Electrophoretic deposition of reduced graphene-carbon nanotubes composite films as counter electrodes of dye-sensitized solar cells

Reduced graphene (RG)-carbon nanotubes (CNTs) composite films are successfully fabricated by electrophoretic deposition and used as counter electrodes of dye-sensitized solar cells. RG is obtained by microwave-assisted reduction of graphite oxide dispersion in aqueous solution using a microwave synthesis system. By the optimization of CNTs content, photovoltaic conversion efficiency of the cell with RG-CNTs counter electrode reaches a maximum of 6.17% at one sun (AM 1.5 G, 100 mW cm−2) which is comparable to the cell with conventional Pt counter electrode. The results suggest that the RG-CNTs composite films provide a potential feasibility for replacing conventional Pt counter electrodes for DSSCs.

[1]  Yang Yang,et al.  Low-temperature solution processing of graphene-carbon nanotube hybrid materials for high-performance transparent conductors. , 2009, Nano letters.

[2]  S. Rhee,et al.  Sub-micrometer-sized graphite as a conducting and catalytic counter electrode for dye-sensitized solar cells. , 2011, ACS applied materials & interfaces.

[3]  Chunzhong Li,et al.  Interfacial confined formation of mesoporous spherical TiO2 nanostructures with improved photoelectric conversion efficiency. , 2010, Inorganic chemistry.

[4]  Jaesung Song,et al.  Efficient dye-sensitized solar cells with catalytic multiwall carbon nanotube counter electrodes. , 2009, ACS applied materials & interfaces.

[5]  M. Ozkan,et al.  Synthesis of a pillared graphene nanostructure: a counterpart of three-dimensional carbon architectures. , 2010, Small.

[6]  Christian Punckt,et al.  Functionalized graphene as a catalytic counter electrode in dye-sensitized solar cells. , 2010, ACS nano.

[7]  Ladislav Kavan,et al.  Optically transparent cathode for dye-sensitized solar cells based on graphene nanoplatelets. , 2011, ACS nano.

[8]  Juan Bisquert,et al.  Simulation of Steady-State Characteristics of Dye- Sensitized Solar Cells and the Interpretation of the Diffusion Length , 2010 .

[9]  Yanhong Luo,et al.  Low temperature fabrication of efficient porous carbon counter electrode for dye-sensitized solar cells , 2009 .

[10]  Dae-Sik Lee,et al.  Flexible room-temperature NO2 gas sensors based on carbon nanotubes/reduced graphene hybrid films , 2010 .

[11]  M. Grätzel,et al.  CoS supersedes Pt as efficient electrocatalyst for triiodide reduction in dye-sensitized solar cells. , 2009, Journal of the American Chemical Society.

[12]  Dongmin Chen,et al.  Synthesis and Solid-State NMR Structural Characterization of 13C-Labeled Graphite Oxide , 2008, Science.

[13]  Jiang Sheng,et al.  A facile synthesis of anatase N,B codoped TiO2 anodes for improved-performance dye-sensitized solar cells , 2011 .

[14]  C. Hsieh,et al.  One- and two-dimensional carbon nanomaterials as counter electrodes for dye-sensitized solar cells , 2011 .

[15]  W. Que,et al.  Optimization of field emission properties of carbon nanotubes cathodes by electrophoretic deposition , 2007 .

[16]  D. Y. Kim,et al.  Water-soluble polyelectrolyte-grafted multiwalled carbon nanotube thin films for efficient counter electrode of dye-sensitized solar cells. , 2010, ACS nano.

[17]  Yongsheng Chen,et al.  SUPERCAPACITOR DEVICES BASED ON GRAPHENE MATERIALS , 2009 .

[18]  Efficient organic dye sensitized solar cells based on modified sulfide/polysulfide electrolyte , 2011 .

[19]  J. Bisquert,et al.  Triplication of the photocurrent in dye solar cells by increasing the elongation of the π-conjugation in Zn-porphyrin sensitizers. , 2011, Chemphyschem : a European journal of chemical physics and physical chemistry.

[20]  Yanhong Luo,et al.  A flexible carbon counter electrode for dye-sensitized solar cells , 2009 .

[21]  Chang Ming Li,et al.  Layered graphene/quantum dots for photovoltaic devices. , 2010, Angewandte Chemie.

[22]  Jin Zhai,et al.  Two-dimensional graphene bridges enhanced photoinduced charge transport in dye-sensitized solar cells. , 2010, ACS nano.

