Correlation Between Epitaxial Layer Quality and Drain Current Stability of GaN/AlGaN/GaN Heterostructure Field-Effect Transistors

Stability of current-voltage characteristics was investigated for GaN/AlGaN/GaN heterostructure field-effect transistors, which were fabricated using epiwafers with different yellow luminescence (YL)-to-band edge (BE) ratios in photoluminescence spectrum and full-width at half-maximum (FWHM) values of X-ray rocking curves. After application of a long-term high-voltage OFF-state stress, they exhibited a temporary reduction of drain current (Id) accompanied by a positive threshold voltage shift with a long recovery time (>1 h at room temperature). To study the mechanism of this instability, transient of Id just after removing the stress was measured under the subthreshold condition for different ambient temperatures (-20 °C to 200 °C). An isothermal capacitance transient spectroscopy-like analysis applied to the transient signal indicated that electron traps with an activation energy of 0.3-0.5 eV and a density of the order of 1011 cm-2 are responsible for this phenomenon. The emission rate of these electron traps increased when the YL/BE ratio was reduced, while the trap density decreased when the FWHM values were reduced. These results suggest that the long-term Id transient can be minimized by reducing both of these parameters.

[1]  M. Meneghini,et al.  Deep-Level Characterization in GaN HEMTs-Part I: Advantages and Limitations of Drain Current Transient Measurements , 2013, IEEE Transactions on Electron Devices.

[2]  A. Vescan,et al.  Investigation of trapping effects in AlGaN/GaN/Si field-effect transistors by frequency dependent capacitance and conductance analysis , 2008 .

[3]  H. Miyamoto,et al.  A normally-off GaN FET with high threshold voltage uniformity using a novel piezo neutralization technique , 2009, 2009 IEEE International Electron Devices Meeting (IEDM).

[4]  Olson,et al.  Optically detected magnetic resonance of GaN films grown by organometallic chemical-vapor deposition. , 1995, Physical review. B, Condensed matter.

[5]  Jungwoo Joh,et al.  A Current-Transient Methodology for Trap Analysis for GaN High Electron Mobility Transistors , 2011, IEEE Transactions on Electron Devices.

[6]  D. Look,et al.  Effects of electron-irradiation on electrical properties of AlGaN/GaN Schottky barrier diodes , 2009 .

[7]  Yuji Ando,et al.  Impact of Epi-Layer Quality on Reliability of GaN/AlGaN/GaN Heterostructure Field-Effect Transistors on Si Substrate , 2013, IEEE Transactions on Electron Devices.

[8]  Gaudenzio Meneghesso,et al.  Evaluation of GaN HEMT degradation by means of pulsed I-V, leakage and DLTS measurements , 2009 .

[9]  Tamotsu Hashizume,et al.  Effects of interface states and temperature on the C-V behavior of metal/ insulator/AlGaN/GaN heterostructure capacitors , 2008 .

[10]  Sven Öberg,et al.  DEEP ACCEPTORS TRAPPED AT THREADING-EDGE DISLOCATIONS IN GAN , 1998 .

[11]  Hideki Hasegawa,et al.  Mechanisms of current collapse and gate leakage currents in AlGaN/GaN heterostructure field effect transistors , 2003 .

[12]  Kovalev,et al.  Properties of the yellow luminescence in undoped GaN epitaxial layers. , 1995, Physical review. B, Condensed matter.

[13]  Umesh K. Mishra,et al.  Importance of impurity diffusion for early stage degradation in AlGaN/GaN high electron mobility transistors upon electrical stress , 2010 .

[14]  T. Kachi,et al.  Characterization of plasma etching damage on p-type GaN using Schottky diodes , 2008 .

[15]  Gijs Bosman,et al.  Device reliability study of high gate electric field effects in AlGaN/GaN high electron mobility transistors using low frequency noise spectroscopy , 2010 .

[16]  Peter Kordos,et al.  Investigation of buffer traps in an AlGaN/GaN/Si high electron mobility transistor by backgating current deep level transient spectroscopy , 2003 .

