Effects of gas flow rate, inlet concentration and temperature on biofiltration of volatile organic compounds in a peat-packed biofilter.

The effects of incoming gas concentration, empty bed residence time (EBRT), and column temperature on the removal efficiency of volatile organic compounds (isoprene, dimethyl sulfide, chloroform, benzene, trichloroethylene, toluene, m-xylene, o-xylene and styrene) were studied for 101 d in a biofilter comprising two glass columns (I.D. 5.0 cm x height 62 cm) packed with peat. At an EBRT of 3 min the removal efficiency increased up to 90% 34 d after start up at both 25 degrees C and 45 degrees C when the incoming gas concentration was raised stepwise to 65 g.m(-3). When the incoming gas concentration increased to 83 g.m(-3), the removal efficiency was 93% at 25 degrees C, but dropped to 74% at 45 degrees C. At an incoming gas concentration of 92 g.m(-3) and an EBRT of 1.5 min, the removal efficiencies were 91% and 94% at 25 degrees C and 32 degrees C, respectively. However, at 1 min of EBRT, the removal efficiencies decreased to 68% and 81% at 25 degrees C and 32 degrees C, respectively. The removal rate per unit time and per unit volume of the biofilter was proportional to the incoming gas rate up to 3483 g VOC.m(-3).h(-1). Further increase of the incoming gas rate lowered the removal rate as compared to that predicted by the proportionality. The maximum removal rate was 3977 g.m(-3).h(-1) at 32 degrees C. At an EBRT of 1.5 min, the removal efficiency was highest for isoprene (93%), and lowest for chloroform (84%). Aromatic compounds (benzene, toluene, and xylene) were removed by 93-94%. The cell concentration increased 100-fold from the initial value, and reached 1.12 x 10(8) cells.(g of dry peat)(-1). At 32 degrees C, 67% of the incoming VOC was removed in the first quarter of the column.

[1]  Chungsying Lu,et al.  Temperature Effects of Trickle-Bed Biofilter for Treating BTEX Vapors , 1999 .

[2]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[3]  A M Winer,et al.  Biofiltration: an innovative air pollution control technology for VOC emissions. , 1991, Journal of the Air & Waste Management Association.

[4]  B. Ramsay,et al.  Active compost biofiltration of toluene , 2004, Biodegradation.

[5]  Dick B. Janssen,et al.  Handbook on Biodegradation and Biological Treatment of Hazardous Organic Compounds , 1998 .

[6]  C. D. Cox,et al.  Cometabolic biodegradation of trichloroethylene (TCE) in the gas phase , 1998 .

[7]  L. Elsgaard.  Ethylene Removal at Low Temperatures under Biofilter and Batch Conditions , 2000, Applied and Environmental Microbiology.

[8]  L. Fishbein.  An overview of environmental and toxicological aspects of aromatic hydrocarbons. IV. Ethylbenzene. , 1985, The Science of the total environment.

[9]  M. Heitz,et al.  Biological Elimination of Volatile Organic Compounds from Waste Gases in a Biofilter , 1998 .

[10]  J. Spain,et al.  Adaptation of Natural Microbial Communities to Degradation of Xenobiotic Compounds: Effects of Concentration, Exposure Time, Inoculum, and Chemical Structure , 1983, Applied and environmental microbiology.

[11]  R. Scott Summers,et al.  Biofiltration performance: part 1, relationship to biomass , 1995 .

[12]  J. Hobbie,et al.  Use of nuclepore filters for counting bacteria by fluorescence microscopy , 1977, Applied and environmental microbiology.

[13]  E. R. Allen,et al.  Biofiltration Control of Hydrogen Sulfide 1. Design and Operational Parameters , 1994 .

[14]  Martin Reinhard,et al.  Occurrence and distribution of organic chemicals in two landfill leachate plumes , 1984 .

[15]  Raymond C. Loehr,et al.  Biofiltration: Fundamentals, design and operations principles and applications , 1997 .

[16]  K. Kinney,et al.  Characterization of compost biofiltration system degrading dichloromethane , 1994, Biotechnology and bioengineering.