Extremely fast increase in the organic loading rate during the co-digestion of rapeseed oil and sewage sludge in a CSTR--characterization of granules formed due to CaO addition to maintain process stability.

In a co-digestion system running with rapeseed oil and sewage sludge, an extremely fast increase in the organic loading rate was studied to develop a procedure to allow for flexible and demand-driven energy production. The over-acidification of the digestate was successfully prevented by calcium oxide dosage, which resulted in granule formation. Mineralogical analyses revealed that the granules were composed of insoluble salts of long chain fatty acids and calcium and had a porous structure. Long chain fatty acids and calcium formed the outer cover of granules and offered interfaces on the inside thereby enhancing the growth of biofilms. With granule size and age, the pore size increased and indicated degradation of granular interfaces. A stable biogas production up to the organic loading rate of 10.4 kg volatile solids m(-3) d(-1) was achieved although the hydrogen concentration was not favorable for propionic acid degradation. However, at higher organic loading rates, unbalanced granule formation and degradation were observed. Obviously, the adaption time for biofilm growth was too short to maintain the balance, thereby resulting in a low methane yield.

[1]  M. Kraume,et al.  Application of an early warning indicator and CaO to maximize the time-space-yield of an completely mixed waste digester using rape seed oil as co-substrate. , 2014, Waste management.

[2]  W. Verstraete,et al.  Early warning indicators for process failure due to organic overloading by rapeseed oil in one-stage continuously stirred tank reactor, sewage sludge and waste digesters. , 2012, Bioresource technology.

[3]  M. Kraume,et al.  Comparison of different procedures to stabilize biogas formation after process failure in a thermophilic waste digestion system: influence of aggregate formation on process stability. , 2012, Waste management.

[4]  Anwar Ahmad,et al.  Role of calcium oxide in sludge granulation and methanogenesis for the treatment of palm oil mill effluent using UASB reactor. , 2011, Journal of hazardous materials.

[5]  M. Spérandio,et al.  Biologically induced phosphorus precipitation in aerobic granular sludge process. , 2011 .

[6]  Sonja Schreurs,et al.  Study of bio-oils and solids from flash pyrolysis of sewage sludges , 2009 .

[7]  R. Barat,et al.  Interactions between calcium precipitation and the polyphosphate-accumulating bacteria metabolism. , 2008, Water research.

[8]  Hanqing Yu,et al.  Calcium spatial distribution in aerobic granules and its effects on granule structure, strength and bioactivity. , 2008, Water research.

[9]  M. Zaiat,et al.  Granules characteristics in the vertical profile of a full-scale upflow anaerobic sludge blanket reactor treating poultry slaughterhouse wastewater. , 2008, Bioresource technology.

[10]  D. Deublein,et al.  Biogas from Waste and Renewable Resources , 2008 .

[11]  J. Wong,et al.  Transformation of organic matter during co-composting of pig manure with sawdust. , 2006, Bioresource technology.

[12]  P. Egeberg,et al.  Quantitative determination of saturated and unsaturated fatty acids in edible oils by infrared spectroscopy and chemometrics , 2006 .

[13]  M. Kaiser,et al.  Stability and composition of different soluble soil organic matter fractions-evidence from δ13C and FTIR signatures , 2005 .

[14]  P. Lens,et al.  Anaerobic sludge granulation. , 2004, Water research.

[15]  Orhan Yenigün,et al.  Two‐phase anaerobic digestion processes: a review , 2002 .

[16]  P Gras,et al.  Evaluation of a four year experience with a fully instrumented anaerobic digestion process. , 2002, Water science and technology : a journal of the International Association on Water Pollution Research.

[17]  Joo-Hwa Tay,et al.  INFLUENCE OF SUBSTRATE CONCENTRATION ON MICROBIAL SELECTION AND GRANULATION DURING START-UP OF UPFLOW ANAEROBIC SLUDGE BLANKET REACTORS , 1996 .

[18]  B. Ahring,et al.  Effects of free long-chain fatty acids on thermophilic anaerobic digestion , 1992, Applied Microbiology and Biotechnology.

[19]  Serge R. Guiot,et al.  Layered structure of bacterial aggregates produced in an upflow anaerobic sludge bed and filter reactor , 1990, Applied and environmental microbiology.

[20]  M. P. Bryant,et al.  Propionate-Degrading Bacterium, Syntrophobacter wolinii sp. nov. gen. nov., from Methanogenic Ecosystems , 1980, Applied and environmental microbiology.

[21]  A. Buswell,et al.  The mechanism of the methane fermentation. , 1952, Journal of the American Chemical Society.

[22]  S. Mathieu,et al.  Biologically induced phosphorus precipitation in aerobic granular sludge process. , 2011, Water research.

[23]  T Conte,et al.  Dynamic evaluation of a fixed bed anaerobic digestion process in response to organic overloads and toxicant shock loads. , 2004, Water science and technology : a journal of the International Association on Water Pollution Research.

[24]  I. W. Koster,et al.  Abatement of long-chain fatty acid inhibition of methanogenesis by calcium addition , 1987 .

[25]  S. K. Ghosh,et al.  Developments in anaerobic stabilization of organic wastes--the two-phase concept. , 1971, Environmental letters.