Protein Spray-Freeze Drying. Effect of Atomization Conditions on Particle Size and Stability

AbstractPurpose. To investigate the effect of atomization conditions on particle size and stability of spray-freeze dried protein. Methods. Atomization variables were explored for excipient-free (no zinc added) and zinc-complexed bovine serum albumin (BSA). Particle size was measured by laser diffraction light scattering following sonication in organic solvent containing poly(lactide-co-glycolide) (PLG). Powder surface area was determined from the N2 vapor sorption isotherm. Size-exclusion chromatography (SEC) was used to assess decrease in percent protein monomer. Fourier-transform infrared (FTIR) spectroscopy was employed to estimate protein secondary structure. PLG microspheres were made using a non-aqueous, cryogenic process and release of spray-freeze dried BSA was assessed in vitro. Results. The most significant atomization parameter affecting particle size was the mass flow ratio (mass of atomization N2 relative to that for liquid feed). Particle size was inversely related to specific surface area and the amount of protein aggregates formed. Zinc-complexation reduced the specific surface area and stabilized the protein against aggregation. FTIR data indicated perturbations in secondary structure upon spray-freeze drying for both excipient-free and zinc-complexed protein. Conclusions. Upon sonication, spray-freeze dried protein powders exhibited friability, or susceptibility towards disintegration. For excipient-free protein, conditions where the mass flow ratio was > ∼0.3 yielded sub-micron powders with relatively large specific surface areas. Reduced particle size was also linked to a decrease in the percentage of protein monomer upon drying. This effect was ameliorated by zinc-complexation, via a mechanism involving reduction in specific surface area of the powder rather than stabilization of secondary structure. Reduction of protein particle size was beneficial in reducing the initial release (burst) of the protein encapsulated in PLG microspheres.

[1]  E. Gabellieri,et al.  Proteins in frozen solutions: evidence of ice-induced partial unfolding. , 1996, Biophysical journal.

[2]  R. Langer,et al.  Polymers for sustained macromolecule release: procedures to fabricate reproducible delivery systems and control release kinetics. , 1980, Journal of pharmaceutical sciences.

[3]  J. Cleland,et al.  The Stabilization and Encapsulation of Human Growth Hormone into Biodegradable Microspheres , 1997, Pharmaceutical Research.

[4]  R. Siegel,et al.  A new Monte Carlo approach to diffusion in constricted porous geometries , 1986 .

[5]  T. Bewley,et al.  Effect of Freezing on Aggregation of Human Growth Hormone , 1991, Pharmaceutical Research.

[6]  Chung C. Hsu,et al.  Fourier‐transform Infrared Spectroscopy Demonstrates that Lyophilization Alters the Secondary Structure of Recombinant Human Growth Hormone , 1996 .

[7]  K. Griebenow,et al.  On the structural preservation of recombinant human growth hormone in a dried film of a synthetic biodegradable polymer. , 1999, Journal of pharmaceutical sciences.

[8]  A. Klibanov,et al.  Stability of Proteins and Their Delivery from Biodegradable Polymer Microspheres , 1996 .

[9]  M. Pikal,et al.  Physical chemistry of freeze-drying: measurement of sublimation rates for frozen aqueous solutions by a microbalance technique. , 1983, Journal of pharmaceutical sciences.

[10]  John Aurie Dean,et al.  Lange's Handbook of Chemistry , 1978 .

[11]  Steven J. Shire,et al.  Protein Inhalation Powders: Spray Drying vs Spray Freeze Drying , 1999, Pharmaceutical Research.

[12]  Chung C. Hsu,et al.  Surface Denaturation at Solid-Void Interface—A Possible Pathway by Which Opalescent Participates Form During the Storage of Lyophilized Tissue-Type Plasminogen Activator at High Temperatures , 2004, Pharmaceutical Research.

[13]  W. H. Elliott,et al.  Data for Biochemical Research , 1986 .

[14]  E. Teller,et al.  ADSORPTION OF GASES IN MULTIMOLECULAR LAYERS , 1938 .

[15]  Y. Maa,et al.  Spray-drying of air-liquid interface sensitive recombinant human growth hormone. , 1998, Journal of pharmaceutical sciences.

[16]  S J Prestrelski,et al.  Separation of freezing- and drying-induced denaturation of lyophilized proteins using stress-specific stabilization. II. Structural studies using infrared spectroscopy. , 1993, Archives of biochemistry and biophysics.

[17]  J. Carpenter,et al.  Are freezing and dehydration similar stress vectors? A comparison of modes of interaction of stabilizing solutes with biomolecules , 1990 .

[18]  K. Griebenow,et al.  Structure‐guided Encapsulation of Bovine Serum Albumin in Poly(DL‐lactic‐co‐glycolic) Acid , 1998 .

[19]  K. Griebenow,et al.  Effect of excipients on the stability and structure of lyophilized recombinant human growth hormone. , 1998, Journal of pharmaceutical sciences.

[20]  J. Cleland,et al.  A Large-Scale Process to Produce Microencapsulated Proteins , 1998, Pharmaceutical Research.

[21]  Keith Masters,et al.  Spray drying handbook , 1979 .

[22]  R. Langer,et al.  Heterogeneity of serum albumin samples with respect to solid-state aggregation via thiol-disulfide interchange : Implications for sustained release from polymers , 1997 .

[23]  H Willemer,et al.  Measurements of temperatures, ice evaporation rates and residual moisture contents in freeze-drying. , 1992, Developments in biological standardization.

[24]  A. Klibanov,et al.  Fourier-transform infrared spectroscopic investigation of protein stability in the lyophilized form. , 1995, Biochimica et biophysica acta.

[25]  Alexander M. Klibanov,et al.  On Protein Denaturation in Aqueous−Organic Mixtures but Not in Pure Organic Solvents , 1996 .

[26]  B. Chang,et al.  Surface-induced denaturation of proteins during freezing and its inhibition by surfactants. , 1996, Journal of pharmaceutical sciences.

[27]  A. Klibanov,et al.  FTIR characterization of the secondary structure of proteins encapsulated within PLGA microspheres. , 1999, Journal of controlled release : official journal of the Controlled Release Society.

[28]  S J Prestrelski,et al.  Separation of freezing- and drying-induced denaturation of lyophilized proteins using stress-specific stabilization. I. Enzyme activity and calorimetric studies. , 1993, Archives of biochemistry and biophysics.