Modeling and numerical simulation of secondary settlers: a method of lines strategy.

In this paper, attention is focused on a parabolic partial differential equation (PDE) modeling sedimentation in a secondary settler and the proper formulation of the problem boundary conditions (i.e., the conditions prevailing at the feed, clear water and sludge outlets). The presence of a diffusion term in the equation not only allows the reproduction of experimental observations, as reported in a number of works, but also makes the numerical solution of the initial-boundary value problem significantly easier than the original conservation law (which is a nonlinear hyperbolic PDE problem requiring advanced numerical techniques). A Method of Lines (MOL) solution strategy is then proposed, based on the use of finite differences or spectral methods, and on readily available time integrators. The efficiency and flexibility of the general procedure are demonstrated with various numerical simulation results.

[1]  Sylvie Gillot,et al.  The COST Simulation Benchmark: Description and Simulator Manual , 2001 .

[2]  Z. Vitasovic,et al.  AN INTEGRATED CONTROL STRATEGY FOR THE ACTIVATED SLUDGE PROCESS , 1986 .

[3]  Raimund Bürger,et al.  Numerical methods for the simulation of continuous sedimentation in ideal clarifier-thickener units , 2004 .

[4]  Stefan Diehl,et al.  On boundary conditions and solutions for ideal clarifier–thickener units , 2000 .

[5]  G. J. Kynch.  A theory of sedimentation , 1952 .

[6]  Peter A. Vanrolleghem,et al.  Analysis and simulation of the sludge profile dynamics in a full-scale clarifier , 2005 .

[7]  Stefan Diehl,et al.  A conservation Law with Point Source and Discontinuous Flux Function Modelling Continuous Sedimentation , 1996, SIAM J. Appl. Math..

[8]  L. Trefethen.  Spectral Methods in MATLAB , 2000 .

[9]  I. Takács.  A dynamic model of the clarification-thickening process , 1991 .

[10]  Jan Van Impe,et al.  SIMULATION ANALYSIS OF A ONE-DIMENSIONAL SEDIMENTATION MODEL , 2002 .

[11]  W. Schiesser.  The Numerical Method of Lines: Integration of Partial Differential Equations , 1991 .

[12]  David A. Vaccari,et al.  Calibration of a compressive gravity thickening model from a single batch settling curve , 1994 .

[13]  Ulf Jeppsson,et al.  Modelling Aspects of Wastewater Treatment Processes , 1996 .

[14]  Raimund Bürger,et al.  Mathematical model and numerical simulation of the dynamics of flocculated suspensions in clarifier–thickeners , 2005 .

[15]  R. Bürger,et al.  A Century of Research in Sedimentation and Thickening , 2002 .

[16]  A. Wouwer,et al.  Adaptive Method of Lines , 2001 .

[17]  C. Petty,et al.  Continuous sedimentation of a suspension with a nonconvex flux law , 1975 .

[18]  Ulf Jeppsson,et al.  An evaluation of a dynamic model of the secondary clarifier , 1996 .

[19]  L. Härtel,et al.  A Dynamic Secondary Clarifier Model including Processes of Sludge Thickening , 1992 .

[20]  I Queinnec,et al.  Modelling and simulation of the steady-state of secondary settlers in wastewater treatment plants. , 2001, Water science and technology : a journal of the International Association on Water Pollution Research.

[21]  Ulf Jeppsson,et al.  A model of the settler coupled to the biological reactor , 1998 .

[22]  R. Otterpohl,et al.  Dynamic Models for Clarifiers of Activated Sludge Plants with Dry and Wet Weather Flows , 1992 .

[23]  S. Svoronos,et al.  One-dimensional modeling of secondary clarifiers using a concentration and feed velocity-dependent dispersion coefficient , 1996 .

[24]  Ingmar Nopens,et al.  Detailed spatio-temporal solids concentration profiling during batch settling of activated sludge using a radiotracer. , 2005, Water research.

[25]  Gerasimos Lyberatos,et al.  Modeling and Pilot-Scale Experimental Verification for Predenitrification Process , 1992 .

[26]  I Takács,et al.  Hindered and compression settling: parameter measurement and modelling. , 2007, Water science and technology : a journal of the International Association on Water Pollution Research.

[27]  Ingmar Nopens,et al.  Extending and calibrating a mechanistic hindered and compression settling model for activated sludge using in-depth batch experiments. , 2008, Water research.