Catalytic cracking of toluene using a biochar derived catalyst

CATALYST by ANKITA JUNEJA (Under the Direction of Sudhagar Mani) ABSTRACT This research investigated char naturally produced inside the gasifier, as a low cost catalyst, to decompose toluene as a model tar compound from the temperature range of 600-900°C. The reaction kinetics found from 650 to 900°C gave an activation energy of 90 kJ/mol for toluene decomposition (compared to 80.24 kJ/mol for Ni/Mayenite and 196 kJ/mol for olivine). The catalytic activity of char for toluene decomposition was comparable to other commercially available catalysts. It is theorized that metals in the char catalyzed a free radical reaction in which benzene, CO2 and CH4 was formed as end products. Additionally, when char was loaded with iron (9.89%, 13% and 18.7% by weight), the activity increased and the temperatures required for almost complete conversion were lowered from 900 to 8000C. The activation energy found for the iron loaded char (18.7%) was 49 kJ/mol. The results from this research may be used to design a catalytic cracking process using biochar catalysts for tars downstream of a gasifier or inside the gasifier and potentially replace energy intensive and costly processes.

[1]  T. Foust,et al.  An economic and environmental comparison of a biochemical and a thermochemical lignocellulosic ethanol conversion processes , 2009 .

[2]  Chunshan Li,et al.  Development of new nickel based catalyst for biomass tar steam reforming producing H2-rich syngas , 2009 .

[3]  Xionggang Lu,et al.  Hydrogen production from simulated hot coke oven gas by catalytic reforming over Ni/Mg(Al)O catalysts , 2009 .

[4]  Jun-ichiro Hayashi,et al.  Mechanism of decomposition of aromatics over charcoal and necessary condition for maintaining its activity , 2008 .

[5]  S. Saka,et al.  Pyrolysis gasification reactivities of primary tar and char fractions from cellulose and lignin as studied with a closed ampoule reactor , 2008 .

[6]  Gerrit Brem,et al.  Experimental comparison of biomass chars with other catalysts for tar reduction , 2008 .

[7]  Larry G. Felix,et al.  Olivine catalysts for methane- and tar-steam reforming , 2008 .

[8]  D. Świerczyński,et al.  Study of steam reforming of toluene used as model compound of tar produced by biomass gasification , 2008 .

[9]  A. Corma,et al.  Processing biomass-derived oxygenates in the oil refinery: Catalytic cracking (FCC) reaction pathways and role of catalyst , 2007 .

[10]  Jeng-Chyan Muti Lin,et al.  Combination of a Biomass Fired Updraft Gasifier and a Stirling Engine for Power Production , 2007 .

[11]  K. Kuramoto,et al.  Steam Reforming of Woody Biomass in a Fluidized Bed of Iron Oxide-Impregnated Porous Alumina , 2006 .

[12]  Kj Krzysztof Ptasinski,et al.  Olivine as tar removal catalyst for biomass gasifiers: Catalyst characterization , 2005 .

[13]  Kj Krzysztof Ptasinski,et al.  Catalytic decomposition of biomass tars: use of dolomite and untreated olivine , 2005 .

[14]  Andrew A. Suby,et al.  Catalytic destruction of tar in biomass derived producer gas , 2004 .

[15]  José Corella,et al.  Olivine or Dolomite as In-Bed Additive in Biomass Gasification with Air in a Fluidized Bed: Which Is Better? , 2004 .

[16]  T. Namioka,et al.  High Tar Reduction with porous-particles for Low Temperature Biomass Gasification : Effects of Porous Particles on Tar and Gas Yields during Sawdust Pyrolysis , 2003 .

[17]  Seung Wook Baek,et al.  Catalytic cracking of tar component from high-temperature fuel gas , 2003 .

[18]  Wen-ching Yang.  Handbook of Fluidization and Fluid-Particle Systems , 2003 .

[19]  D. Dayton,et al.  A Review of the Literature on Catalytic Biomass Tar Destruction Milestone Completion Report , 2002 .

[20]  K. Sjöström,et al.  Rapid pyrolysis of agricultural residues at high temperature , 2002 .