[17]  Steven A. Ringel,et al.  Impact of deep levels on the electrical conductivity and luminescence of gallium nitride codoped with carbon and silicon , 2005 .

[18]  Anderson Janotti,et al.  Carbon impurities and the yellow luminescence in GaN , 2010 .

[19]  Gaudenzio Meneghesso,et al.  RF degradation of GaN HEMTs and its correlation with DC stress and I-DLTS measurements , 2009, 2009 European Microwave Integrated Circuits Conference (EuMIC).

[20]  Alan Francis Wright,et al.  Substitutional and interstitial oxygen in wurtzite GaN , 2002 .

[21]  Jaime A. Freitas,et al.  On the origin of electrically active defects in AlGaN alloys grown by organometallic vapor phase epitaxy , 1996 .

[22]  Umesh K. Mishra,et al.  GaN-Based RF Power Devices and Amplifiers , 2008, Proceedings of the IEEE.

[23]  T. Detzel,et al.  Influence of Buffer Carbon Doping on Pulse and AC Behavior of Insulated-Gate Field-Plated Power AlGaN/GaN HEMTs , 2014, IEEE Electron Device Letters.

[24]  Y. Okamoto,et al.  10-W/mm AlGaN-GaN HFET with a field modulating plate , 2003, IEEE Electron Device Letters.

[25]  H. Cho,et al.  Electron capture behaviors of deep level traps in unintentionally doped and intentionally doped n-type GaN , 2003 .

[26]  S. Blight,et al.  Surface influence on the conductance DLTS spectra of GaAs MESFET's , 1986, IEEE Transactions on Electron Devices.

[27]  T. Kachi,et al.  Current deep-level transient spectroscopy investigation of acceptor levels in Mg-doped GaN , 2001 .

[28]  Alan Francis Wright,et al.  Role of carbon in GaN , 2002 .

[29]  Steven A. Ringel,et al.  Direct comparison of traps in InAlN/GaN and AlGaN/GaN high electron mobility transistors using constant drain current deep level transient spectroscopy , 2013 .

[30]  Masashi Mizuta,et al.  Characteristics of Fielo-GaN Grown by Hydride Vapor Phase Epitaxy , 2000 .

[31]  D. Lang.  Deep‐level transient spectroscopy: A new method to characterize traps in semiconductors , 1974 .

[32]  S. Delage,et al.  Evidence of traps creation in GaN/AlGaN/GaN HEMTs after a 3000 hour on-state and off-state hot-electron stress , 2005, IEEE InternationalElectron Devices Meeting, 2005. IEDM Technical Digest..

[33]  D. Chi,et al.  Identification of deep levels in GaN associated with dislocations , 2004 .

[34]  C. Gaquière,et al.  Anomaly and defects characterization by I-V and current deep level transient spectroscopy of Al0.25Ga0.75N/GaN/SiC high electron-mobility transistors , 2012 .

[35]  Yutaka Ohno,et al.  Drain Current DLTS of AlGaN/GaN MIS-HEMTs , 2003 .

[36]  T. Jimbo,et al.  Electrical characterization of acceptor levels in Mg-doped GaN , 2002 .

[37]  Lester F. Eastman,et al.  Slow transients observed in AlGaN/GaN HFETs: effects of SiN/sub x/ passivation and UV illumination , 2003 .

[38]  G. Verzellesi,et al.  Reliability of GaN High-Electron-Mobility Transistors: State of the Art and Perspectives , 2008, IEEE Transactions on Device and Materials Reliability.

[39]  Piotr Perlin,et al.  Mechanism of yellow luminescence in GaN , 1995 .

[40]  K. Matsunaga,et al.  Novel AlGaN/GaN dual-field-plate FET with high gain, increased linearity and stability , 2005, IEEE InternationalElectron Devices Meeting, 2005. IEDM Technical Digest..

[41]  S. Yamasaki,et al.  Determination of the Density of State Distribution of a-Si:H by Isothermal Capacitance Transient Spectroscopy , 1981 .

[42]  Y. Hao,et al.  Trap states in InAlN/AlN/GaN-based double-channel high electron mobility transistors , 2013 .