The influence of pH and ammonia concentration on the methane production in high‐solids digestion processes

The influence of pH and ammonium‐nitrogen on methane production in a high‐solids sludge digestion process was investigated using a mesophilic batch digester fed with a sludge cake. A simple model developed from the Gompertz equation was applied to the quantitative measurement of the methane production rate and lag‐phase time at pHs ranging from 6.5 to 9.0 and ammonium‐nitrogen concentrations ranging from 100 to 6 000 mg/L. The results indicate that the ammonium‐nitrogen concentration was a more significant factor than the free ammonia in affecting the methanogenic activity of a well‐acclimatized system. The simulated results reveal that the methanogenic activity decreased with an increase in ammonium‐nitrogen, dropped 10% at an ammonium‐nitrogen concentration of 1 670 to 3 720 mg/L, dropped 50% at 4 090 to 5 550 mg/L, and dropped to zero at 5 880 to 6 000 mg/L. The lag‐phase time in the batch experiment was dependent on the ammonia level, but not ammonium, and when the free ammonia concentration was higher than 500 mg/L, a notable shock load was observed. In addition, the maximum methane‐converting capacity of sludge changed from 28 to 0.9 mL CH4/g VS·d when the ammonium‐nitrogen concentration increased from 100 to 6 000 mg/L.

[1]  J. Lay,et al.  INFLUENCES OF pH AND MOISTURE CONTENT ON THE METHANE PRODUCTION IN HIGH-SOLIDS SLUDGE DIGESTION , 1997 .

[2]  S. Sastry,et al.  Growth kinetics of Lactobacillus acidophilus under ohmic heating , 2000, Biotechnology and bioengineering.

[3]  D. Boone,et al.  Influence of pH on Ammonia Accumulation and Toxicity in Halophilic, Methylotrophic Methanogens , 1996, Applied and environmental microbiology.

[4]  J. Lay,et al.  EFFECT OF MOISTURE CONTENT AND CHEMICAL NATURE ON METHANE FERMENTATION CHARACTERISTICS OF MUNICIPAL SOLID WASTES , 1996, Doboku Gakkai Ronbunshu.

[5]  Richard E. Speece,et al.  Anaerobic Biotechnology for Industrial Wastewaters , 1996 .

[6]  M. Kayhanian,et al.  Sludge management using the biodegradable organic fraction of municipal solid waste as a primary substrate , 1996 .

[7]  Barth F. Smets,et al.  Variability in kinetic parameter estimates: A review of possible causes and a proposed terminology , 1996 .

[8]  頼 俊吉,et al.  Effect of Moisture Content and Chemical Nature on Methane Fermentation Characteristics of Municipal Solid Wastes. , 1996 .

[9]  T. Noike,et al.  Performance analysis of the full-scale egg-shaped digester in treating sewage sludge of high concentration , 1996 .

[10]  T. Noike,et al.  Response of mixed cultures of chlorella vulgaris and heterotrophic bacteria to variation of pH , 1994 .

[11]  Paul N. Cheremisinoff.  Sludge: Management and Disposal , 1994 .

[12]  T. Wen,et al.  A kinetic model of a recirculated upflow anaerobic sludge blanket treating phenolic wastewater , 1994 .

[13]  Stephen H. Zinder,et al.  Physiological Ecology of Methanogens , 1993 .

[14]  Paolo Pavan,et al.  Semi-Dry Thermophilic Anaerobic Digestion of Fresh and Pre-Composted Organic Fraction of Municipal Solid Waste (MSW): Digester Performance , 1993 .

[15]  M H Zwietering,et al.  Comparison of definitions of the lag phase and the exponential phase in bacterial growth. , 1992, The Journal of applied bacteriology.

[16]  Robert L. Buchanan,et al.  A mathematical approach toward defining and calculating the duration of the lag phase , 1990 .

[17]  F. Rombouts,et al.  Modeling of the Bacterial Growth Curve , 1990, Applied and environmental microbiology.

[18]  W. M. Haynes.  CRC Handbook of Chemistry and Physics , 1990 .

[19]  Gerasimos Lyberatos,et al.  Effect of temperature and ph on the effective maximum specific growth rate of nitrifying bacteria , 1990 .

[20]  Shangtian Yang,et al.  Effects of pH and acetic acid on homoacetic fermentation of lactate by Clostridium formicoaceticum , 1989, Biotechnology and bioengineering.

[21]  O. Levenspiel,et al.  Extended monod kinetics for substrate, product, and cell inhibition , 1988, Biotechnology and bioengineering.

[22]  Gatze Lettinga,et al.  Anaerobic digestion at extreme ammonia concentrations. , 1988 .

[23]  J M Tiedje,et al.  General method for determining anaerobic biodegradation potential , 1984, Applied and environmental microbiology.

[24]  S. Ghosh,et al.  Solid-phase digestion of low-moisture feeds , 1984 .

[25]  G. Lettinga,et al.  The influence of ammonium-nitrogen on the specific activity of pelletized methanogenic sludge , 1984 .

[26]  Willy Verstraete,et al.  Influence of high NaCl and NH4Cl salt levels on methanogenic associations , 1984 .

[27]  Wilson H. Tang,et al.  Probability concepts in engineering planning and design , 1984 .

[28]  Anthony F. Gaudy,et al.  Microbiology for environmental scientists and engineers , 1981 .

[29]  W. J. Jewell,et al.  Dry anaerobic fermentation , 1980 .

[30]  E. J. Kroeker.  Anaerobic treatment process stability , 1979 .

[31]  A.F.M. Van Velsen,et al.  Adaptation of methanogenic sludge to high ammonia-nitrogen concentrations , 1979 .

[32]  P. Mccarty,et al.  Bioassay for monitoring biochemical methane potential and anaerobic toxicity , 1979 .

[33]  D. M. Ward,et al.  Biogenesis of methane. , 1977, Annual review of microbiology.

[34]  Edward D. Schroeder,et al.  Water and wastewater treatment , 1977 .

[35]  W A Taber,et al.  Wastewater microbiology. , 1976, Annual review of microbiology.

[36]  T. Miller,et al.  A serum bottle modification of the Hungate technique for cultivating obligate anaerobes. , 1974, Applied microbiology.

[37]  C. E. Lankford,et al.  Inoculum-Dependent Division Lag of Bacillus Cultures and Its Relation to an Endogenous Factor(s) (“Schizokinen”) , 1966, Journal of bacteriology.

[38]  a Kinetic Model , 2022 .