Influence of harmonic AC voltage on surface discharge formation in transformer insulation

The Ultra High Frequency (UHF) signal radiated during the surface discharge process under harmonic AC voltages with different Total Harmonic Distortion (THD) shows a dominant frequency at 0.8 GHz. The surface discharge inception voltage decreases with an increase in harmonics and THD as observed in the present work. The peak factor of the harmonic voltage and the surface discharge inception factor show inverse relationship. The rise time of injected current pulse due to surface discharges measured using High Frequency Current Transformer (HFCT) is about 600 ps and 900 ps for the positive and negative current signal, respectively. Cumulative energy spectra and Ternary plot confirms that UHF signal generated due to surface discharge process does not significantly vary under harmonic AC voltage with different THD's. The magnitude of UHF signal formed due to surface discharge under 50 Hz AC voltage is higher than that formed under the harmonic AC voltage. Surface charge measurement after corona charging process with the oil impregnated pressboard material indicates that the amount of charge deposited is high with the specimen damaged under harmonic AC voltage. Degraded zone of oil impregnated pressboard insulation due to surface discharges was analyzed using Attenuated Total Reflectance Fourier Transform Infra-red (ATR-FTIR) spectroscopy. Phase resolved partial discharge (PRPD) studies indicate that surface discharge activity predominates when the rate of rise of voltage is high.

[1]  Issouf Fofana,et al.  Characterization of aging transformer oil–pressboard insulation using some modern diagnostic techniques , 2011 .

[2]  M. Pompili,et al.  Partial discharge development and detection in dielectric liquids , 2009, IEEE Transactions on Dielectrics and Electrical Insulation.

[3]  A. Beroual,et al.  Barrier effect on breakdown of point-plane oil gaps under alternating current voltage , 2010 .

[4]  Ruijin Liao,et al.  Measurements and analysis of surface damage on oil-impregnated insulation paper caused by partial discharge , 2011 .

[5]  S. Sahli,et al.  Surface Potential Decay of Low Density Polyethylene (LDPE) Films under Different Corona Discharge Conditions , 2010 .

[6]  P. M. Eleftherion.  Partial discharge. XXI. Acoustic emission based PD source location in transformers , 1995 .

[7]  A. Domijan,et al.  The effects of linear and nonlinear operation modes in transformers , 2004, 2004 11th International Conference on Harmonics and Quality of Power (IEEE Cat. No.04EX951).

[8]  Haiqing Niu,et al.  A modified method of suppressing narrow-band interference using FFT power spectrum , 2013, 2013 IEEE International Conference on Solid Dielectrics (ICSD).

[9]  Gian Montanari,et al.  Bringing an insulation to failure: The role of space charge , 2010, 2010 Annual Report Conference on Electrical Insulation and Dielectic Phenomena.

[10]  Gian Carlo Montanari,et al.  An approach to life estimation of electrical plant components in the presence of harmonic distortion , 2000, Ninth International Conference on Harmonics and Quality of Power. Proceedings (Cat. No.00EX441).

[11]  R. Schifani,et al.  Partial discharge tests using CIGRE method II , 2000 .

[12]  M. Etezadi-Amoli,et al.  Voltage and current harmonic content of a utility system-a summary of 1120 test measurements , 1990 .

[13]  A. Beroual,et al.  Analysis of cumulative number and polarity of creeping discharges initiated at solid/liquid interfaces subjected to AC voltage , 2009, 2009 IEEE Conference on Electrical Insulation and Dielectric Phenomena.

[14]  C. M. Cooke,et al.  Charging of Insulator Surfaces by Ionization and Transport in Gases , 1981, IEEE Transactions on Electrical Insulation.

[15]  Martin D. Judd,et al.  Partial discharge study in transformer oil due to particle movement under DC voltage using the UHF technique , 2008 .

[16]  S. A. Khaparde,et al.  Transformer Engineering: Design, Technology, and Diagnostics, Second Edition , 2012 .

[17]  B. Florkowska,et al.  The Role of Harmonic Components on Partial Discharge Mechanism and Degradation Processes in Epoxy Resin Insulation , 2007, 2007 IEEE International Conference on Solid Dielectrics.

[18]  Pawel Zydron,et al.  Impact of high voltage harmonics on interpretation of partial discharge patterns , 2013, IEEE Transactions on Dielectrics and Electrical Insulation.