[23]  Hui Wang,et al.  Thinnest two-dimensional nanomaterial-graphene for solar energy. , 2010, ChemSusChem.

[24]  S. Kim,et al.  Flexible field emission of nitrogen-doped carbon nanotubes/reduced graphene hybrid films. , 2011, Small.

[25]  F. Fabregat‐Santiago,et al.  Electron Lifetime in Dye-Sensitized Solar Cells: Theory and Interpretation of Measurements , 2009 .

[26]  Chenxi Xu,et al.  Highly Conductive Carbon‐Nanotube/Graphite‐Oxide Hybrid Films , 2008 .

[27]  R. Ruoff,et al.  Graphene-based ultracapacitors. , 2008, Nano letters.

[28]  Yanglong Hou,et al.  Aqueous dispersions of TCNQ-anion-stabilized graphene sheets. , 2008, Chemical communications.

[29]  Bing Yang,et al.  Room-temperature fabrication of graphene films on variable substrates and its use as counter electrodes for dye-sensitized solar cells , 2011 .

[30]  Lifeng Zhang,et al.  Electrospun carbon nanofibers as low-cost counter electrode for dye-sensitized solar cells. , 2010, ACS applied materials & interfaces.

[31]  P. Thordarson,et al.  Gram-scale production of graphene based on solvothermal synthesis and sonication. , 2009, Nature nanotechnology.

[32]  Yanhong Luo,et al.  Application of a new cyclic guanidinium ionic liquid on dye-sensitized solar cells (DSCs). , 2009, Langmuir : the ACS journal of surfaces and colloids.

[33]  C. Hsieh,et al.  Influence of oxidation level on capacitance of electrochemical capacitors fabricated with carbon nanotube/carbon paper composites , 2010 .

[34]  Hyonkwang Choi,et al.  Electrochemical electrodes of graphene-based carbon nanotubes grown by chemical vapor deposition , 2011 .

[35]  K. Ho,et al.  A high performance dye-sensitized solar cell with a novel nanocomposite film of PtNP/MWCNT on the counter electrode , 2010 .

[36]  W. Choi,et al.  Dye-sensitized solar cells using graphene-based carbon nano composite as counter electrode , 2011 .

[37]  Gordon G Wallace,et al.  Dispersing carbon nanotubes with graphene oxide in water and synergistic effects between graphene derivatives. , 2010, Chemistry.

[38]  Heeyeop Chae,et al.  A graphene sheet exfoliated with microwave irradiation and interlinked by carbon nanotubes for high-performance transparent flexible electrodes , 2010, Nanotechnology.

[39]  Qiang Zhang,et al.  A Three‐Dimensional Carbon Nanotube/Graphene Sandwich and Its Application as Electrode in Supercapacitors , 2010, Advanced materials.

[40]  T. Xu,et al.  Graphene-incorporated nanocrystalline TiO2 films for CdS quantum dot-sensitized solar cells , 2011 .

[41]  Fuzhi Huang,et al.  Dye-sensitized solar cells employing a single film of mesoporous TiO2 beads achieve power conversion efficiencies over 10%. , 2010, ACS nano.

[42]  Wen-Yueh Yu,et al.  Transparent electrodes of ordered opened-end TiO2-nanotube arrays for highly efficient dye-sensitized solar cells , 2010 .

[43]  L. Gao,et al.  Optimization of the cutting process of multi-wall carbon nanotubes for enhanced dye-sensitized solar cells , 2011 .

[44]  Liquan Chen,et al.  Room temperature fabrication of porous ZnO photoelectrodes for flexible dye-sensitized solar cells. , 2007, Chemical communications.

[45]  Juan Bisquert,et al.  Breakthroughs in the Development of Semiconductor-Sensitized Solar Cells , 2010 .

[46]  A. Govindaraj,et al.  Graphene-based electrochemical supercapacitors , 2008 .

[47]  Byeong-Su Kim,et al.  Transparent, flexible conducting hybrid multilayer thin films of multiwalled carbon nanotubes with graphene nanosheets. , 2010, ACS nano.

[48]  Jing Sun,et al.  Assembly of CdSe nanoparticles on graphene for low-temperature fabrication of quantum dot sensitized solar cell , 2011 .

[49]  Jihuai Wu,et al.  High-performance and low platinum loading Pt/Carbon black counter electrode for dye-sensitized solar cells , 2009 .

