Dynamics and control study on the low temperature methanation reactor with mass and heat recycle

Abstract Both nonlinear and linear dynamic characteristics of the low temperature methanation reactor with recycle loop are analyzed for the process safe operation and effective control. Aspen Dynamics tool is adopted to get transient behaviors of the reactor under step changes of the inlet temperature and CO mole fraction. A double-input-multi-output linearized system based on the nonlinear dynamic model is developed for further insight into the process stability, response rapidity and controllability. Similar responses are obtained in the nonlinear and linear models for commendable mutual authenticating. The presence of material recycle because of the unconverted reactants, together with the thermal recycle for energy saving, renders a more sensitive stability of the system, where thermal feedback has the major effect, but the existing of mass feedback may weaken this effect when considerable heat is recycled. Moreover, the transfer function of the linear model indicates that the integral term is necessary for the reactor variables control, and the proposed control strategy using a High Selector module in Aspen Dynamics can successfully maintain the hot spot temperature within the reactor by considering the migration of the peak temperature under the two disturbances.

[1]  T. Schildhauer,et al.  Applying spatially resolved concentration and temperature measurements in a catalytic plate reactor for the kinetic study of CO methanation , 2010 .

[2]  Panagiotis D. Christofides,et al.  Studies on nonlinear dynamics and control of a tubular reactor with recycle , 2001 .

[3]  M. Rovaglio,et al.  A reliable control for the ammonia loop facing limit‐cycle and snowball effects , 2004 .

[4]  W. Luyben.  Design and Control of the Cumene Process , 2010 .

[5]  William L. Luyben,et al.  Chemical Reactor Design and Control , 2007 .

[6]  G. Froment,et al.  Methane steam reforming, methanation and water‐gas shift: I. Intrinsic kinetics , 1989 .

[7]  T. Schildhauer,et al.  Methanation in a fluidized bed reactor with high initial CO partial pressure: Part II— Modeling and sensitivity study , 2011 .

[8]  Chunshan Li,et al.  Low-temperature methanation of CO in coke oven gas using single nanosized Co3O4 catalysts , 2012 .

[9]  W. Luyben.  Design and control of the ethyl benzene process , 2011 .

[10]  Henryk Merta,et al.  Chaotic dynamics of a cascade of plug flow tubular reactors (PFTRs) with division of recirculating stream , 2005 .

[11]  Marek Berezowski.  Spatio-temporal chaos in tubular chemical reactors with the recycle of mass , 2000 .

[12]  Mohammad Reza Rahimpour,et al.  A two-stage catalyst bed concept for conversion of carbon dioxide into methanol , 2008 .

[13]  Prodromos Daoutidis,et al.  Control of hot spots in plug flow reactors , 2002 .

[14]  T. Schildhauer,et al.  Production of synthetic natural gas (SNG) from coal and dry biomass - A technology review from 1950 to 2009 , 2010 .

[15]  Marek Berezowski,et al.  Chaotic and non-chaotic mixed oscillations in a logistic system with delay and heat-integrated tubular chemical reactor , 2002 .

[16]  S. Skogestad,et al.  Analysis of instability in an industrial ammonia reactor , 1998 .

[17]  W. Luyben.  Design and Control of a Methanol Reactor/Column Process , 2010 .

[18]  Filip Logist,et al.  Simulation of (bio)chemical processes with distributed parameters using Matlab , 2009 .

[19]  M. Michelsen,et al.  State-Space Formulation of Fixed-Bed Reactor Dynamics , 1973 .

[20]  P. Maffettone,et al.  Multistability and hysteresis in an industrial ammonia reactor , 2000 .

[21]  Marek Berezowski.  Dynamic profiles in chemical reactors with recycle , 1993 .

[22]  Mohammad Shahrokhi,et al.  Modeling, simulation and control of a methanol synthesis fixed-bed reactor , 2005 .

[23]  Asen I. Anastasov,et al.  A study of the influence of the operating parameters on the temperature of the hot spot in a fixed bed reactor , 2002 .

[24]  Ville Alopaeus,et al.  A dynamic model for plug flow reactor state profiles , 2008, Comput. Chem. Eng..

[25]  Tilman J. Schildhauer,et al.  Methanation in a fluidized bed reactor with high initial CO partial pressure: Part I—Experimental investigation of hydrodynamics, mass transfer effects, and carbon deposition , 2011 .

[26]  Marek Berezowski,et al.  Chaotic dynamics in homogeneous tubular reactors with recycle , 1998 .

[27]  Transient behaviour of an adiabatic fixed-bed methanator—II: Methanation of mixtures of carbon monoxide and carbon dioxide , 1976 .

[28]  Mohammad Reza Rahimpour,et al.  Dynamic Simulation and Optimization of a Dual‐Type Methanol Reactor Using Genetic Algorithms , 2008 .