Impact of X-Ray Exposure on a Triple-Level-Cell NAND Flash

The total ionizing dose response of a triple-level-cell (TLC) NAND flash is shown to be low enough that data corruption can occur as a result of an x-ray inspection. Only a few seconds of x-ray exposure corresponding to a total dose of merely 50 rad(Si) in a real-time x-ray source are required to induce errors. An in-depth total dose analysis shows which pages of the memory and data patterns are the most susceptible to radiation. The results show that TLC NAND flash devices are not suitable for use in high radiation environments, and that care must be taken when exposing them to even small x-ray exposures like those present in a circuit board inspection.

[1]  Alessandro Paccagnella,et al.  Radiation induced leakage current and stress induced leakage current in ultra-thin gate oxides , 1998 .

[2]  A. Paccagnella,et al.  Effects of Total Ionizing Dose on the Retention of 41-nm NAND Flash Cells , 2011, IEEE Transactions on Nuclear Science.

[3]  Sean Eilert,et al.  Evaluation of x-ray irradiation on 65nm Multi-Level Cell NOR flash technologies , 2010, 2010 IEEE International Integrated Reliability Workshop Final Report.

[4]  Alessandro Paccagnella,et al.  Ionizing radiation induced leakage current on ultra-thin gate oxides , 1997 .

[5]  T. R. Oldham,et al.  Comparison of 60Co Response and 10 KeV X-Ray Response in MOS Capacitors , 1983, IEEE Transactions on Nuclear Science.

[6]  Andrea L. Lacaita,et al.  A statistical model for SILC in flash memories , 2002 .

[7]  T. A. Dellin,et al.  Radiation response of floating gate EEPROM memory cells , 1989 .

[8]  Gabriella Ghidini,et al.  A model of radiation induced leakage current (RILC) in ultra-thin gate oxides , 1999 .

[9]  A. Paccagnella,et al.  A study on the short- and long-term effects of X-ray exposure on NAND Flash memories , 2011, IEEE International Reliability Physics Symposium.

[10]  R. Harboe-Sorensen,et al.  Evaluation of Mechanisms in TID Degradation and SEE Susceptibility of Single- and Multi-Level High Density NAND Flash Memories , 2011, IEEE Transactions on Nuclear Science.

[11]  Paul H. Siegel,et al.  Characterization and error-correcting codes for TLC flash memories , 2012, 2012 International Conference on Computing, Networking and Communications (ICNC).

[12]  A. Candelori,et al.  Effect of different total ionizing dose sources on charge loss from programmed floating gate cells , 2005, IEEE Transactions on Nuclear Science.

[13]  M. Ma,et al.  X-Ray Inspection-Induced Latent Damage in DRAM , 2006, 2006 IEEE International Reliability Physics Symposium Proceedings.

[14]  R. Blish,et al.  Filter optimization for X-ray inspection of surface-mounted ICs , 2002 .

[15]  H. E. Boesch,et al.  Reversibility of trapped hole annealing , 1988 .

[16]  B. Cho,et al.  Radiation-induced leakage current of ultra-thin gate oxide under X-ray lithography conditions , 1999, Proceedings of the 1999 7th International Symposium on the Physical and Failure Analysis of Integrated Circuits (Cat. No.99TH8394).