Direct Observation of the Relationship between Thixotropic Behavior and Shear-Induced Orientation of Clay Particles in Synesthetic Hectorite Suspensions.

A thixotropic characteristics of aqueous gels containing smectite clay minerals were used in various industrial applications such as paint additives, which have been affected by the clay types and clay particle sizes. A model called a house-of-card arrangement of clay particles and anisotropic arrangement in aqueous gels has been proposed. We prepared different sizes of synthetic hectorite and studied them by scanning electron-assisted dielectric microscopy (SE-ADM) and simultaneous small-angle neutron scattering and rheological measurements (Rheo-SANS). The Rheo-SANS results indicated that the clay particles with the cross-sectional radius of 30 nm were clearly oriented in the direction of shear-flow (1 × 103 s-1) direction, but the anisotropic change was not observed for an aqueous gel with clays whose average radius was 19.5 nm. The present study suggested the thixotropic characteristics of aqueous gels depend on the hectorite particle size and aggregation structure under shear conditions.

[1]  W. Yu,et al.  Insights into rheological behavior of aqueous dispersions of synthetic saponite: effects of saponite composition and sodium polyacrylate. , 2019, Langmuir : the ACS journal of surfaces and colloids.

[2]  Hao Zhang,et al.  Hectorite: Synthesis, modification, assembly and applications , 2019, Applied Clay Science.

[3]  M. Shibayama,et al.  Rheo-SANS study on relationship between micellar structures and rheological behavior of cationic gemini surfactants in solution. , 2019, Journal of colloid and interface science.

[4]  K. Tamura,et al.  Structural investigation of hectorite aqueous suspensions by dielectric microscopy and small-angle neutron scattering coupling with rheological measurement , 2018, Applied Clay Science.

[5]  H. Frielinghaus,et al.  Tunable viscosity modification with diluted particles: when particles decrease the viscosity of complex fluids , 2017, Colloid and Polymer Science.

[6]  Y. M. Joshi,et al.  Phase Behavior of Aqueous Suspension of Laponite: New Insights with Microscopic Evidence. , 2017, Langmuir : the ACS journal of surfaces and colloids.

[7]  Dimitrios I. Gerogiorgis,et al.  Effect of temperature on the rheological properties of neat aqueous Wyoming sodium bentonite dispersions , 2017 .

[8]  L. Kong,et al.  Thixotropic mechanism of clay: A microstructural investigation , 2017 .

[9]  J. Hedlund,et al.  The structure of montmorillonite gels revealed by sequential cryo-XHR-SEM imaging. , 2016, Journal of colloid and interface science.

[10]  T. Ogura.  Nanoscale analysis of unstained biological specimens in water without radiation damage using high-resolution frequency transmission electric-field system based on FE-SEM. , 2015, Biochemical and biophysical research communications.

[11]  T. Ogura.  Direct Observation of Unstained Biological Specimens in Water by the Frequency Transmission Electric-Field Method Using SEM , 2014, PloS one.

[12]  E. Zaccarelli,et al.  A fresh look at the Laponite phase diagram , 2011 .

[13]  U. Olsson,et al.  Ordering fluctuations in a shear-banding wormlike micellar system. , 2010, Physical chemistry chemical physics : PCCP.

[14]  P. Levitz,et al.  Phase diagrams of Wyoming Na-montmorillonite clay. Influence of particle anisotropy. , 2004, Langmuir : the ACS journal of surfaces and colloids.

[15]  V. Aswal,et al.  Small angle neutron scattering and viscosity studies of micellar solutions of bis-cationic surfactants containing hydroxyethyl methyl quaternary ammonium head groups , 2004 .

[16]  P. Panine,et al.  The measurement by SAXS of the nematic order parameter of laponite gels , 2002 .

[17]  P. Levitz,et al.  Liquid-solid transition of Laponite suspensions at very low ionic strength: Long-range electrostatic stabilisation of anisotropic colloids , 2000 .

[18]  J. W. Goodwin,et al.  A Small-Angle X-ray Scattering Study of the Structure of Aqueous Laponite Dispersions , 1999 .

[19]  H. Hanley,et al.  A Small Angle Neutron Scattering Study of a Clay Suspension under Shear , 1994 .

[20]  T. Pinnavaia,et al.  Characterisation of pillared clays by neutron scattering , 1984 .

[21]  Sow-Hsin Chen,et al.  Analysis of small angle neutron scattering spectra from polydisperse interacting colloids , 1983 .

[22]  H. Olphen.  Internal mutual flocculation in clay suspensions. , 1964 .

[23]  P. Lindner,et al.  Small-angle neutron scattering investigations of the structure of thixotropic dispersions of smectite clay colloids , 1993 .

[24]  J. Ramsay,et al.  Swelling and dispersion of smectite clay colloids: determination of structure by neutron diffraction and small-angle neutron scattering , 1990 .

[25]  R. Thomas,et al.  Small angle neutron scattering from dilute aqueous dispersions of clay , 1980 .