Microfluidic assisted preparation of CdSe/ZnS nanocrystals encapsulated into poly(DL-lactide-co-glycolide) microcapsules

This paper demonstrates a proof-of-concept approach for encapsulating CdSe/ZnS quantum dots (QDs) into uniform-sized poly(DL-lactide-co-glycolide) (PLGA) biocompatible microcapsules utilizing a microfluidic chip. By adapting a blend of poly(vinyl alcohol) (PVA) and chitosan (CS) as stabilizers for constructing a PLGA polymer matrix to entrap CdSe/ZnS QDs, the PLGA polymer solution was constrained to adopt the spherical droplets in a continuous aqueous phase at a microchannel cross-junction. The generation of these droplets was then studied quantitatively. The flow conditions of the two immiscible solutions were adjusted in order to successfully generate the polymer droplets. Size-controllable PLGA microgels containing CdSe/ZnS QDs were produced, ranging in size from 180 to 550 µm in diameter. The narrow size distribution (within ± 5%) was obtained by altering the ratio of the flow rate. In contrast to individual QDs, each PLGA microsphere encapsulates thousands of fluorescent QDs in a protective polymer matrix, providing a highly amplified and reproducible signal for fluorescence-based bioanalysis.

[1]  W. Webb,et al.  Water-Soluble Quantum Dots for Multiphoton Fluorescence Imaging in Vivo , 2003, Science.

[2]  Darwin R. Reyes,et al.  Micro total analysis systems. 1. Introduction, theory, and technology. , 2002, Analytical chemistry.

[3]  Toru Torii,et al.  Controlled production of monodisperse double emulsions by two-step droplet breakup in microfluidic devices. , 2004, Langmuir : the ACS journal of surfaces and colloids.

[4]  Eun Kyu Lee,et al.  Continuous fabrication of biocatalyst immobilized microparticles using photopolymerization and immiscible liquids in microfluidic systems. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[5]  Xiaogang Peng,et al.  Experimental Determination of the Extinction Coefficient of CdTe, CdSe, and CdS Nanocrystals , 2003 .

[6]  Louis E. Brus,et al.  Nucleation and Growth of CdSe on ZnS Quantum Crystallite Seeds and Vice Versa, in Inverse Micelle Media , 1990 .

[7]  G. Whitesides,et al.  Formation of droplets and bubbles in a microfluidic T-junction-scaling and mechanism of break-up. , 2006, Lab on a chip.

[8]  Eiji Ohtani,et al.  Electroluminescence from single monolayers of nanocrystals in molecular organic devices , 2022 .

[9]  G. Whitesides,et al.  Mechanism for flow-rate controlled breakup in confined geometries: a route to monodisperse emulsions. , 2005, Physical review letters.

[10]  T. Park,et al.  Biodegradable PLGA Microcarriers for Injectable Delivery of Chondrocytes: Effect of Surface Modification on Cell Attachment and Function , 2004, Biotechnology progress.

[11]  Helen Song,et al.  Formation of droplets and mixing in multiphase microfluidics at low values of the Reynolds and the capillary numbers , 2003 .

[12]  Liberato Manna,et al.  Synthesis of Soluble and Processable Rod-, Arrow-, Teardrop-, and Tetrapod-Shaped CdSe Nanocrystals , 2000 .

[13]  Vincent Noireaux,et al.  In Vivo Imaging of Quantum Dots Encapsulated in Phospholipid Micelles , 2002, Science.

[14]  Igor L. Medintz,et al.  Quantum dot bioconjugates for imaging, labelling and sensing , 2005, Nature materials.

[15]  C. Wischke,et al.  Stable cationic microparticles for enhanced model antigen delivery to dendritic cells. , 2006, Journal of controlled release : official journal of the Controlled Release Society.

[16]  T. Mihaljevic,et al.  Near-infrared fluorescent type II quantum dots for sentinel lymph node mapping , 2004, Nature Biotechnology.

[17]  A. Alivisatos,et al.  Light-emitting diodes made from cadmium selenide nanocrystals and a semiconducting polymer , 1994, Nature.

[18]  Jun Kameoka,et al.  An electrospray ionization source for integration with microfluidics. , 2002, Analytical chemistry.

[19]  G. Whitesides,et al.  Generation of monodisperse particles by using microfluidics: control over size, shape, and composition. , 2005, Angewandte Chemie.

[20]  Minseok Seo,et al.  Polymer particles with various shapes and morphologies produced in continuous microfluidic reactors. , 2005, Journal of the American Chemical Society.

[21]  A. Manz,et al.  Micro total analysis systems. Recent developments. , 2004, Analytical chemistry.

