contreras,et al.  Beam injection methods for characterizing thin‐film solar cells , 2002 .

[100]  D. Leonard,et al.  Carrier separation at dislocation pairs in CdTe. , 2013, Physical review letters.

[101]  H. Jehn.  Nucleation and Growth of Thin Films , 1992 .

[102]  K. Durose,et al.  Assessment of Photovoltaic Junction Position in CdTe Solar Cells Using a Combined FIB-EBIC Technique , 2012 .

[103]  G. Feuillet,et al.  Local redistribution of dopants and defects induced by annealing in polycrystalline compound semiconductors , 2009 .

[104]  T. Raadik,et al.  Effect of CdCl2 annealing treatment on structural and optoelectronic properties of close spaced sublimation CdTe/CdS thin film solar cells vs deposition conditions , 2015 .

[105]  L. Kazmerski,et al.  Electrical properties of CdTe/CdS solar cells investigated with conductive atomic force microscopy , 2006 .

[106]  L. Kazmerski,et al.  Studies of Recrystallization of CdTe Thin Films After CdCl Treatment , 1997 .

[107]  Oleg V. Sulima,et al.  Role of oxygen during CdTe growth for CdTe photovoltaic devices , 2014 .

[108]  Wei Wang,et al.  Device Characteristics of CZTSSe Thin‐Film Solar Cells with 12.6% Efficiency , 2014 .

[109]  Shiro Nishiwaki,et al.  Doping of polycrystalline CdTe for high-efficiency solar cells on flexible metal foil , 2013, Nature Communications.

[110]  V. Buschmann,et al.  Spatially resolved measurements of charge carrier lifetimes in CdTe solar cells , 2013 .

[111]  G. Zoppi,et al.  Grain and crystal texture properties of absorber layers in MOCVD-grown CdTe/CdS solar cells , 2006 .

[112]  S. Haigh,et al.  S–Te Interdiffusion within Grains and Grain Boundaries in CdTe Solar Cells , 2014, IEEE Journal of Photovoltaics.

[113]  D. Levi,et al.  The role of oxygen in CdS/CdTe solar cells deposited by close-spaced sublimation , 1996, Conference Record of the Twenty Fifth IEEE Photovoltaic Specialists Conference - 1996.

[114]  Lars Stolt,et al.  World‐record Cu(In,Ga)Se2‐based thin‐film sub‐module with 17.4% efficiency , 2012 .

[115]  A. Tiwari,et al.  Flexible CdTe solar cells with high photovoltaic conversion efficiency , 2009, 2009 34th IEEE Photovoltaic Specialists Conference (PVSC).

[116]  Bin Chen,et al.  A string-inspired quintom model of dark energy , 2007, hep-th/0701016.

[117]  K. Durose,et al.  Investigation of post deposition CdCl2 treatment for fully sputtered CdTe/CdS thin film solar cells , 2012, 2012 38th IEEE Photovoltaic Specialists Conference.

[118]  S. Pennycook,et al.  Physics of grain boundaries in polycrystalline photovoltaic semiconductors , 2015 .

[119]  D. Albin,et al.  The effect of oxygen on interface microstructure evolution in CdS/CdTe solar cells , 2002 .

[120]  K. Durose,et al.  Impact of CdTe surface composition on doping and device performance in close Space sublimation deposited CdTe solar cells , 2011 .

[121]  A. Tiwari,et al.  Structural and chemical interface characterization of CdTe solar cells by transmission electron microscopy , 2003 .

[122]  D. Taylor,et al.  Scanning Kelvin probe measurements on As-doped CdTe solar cells , 2013 .

[123]  D. Levi,et al.  Time-resolved photoluminescence studies of CdTe solar cells , 2003 .

[124]  V. Karpov,et al.  Electron-beam induced degradation in CdTe photovoltaics , 2000 .

[125]  A. Morales-Acevedo,et al.  Influence of the growth conditions and postdeposition treatments upon the grain boundary barrier height of CdTe thin films deposited by close space vapor transport , 2001 .

[126]  L. Kranz,et al.  Effect of sodium on recrystallization and photovoltaic properties of CdTe solar cells , 2012 .

[127]  G. Agostinelli,et al.  Local inversion of photocurrent in cadmium telluride solar cells , 2003 .

[128]  Yanfa Yan,et al.  Effect of copassivation of Cl and Cu on CdTe grain boundaries. , 2008, Physical review letters.

[129]  Aidan A. Taylor,et al.  A comparative study of microstructural stability and sulphur diffusion in CdS/CdTe photovoltaic devices , 2015 .