[50]  B. Koo,et al.  Pt-free transparent counter electrodes for dye-sensitized solar cells prepared from carbon nanotube micro-balls , 2010 .

[51]  Hongwei Zhu,et al.  Graphene Nano-“patches” on a Carbon Nanotube Network for Highly Transparent/Conductive Thin Film Applications , 2010 .

[52]  An M. Prenen,et al.  Monodisperse, polymeric nano- and microsieves produced with interference holography , 2009 .

[53]  G. Wallace,et al.  Processable aqueous dispersions of graphene nanosheets. , 2008, Nature nanotechnology.

[54]  Z. Xiong,et al.  Pillaring chemically exfoliated graphene oxide with carbon nanotubes for photocatalytic degradation of dyes under visible light irradiation. , 2010, ACS nano.

[55]  Zhuo Sun,et al.  Electrosorption behavior of graphene in NaCl solutions , 2009 .

[56]  Hongxia Wang,et al.  Solid-state composite electrolyte LiI/3-hydroxypropionitrile/SiO2 for dye-sensitized solar cells. , 2005, Journal of the American Chemical Society.

[57]  Andre K. Geim,et al.  Electric Field Effect in Atomically Thin Carbon Films , 2004, Science.

[58]  R. Ruoff,et al.  Versatile Carbon Hybrid Films Composed of Vertical Carbon Nanotubes Grown on Mechanically Compliant Graphene Films , 2010, Advanced materials.

[59]  N. Park,et al.  Effect of surface modification of multi-walled carbon nanotubes on the fabrication and performance of carbon nanotube based counter electrodes for dye-sensitized solar cells , 2010 .

[60]  E. Barea,et al.  Near-IR sensitization of wide band gap oxide semiconductor by axially anchored Si-naphthalocyanines , 2009 .

[61]  J. Kenny,et al.  Electrodeposition of transparent and conducting graphene/carbon nanotube thin films , 2010 .

[62]  K. Moon,et al.  Ultrafast, dry microwave synthesis of graphene sheets , 2010 .

[63]  V. Amornkitbamrung,et al.  Influences of magnesium particles incorporated on electrophoretically multiwall carbon nanotube film on dye-sensitized solar cell performance , 2009 .

[64]  U. Jansson,et al.  Stirring-induced aggregation of graphene in suspension , 2011 .

[65]  C. Hsieh,et al.  Water/oil repellency and drop sliding behavior on carbon nanotubes/carbon paper composite surfaces , 2010 .

[66]  C. Hsieh,et al.  Fabrication and superhydrophobicity of fluorinated carbon fabrics with micro/nanoscaled two-tier roughness , 2008 .

[67]  R. Ruoff,et al.  The chemistry of graphene oxide. , 2010, Chemical Society reviews.

[68]  Klaus Müllen,et al.  Towards free-standing graphene/carbon nanotube composite films via acetylene-assisted thermolysis of organocobalt functionalized graphene sheets. , 2010, Chemical communications.

[69]  Chunzhong Li,et al.  Planar scattering from hierarchical anatase TiO2 nanoplates with variable shells to improve light harvesting in dye-sensitized solar cells. , 2011, Chemical communications.

[70]  M. Grätzel.  Photoelectrochemical cells : Materials for clean energy , 2001 .

[71]  Zhuo Sun,et al.  Electrochemical behaviors of graphene–ZnO and graphene–SnO2 composite films for supercapacitors , 2010 .

[72]  Guozhong Cao,et al.  Hierarchically structured photoelectrodes for dye-sensitized solar cells , 2011 .

[73]  Wenjing Hong,et al.  Transparent graphene/PEDOT–PSS composite films as counter electrodes of dye-sensitized solar cells , 2008 .

[74]  Yanhong Luo,et al.  In Situ Preparation of a Flexible Polyaniline/Carbon Composite Counter Electrode and Its Application in Dye-Sensitized Solar Cells , 2010 .

[75]  Dingshan Yu,et al.  Self-Assembled Graphene/Carbon Nanotube Hybrid Films for Supercapacitors , 2010 .

[76]  Hyonkwang Choi,et al.  Graphene counter electrodes for dye-sensitized solar cells prepared by electrophoretic deposition , 2011 .

[77]  Jaesung Song,et al.  Performance variation of carbon counter electrode based dye-sensitized solar cell , 2008 .

[78]  Lifeng Yan,et al.  Preparation of graphene by the rapid and mild thermal reduction of graphene oxide induced by microwaves , 2010 .