[22]  George M. Whitesides,et al.  An Axisymmetric Flow‐Focusing Microfluidic Device , 2005 .

[23]  S. Nie,et al.  Quantum dot bioconjugates for ultrasensitive nonisotopic detection. , 1998, Science.

[24]  A. Berg,et al.  Micro Total Analysis Systems , 1995 .

[25]  Jayanth Panyam,et al.  Dynamics of Endocytosis and Exocytosis of Poly(D,L-Lactide-co-Glycolide) Nanoparticles in Vascular Smooth Muscle Cells , 2003, Pharmaceutical Research.

[26]  Ethan Tumarkin,et al.  Microfluidic production of biopolymer microcapsules with controlled morphology. , 2006, Journal of the American Chemical Society.

[27]  Vittorio Cristini,et al.  Monodispersed microfluidic droplet generation by shear focusing microfluidic device , 2006 .

[28]  Vittorio Cristini,et al.  Design of microfluidic channel geometries for the control of droplet volume, chemical concentration, and sorting. , 2004, Lab on a chip.

[29]  S. Gambhir,et al.  Quantum Dots for Live Cells, in Vivo Imaging, and Diagnostics , 2005, Science.

[30]  P. Guyot-Sionnest,et al.  Synthesis and Characterization of Strongly Luminescing ZnS-Capped CdSe Nanocrystals , 1996 .

[31]  G. Whitesides,et al.  Erratum: Generation of monodisperse particles by using microfluidics - Control over size, shape, and composition (Angewandte Chemie - International Edition (2005) 44 (724-728) DOI: 10.1002/anie.200462226) , 2005 .

[32]  Surface Entrapment of Polylysine in Biodegradable Poly(dl-lactide-co-glycolide) Microparticles , 2001 .

[33]  J. Matthew Mauro,et al.  Self-Assembly of CdSe−ZnS Quantum Dot Bioconjugates Using an Engineered Recombinant Protein , 2000 .

[34]  M. Bawendi,et al.  Electroluminescence from CdSe quantum‐dot/polymer composites , 1995 .

[35]  Oliver Geschke,et al.  CO(2)-laser micromachining and back-end processing for rapid production of PMMA-based microfluidic systems. , 2002, Lab on a chip.

[36]  J. Cleland.  Solvent Evaporation Processes for the Production of Controlled Release Biodegradable Microsphere Formulations for Therapeutics and Vaccines , 1998, Biotechnology progress.

[37]  Xiaogang Peng,et al.  Formation of high-quality CdTe, CdSe, and CdS nanocrystals using CdO as precursor. , 2001, Journal of the American Chemical Society.

[38]  Peter Mitchell,et al.  Turning the spotlight on cellular imaging , 2001, Nature Biotechnology.

[39]  V. Cristini,et al.  Theory and numerical simulation of droplet dynamics in complex flows--a review. , 2004, Lab on a chip.

[40]  U. Banin,et al.  Efficient Near-Infrared Polymer Nanocrystal Light-Emitting Diodes , 2002, Science.

[41]  Takehiko Kitamori,et al.  Continuous-flow chemical processing on a microchip by combining microunit operations and a multiphase flow network. , 2002, Analytical chemistry.

[42]  U. Bakowsky,et al.  Preparation and characterization of cationic PLGA nanospheres as DNA carriers. , 2004, Biomaterials.

[43]  Minoru Seki,et al.  Interfacial Tension Driven Monodispersed Droplet Formation from Microfabricated Channel Array , 2001 .

[44]  Armand Ajdari,et al.  Droplet Control for Microfluidics , 2005, Science.

[45]  Wei Liu,et al.  Preparation and characterization of novel CdSe quantum dots modified with poly (d, l-lactide) nanoparticles , 2006 .

[46]  Caroline Seydel,et al.  Quantum Dots Get Wet , 2003, Science.

[47]  Z. Rosenzweig,et al.  Luminescent CdSe Quantum Dot Doped Stabilized Micelles , 2002 .

[48]  D. Weitz,et al.  Monodisperse Double Emulsions Generated from a Microcapillary Device , 2005, Science.

[49]  Thomas Henkel,et al.  Generation of larger numbers of separated microbial populations by cultivation in segmented-flow microdevices. , 2003, Lab on a chip.

[50]  Darwin R. Reyes,et al.  Micro Total Analysis Systems , 2002 .

[51]  H. Stone,et al.  Formation of dispersions using “flow focusing” in microchannels , 2003 .

[52]  J. Lakowicz,et al.  Emission Spectral Properties of Cadmium Sulfide Nanoparticles with Multiphoton Excitation. , 2002, The journal of physical chemistry. B.