Biohydrogen Production in Continuous‐Flow Reactor Using Mixed Microbial Culture

The goal of the proposed project was to develop an anaerobic fermentation process that converts negative-value organic wastes into hydrogen-rich gas in a continuous-flow reactor under different operating conditions, such as hydraulic retention time (HRT), heat treatment, pH, and substrates. A series of batch tests were also conducted in parallel to the continuous study to evaluate the hydrogen conversion efficiency of two different organic substrates, namely sucrose and starch. A heat shock (at 90 degrees C for 15 minutes) was applied to the sludge in an external heating chamber known as a sludge activation chamber, as a method to impose a selection pressure to eliminate non-spore-forming, hydrogen-consuming bacteria and to activate spore germination. The experimental results showed that the heat activation of biomass enhanced hydrogen production by selecting for hydrogen-producing, spore-forming bacteria. The batch feeding at a shorter HRT of 20 hours (or higher organic loading rate) favored hydrogen production, whereas, at a longer HRT of 30 hours, methane was detected in the gas phase. The major organic acids of hydrogen fermentation were acetate, butyrate, and propionate. Up to 23.1% of influent chemical oxygen demand was consumed in biomass synthesis. Batch tests showed that the hydrogen-production potential of starch was lower than sucrose, and better conversion efficiency from starch was obtained at a lower pH of 4.5. However, addition of sucrose to starch improved the overall hydrogen-production potential and hydrogen-production rate. This study showed that sustainable biohydrogen production from carbohydrate-rich substrates is possible through heat activation of settled sludge.

[1]  P. Mccarty,et al.  Environmental Biotechnology: Principles and Applications , 2000 .

[2]  Richard Sparling,et al.  Hydrogen production from inhibited anaerobic composters , 1997 .

[3]  R. Labbé,et al.  Sporulation-promoting ability of Clostridium perfringens culture fluids , 1996, Applied and environmental microbiology.

[4]  Osamu Mizuno,et al.  HYDROGEN PRODUCTION FROM FOOD PROCESSING WASTE BY ANAEROBIC BACTERIA , 1997 .

[5]  H. A. Barker,et al.  Amino acid fermentations by Clostridium propionicum and Diplococcus glycinophilus. , 1947, Archives of biochemistry.

[6]  Gatze Lettinga,et al.  Anaerobic Sewage Treatment: A Practical Guide for Regions with a Hot Climate , 1995 .

[7]  Samir Kumar Khanal,et al.  Biological hydrogen production: effects of pH and intermediate products , 2003 .

[8]  Y. Ueno,et al.  Hydrogen Production from Industrial Wastewater by Anaerobic Microflora in Chemostat Culture , 1996 .

[9]  Importance of hydrogen metabolism in regulation of solventogenesis by Clostridium acetobutylicum , 1984 .

[10]  F. Smith,et al.  Colorimetric Method for Determination of Sugars and Related Substances , 1956 .

[11]  J. Lay,et al.  Biohydrogen production as a function of pH and substrate concentration. , 2001, Environmental science & technology.

[12]  Tatsushi Kawai,et al.  Biological production of hydrogen from cellulose by natural anaerobic microflora , 1995 .

[13]  P. Mccarty,et al.  Bioassay for monitoring biochemical methane potential and anaerobic toxicity , 1979 .

[14]  V C Kalia,et al.  Frementation of biowaste to H2 by Bacillus licheniformis , 1994, World journal of microbiology & biotechnology.

[15]  Sang-Eun Oh,et al.  Biological hydrogen production measured in batch anaerobic respirometers. , 2002, Environmental science & technology.

[16]  T. Noike,et al.  Hydrogen fermentation of organic municipal wastes , 2000 .

[17]  H. H. Fang,et al.  Hydrogen production from wastewater by acidogenic granular sludge. , 2003, Water science and technology : a journal of the International Association on Water Pollution Research.

[18]  J. Lay,et al.  Modeling and optimization of anaerobic digested sludge converting starch to hydrogen , 2000, Biotechnology and bioengineering.

[19]  M. Levandowsky,et al.  Production of hydrogen by microbial fermentation , 1988 .

[20]  I Karube,et al.  Continuous hydrogen production by immobilized whole cells of Clostridium butyricum. , 1976, Biochimica et biophysica acta.

[21]  J. Brosseau,et al.  Hydrogen-gas production with Citrobacter intermedim and Clostridium pasteurianum , 2007 .

[22]  J. Lay,et al.  Mathematical Model for Methane Production from Landfill Bioreactor , 1998 .

[23]  Akashah Majizat,et al.  Hydrogen gas production from glucose and its microbial kinetics in anaerobic systems , 1997 .

[24]  Henri Petitdemange,et al.  Inhibitor effect of products of metabolism on growth of Clostridium acetobutylicum , 2004, Applied Microbiology and Biotechnology.

[25]  Patrick C. Hallenbeck,et al.  Biological hydrogen production; fundamentals and limiting processes , 2002 .

[26]  J. Linden,et al.  Agitation and pressure effects on acetone‐butanol fermentation , 1985, Biotechnology and bioengineering.

[27]  C. H. Werkman.  Bacterial Metabolism (2nd ed.) , 1940 .

[28]  David T. Jones,et al.  Initiation of solvent production, clostridial stage and endospore formation in Clostridium acetobutylicum P262 , 1984, Applied Microbiology and Biotechnology.

[29]  J. Lay,et al.  Feasibility of biological hydrogen production from organic fraction of municipal solid waste , 1999 .