[19]  J. Kindersberger,et al.  Surface charge accumulation on cylindrical polymeric model insulators in air: simulation and measurement , 2011, IEEE Transactions on Dielectrics and Electrical Insulation.

[20]  T. Tanaka,et al.  Characteristics of Composite Insulation: Liquid-Impregnated Insulation , 1986, IEEE Transactions on Electrical Insulation.

[21]  Lijun Yang,et al.  Product analysis of partial discharge damage to oil-impregnated insulation paper , 2011 .

[22]  S. Boggs,et al.  A rational consideration of space charge , 2004, IEEE Electrical Insulation Magazine.

[23]  R. Bartnikas.  Performance characteristics of dielectrics in the presence of space charge , 1997 .

[24]  T. Dionise,et al.  Voltage Distortion on an Electrical Distribution System , 2010, IEEE Industry Applications Magazine.

[25]  P.E. Sutherland.  Harmonic measurements in industrial power systems , 1994, Proceedings of Industrial and Commercial Power Systems Conference.

[26]  P L Lewin,et al.  Tracking and surface discharge at the oilߝpressboard interface , 2010, IEEE Electrical Insulation Magazine.

[27]  Junhao Li,et al.  Partial discharge characteristics over differently aged oil/pressboard interfaces , 2009, IEEE Transactions on Dielectrics and Electrical Insulation.

[28]  Xiu Yao,et al.  Measurement and simulation of partial discharge in oil impregnated pressboard with an electrical aging process , 2009 .

[29]  J. L. Fierro-Chavez,et al.  Effect of surface charge on hydrophobicity levels of insulating materials , 1998 .

[30]  T. Bengtsson,et al.  Dielectric heating in insulating materials subjected to voltage waveforms with high harmonic content , 2009, IEEE Transactions on Dielectrics and Electrical Insulation.

[31]  H. Kojima,et al.  Surface charge accumulation and partial discharge activity for small gaps of electrode/epoxy interface in sf6 gas , 2009, IEEE Transactions on Dielectrics and Electrical Insulation.

[32]  Michel Duval,et al.  A review of faults detectable by gas-in-oil analysis in transformers , 2002 .

[33]  M D Judd,et al.  UHF Couplers for GIS - Sensitivity and Specification , 1997 .

[34]  Wang Hui,et al.  Experimental study on the evolution of surface discharge for oil-paper insulation in transformers , 2009, 2009 IEEE Conference on Electrical Insulation and Dielectric Phenomena.

[35]  José A. Giacometti,et al.  Corona charging of polymers , 1992 .

[36]  S. Tsukao,et al.  Increase of Static Electrification in Aged Transformers , 2007, 2007 IEEE Power Engineering Society General Meeting.

[37]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[38]  S. Gubanski,et al.  Surface charges on cylindrical polymeric insulators , 2012, IEEE Transactions on Dielectrics and Electrical Insulation.

[39]  Davide Fabiani,et al.  The effect of voltage distortion on ageing acceleration of insulation systems under partial discharge activity , 2001 .

[40]  Martin D. Judd,et al.  UHF and current pulse measurements of partial discharge activity in mineral oil , 2006 .

[41]  Bo Qi,et al.  Surface discharge initiated by immobilized metallic particles attached to gas insulated substation insulators: process and features , 2011, IEEE Transactions on Dielectrics and Electrical Insulation.

[42]  Z. Berler,et al.  Effective methods of assessment of insulation system conditions in power transformers: a view based on practical experience , 1999, Proceedings: Electrical Insulation Conference and Electrical Manufacturing and Coil Winding Conference (Cat. No.99CH37035).

[43]  B. Florkowska,et al.  Distortion of partial-discharge images caused by high-voltage harmonics , 2006 .

[44]  L. Centurioni,et al.  An investigation about the PD degradation of thin polymer films and its correlation with surface charge decay measurements , 2002, Conference Record of the the 2002 IEEE International Symposium on Electrical Insulation (Cat. No.02CH37316).

[45]  P Jarman,et al.  Creepage discharge on insulation barriers in aged power transformers , 2010, IEEE Transactions on Dielectrics and Electrical Insulation.

[46]  Zhiqiang Xu,et al.  Decay of electric charge on corona charged polyethylene , 2007 .

[47]  Analysis of creeping discharges activity at solid/liquid interfaces subjected to ac voltage , 2011 .

[48]  X. Yi,et al.  Surface tracking on pressboard in natural and synthetic transformer liquids under AC stress , 2013, IEEE Transactions on Dielectrics and Electrical Insulation.