[21]  Masaru Watanabe,et al.  Catalytic hydrogen generation from biomass (glucose and cellulose) with ZrO2 in supercritical water , 2002 .

[22]  A. Demirbas,et al.  Biomass resource facilities and biomass conversion processing for fuels and chemicals , 2001 .

[23]  P. Paul,et al.  Biomass derived producer gas as a reciprocating engine fuel—an experimental analysis , 2001 .

[24]  Hongbin Zhao,et al.  Performance of a Nickel-Activated Candle Filter for Naphthalene Cracking in Synthetic Biomass Gasification Gas , 2000 .

[25]  Akira Tomita,et al.  Characterization of coke deposited from cracking of benzene over USY zeolite catalyst , 2000 .

[26]  G. Krishnan,et al.  Elucidation of behavior of sulfur on nickel-based hot gas cleaning catalysts , 1999 .

[27]  A. Krause,et al.  Steam Reforming of Gasification Gas Tar over Dolomite with Benzene as a Model Compound , 1999 .

[28]  José Corella,et al.  Commercial Steam Reforming Catalysts To Improve Biomass Gasification with Steam−Oxygen Mixtures. 1. Hot Gas Upgrading by the Catalytic Reactor , 1997 .

[29]  Ian Narváez,et al.  Performance of Different Dolomites on Hot Raw Gas Cleaning from Biomass Gasification with Air , 1997 .

[30]  S. V. Shurupov,et al.  Soot Formation During Pyrolysis of Naphthalene, Anthracene and Pyrene , 1997 .

[31]  Heikki Haario,et al.  Catalytic Decomposition of Gasification Gas Tar with Benzene as the Model Compound , 1997 .

[32]  Georgios Taralas,et al.  Catalytic Steam Cracking of n-Heptane with Special Reference to the Effect of Calcined Dolomite , 1996 .

[33]  Anthony V. Bridgwater,et al.  Catalysis in thermal biomass conversion , 1994 .

[34]  C. M. Kinoshita,et al.  Tar formation under different biomass gasification conditions , 1994 .

[35]  A. Zukal,et al.  Synthesis of liquid fuels from products of biomass gasification , 1994 .

[36]  S. Fukase,et al.  Residual Oil Cracking with Generation of Hydrogen: Deactivation of Iron Oxide Catalyst in the Steam‐Iron Reaction. , 1993 .

[37]  A. Tomita,et al.  Effect of metal oxides on the secondary reactions of volatiles from coal , 1989 .

[38]  Rafael Kandiyoti,et al.  Secondary reactions of flash pyrolysis tars measured in a fluidized bed pyrolysis reactor with some novel design features , 1989 .

[39]  Brown,et al.  Characterization and treatment of tars and biomass gasifiers , 1988 .

[40]  J. Moulijn,et al.  Gas phase pyrolysis of coal-related aromatic compounds in a coiled tube flow reactor:2. Heterocyclic compounds, their benzo and dibenzo derivatives , 1988 .

[41]  D. Mckee.  Mechanisms of the alkali metal catalysed gasification of carbon , 1983 .

[42]  Toshiaki Hanaoka,et al.  Hydrogen production from woody biomass by steam gasification using a CO2 sorbent , 2005 .

[43]  H. Boerrigter,et al.  "OLGA" TAR REMOVAL TECHNOLOGY Proof-of-Concept (PoC) for application in integrated biomass gasification combined heat and power (CHP) systems , 2005 .

[44]  Harrie Knoef,et al.  Handbook biomass gasification , 2005 .

[45]  L. Dinkelbach,et al.  GASREIP: GASREIniging en Prime mover design: fase A: realisatie en beproeving van een basisconfiguratie ten behoeve van biomassa warmte-kracht koppeling , 2000 .

[46]  W. Peters,et al.  Product yields and kinetics from the vapor phase cracking of wood pyrolysis tars , 1989 .

[47]  Henrik Aldén,et al.  Conversion of Tar in Pyrolysis Gas from Wood Using a Fixed Dolomite Bed , 1988 .

[48]  Clas Ekström,et al.  Catalytic Conversion of Tars, Carbon Black and Methane from Pyrolysis/Gasification of Biomass , 1985 .