[130]  Yun Li,et al.  Ellipsometric investigation of S–Te inter-diffusion and its effect on quantum efficiency of CdS/CdTe thin films solar cell , 2015 .

[131]  N. Amin,et al.  Prospects of Thickness Reduction of the CdTe Layer in Highly Efficient CdTe Solar Cells Towards 1 µm , 1999 .

[132]  K. Durose,et al.  Materials aspects of CdTe/CdS solar cells , 1999 .

[133]  Jonathan D. Poplawsky,et al.  Direct Imaging of Cl‐ and Cu‐Induced Short‐Circuit Efficiency Changes in CdTe Solar Cells , 2014 .

[134]  Yanfa Yan,et al.  Transmission electron microscopy study of dislocations and interfaces in CdTe solar cells , 2011 .

[135]  Vincent Barrioz,et al.  Progression of metalorganic chemical vapour‐deposited CdTe thin‐film PV devices towards modules , 2016 .

[136]  Xuanzhi Wu,et al.  High-efficiency polycrystalline CdTe thin-film solar cells , 2004 .

[137]  Suhuai Wei,et al.  Origin of novel diffusions of Cu and Ag in semiconductors: the case of CdTe. , 2013, Physical review letters.

[138]  R. Birkmire,et al.  Recrystallization and sulfur diffusion in CdCl2‐treated CdTe/CdS thin films , 1997 .

[139]  N. Jokerst,et al.  Copper migration in cdte heterojunction solar cells , 1996 .

[140]  J. Sites,et al.  Local photocurrent and resistivity measurements with micron resolution , 2000, Conference Record of the Twenty-Eighth IEEE Photovoltaic Specialists Conference - 2000 (Cat. No.00CH37036).

[141]  R. Collins,et al.  Evidence for grain-boundary-assisted diffusion of sulfur in polycrystalline CdS/CdTe heterojunctions , 1999 .

[142]  K. Durose,et al.  Focussed ion beam and field emission gun–scanning electron microscopy for the investigation of voiding and interface phenomena in thin‐film solar cells , 2012 .

[143]  M. Young,et al.  Role of Cu on the electrical properties of CdTe∕CdS solar cells: A cross-sectional conductive atomic force microscopy study , 2007 .

[144]  C. DeHart,et al.  High-efficiency polycrystalline CdTe thin-film solar cells with an oxygenated amorphous cds (a-CdS:O) window layer , 2002, Conference Record of the Twenty-Ninth IEEE Photovoltaic Specialists Conference, 2002..

[145]  K. Sun,et al.  XRF and high resolution TEM studies of Cu at the back contact in sputtered CdS/CdTe solar cells , 2008, 2008 33rd IEEE Photovoltaic Specialists Conference.

[146]  Ş. Oktik,et al.  Transmission electron microscopy of CdTeCdS based solar cells , 1996 .

[147]  M. Lonergan,et al.  Controlled activation of ZnTe:Cu contacted CdTe solar cells using rapid thermal processing , 2015 .

[148]  E. Sutter,et al.  High-resolution mapping of nonuniform carrier transport at contacts to polycrystalline CdTe/CdS solar cells , 2004 .

[149]  S. Irvine,et al.  CdCl2 treatment related diffusion phenomena in Cd1−xZnxS/CdTe solar cells , 2014 .

[150]  Degradation of CdTe Solar Cells: Simulation and Experiment , 2015, IEEE Journal of Photovoltaics.

[151]  G. Feuillet,et al.  Correlated structural reordering and dopant redistribution in annealed polycrystalline CdTe , 2009 .

[152]  A. Rockett,et al.  Direct Observation of CdCl2 Treatment Induced Grain Boundary Carrier Depletion in CdTe Solar Cells Using Scanning Probe Microwave Reflectivity Based Capacitance Measurements , 2016 .

[153]  Explanation of red spectral shifts at CdTe grain boundaries , 2013 .

[154]  K. Durose,et al.  Assessment of photovoltaic junction position using combined focused ion beam and electron beam‐induced current analysis of close space sublimation deposited CdTe solar cells , 2014 .

[155]  M. Al‐Jassim,et al.  The Nanometer-Resolution Local Electrical Potential and Resistance Mapping of CdTe Thin Films , 2013, IEEE Journal of Photovoltaics.

[156]  K. Durose,et al.  Study of buried junction and uniformity effects in CdTe/CdS solar cells using a combined OBIC and EQE apparatus , 2009 .