Preparation and characterization of antifouling graphene oxide/polyethersulfone ultrafiltration membrane: Application in MBR for dairy wastewater treatment

This study was performed to investigate effect of different concentrations of graphene oxide (GO) nanoplates on fouling mitigation of polyethersulfone (PES) membranes applied in membrane bioreactor (MBR) to treatment milk processing wastewater. The GO was prepared from graphite and characterized by FTIR, SEM and XRD. The mixed matrix membranes were prepared in three concentrations of 13, 15 and 17 wt% of PES polymer. Static contact angle of the membranes were decreased significantly with addition of the GO nanosheets caused to increasing of pure water flux and MWCO. Cross sectional SEM images showed that the finger-like pores for all of the GO embedded membranes were slightly wider than that of the unfilled PES membrane. Ultrafiltration performance and fouling resistance of the membranes were tested by filtration of activated sludge. With addition of GO nanoplates, fouling resistance ratio (FRR) of the nanocomposite membranes was improved. AFM images and FRR results presented that a membrane with smoother surface has greater fouling resistance ability. Based on antifouling and water flux results, the PES/GO membrane with 15 wt% of PES and GO content of 0.5 wt%, was selected as an optimal membrane and tested in MBR system. The MBR showed an increased capacity for removal of organic matter, both in terms of COD and BOD5 of milk processing wastewater. With increasing of MLSS concentration, flux of the membrane was increased due to a decrease in soluble microbial products and extracellular polymeric substance from the bacterial cells in the lower food to microorganism ratio (F/M).

[1]  Masoud Rahimi,et al.  Preparation of a novel antifouling mixed matrix PES membrane by embedding graphene oxide nanoplates , 2014 .

[2]  Z. Jia,et al.  Quantitative determination of polyethylene glycol with modified Dragendorff reagent method. , 2009 .

[3]  B. Wang,et al.  Nitrogen removal and simultaneous nitrification and denitrification in a fluidized bed step-feed process. , 2012, Journal of environmental sciences.

[4]  Yan Wang,et al.  Molecular‐Level Dispersion of Graphene into Poly(vinyl alcohol) and Effective Reinforcement of their Nanocomposites , 2009 .

[5]  Fenglin Yang,et al.  TiO2 and polyvinyl alcohol (PVA) coated polyester filter in bioreactor for wastewater treatment. , 2012, Water research.

[6]  G. Belfort,et al.  Increasing membrane permeability of UV-modified poly(ether sulfone) ultrafiltration membranes , 2002 .

[7]  Zhiwei Xu,et al.  Effect of graphite oxide and multi-walled carbon nanotubes on the microstructure and performance of PVDF membranes , 2013 .

[8]  G. Najafpour,et al.  Application of response surface methodology for simultaneous carbon and nitrogen (SND) removal from dairy wastewater in batch systems , 2012 .

[9]  Renbi Bai,et al.  Modification of membrane surface for anti-biofouling performance: Effect of anti-adhesion and anti-bacteria approaches , 2010 .

[10]  Zhen-liang Xu,et al.  Preparation and characterization of PVDF-SiO2 composite hollow fiber UF membrane by sol-gel method , 2009 .

[11]  A. Drews,et al.  Recent advances in membrane bioreactors (MBRs): membrane fouling and membrane material. , 2009, Water research.

[12]  M. Ioniță,et al.  Improving the thermal and mechanical properties of polysulfone by incorporation of graphene oxide , 2014 .

[13]  Juan Zhang,et al.  Fabrication of poly(ether sulfone)/poly(zinc acrylate) ultrafiltration membrane with anti-biofouling properties , 2014 .

[14]  Ioannis V. Skiadas,et al.  Treatment of Dairy Wastewater Using an Upflow Anaerobic Sludge Blanket Reactor , 1999 .

[15]  R. Ruoff,et al.  The chemistry of graphene oxide. , 2010, Chemical Society reviews.

[16]  H. Ngo,et al.  Simultaneous removal of phosphorus and nitrogen from sewage using a novel combo system of fluidized bed reactor-membrane bioreactor (FBR-MBR). , 2013, Bioresource technology.

[17]  Ahmad Fauzi Ismail,et al.  Enhanced hydrophilicity and salt rejection study of graphene oxide-polysulfone mixed matrix membrane , 2013 .

[18]  Hang-Sik Shin,et al.  Sludge characteristics and their contribution to microfiltration in submerged membrane bioreactors , 2003 .

[19]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[20]  Derin Orhon,et al.  Biological treatability of dairy wastewaters , 1993 .

[21]  Fenglin Yang,et al.  Highly effective antifouling performance of PVDF/graphene oxide composite membrane in membrane bioreactor (MBR) system , 2014 .

[22]  Weiwei Chen,et al.  The possibility and applicability of coagulation-MBR hybrid system in reclamation of dairy wastewater , 2012 .

[23]  Seoktae Kang,et al.  Mitigated membrane fouling in a vertical submerged membrane bioreactor (VSMBR) , 2006 .

[24]  Matthias Kraume,et al.  Membrane fouling - a review on the role of EPS , 2006 .

[25]  N. Dizge,et al.  Investigation of characterization and biofouling properties of PES membrane containing selenium and copper nanoparticles , 2013 .

[26]  Pierre Le-Clech,et al.  Fouling in membrane bioreactors used in wastewater treatment , 2006 .

[27]  Menachem Elimelech,et al.  Influence of membrane surface properties on initial rate of colloidal fouling of reverse osmosis and nanofiltration membranes , 2001 .

[28]  M. Sobhey,et al.  Treatment of a combined dairy and domestic wastewater in an up-flow anaerobic sludge blanket (UASB) reactor followed by activated sludge (AS system) , 2008 .

[29]  Liyun Yu,et al.  Effect of TiO2 nanoparticles on the surface morphology and performance of microporous PES membrane , 2009 .

[30]  Burhanettin Farizoğlu,et al.  The investigation of dairy industry wastewater treatment in a biological high performance membrane system , 2011 .

[31]  Hui-Ming Cheng,et al.  Synthesis of high-quality graphene with a pre-determined number of layers , 2009 .

[32]  Vahid Vatanpour,et al.  TiO2 embedded mixed matrix PES nanocomposite membranes: Influence of different sizes and types of nanoparticles on antifouling and performance , 2012 .

[33]  Chuanping Feng,et al.  Domestic sewage treatment in a sequencing batch biofilm reactor (SBBR) with an intelligent controlling system , 2011 .

[34]  S. Zinadini,et al.  Fabrication and characterization of novel antifouling nanofiltration membrane prepared from oxidized multiwalled carbon nanotube/polyethersulfone nanocomposite , 2011 .

[35]  Jooheon Kim,et al.  The effect of sulfonated graphene oxide on Sulfonated Poly (Ether Ether Ketone) membrane for direct methanol fuel cells , 2013 .

[36]  A. Mohammad,et al.  Polymeric membranes incorporated with metal/metal oxide nanoparticles: A comprehensive review , 2013 .

[37]  Francisco Omil,et al.  Anaerobic filter reactor performance for the treatment of complex dairy wastewater at industrial scale. , 2003, Water research.

[38]  Xia Huang,et al.  A novel ZnO nanoparticle blended polyvinylidene fluoride membrane for anti-irreversible fouling , 2012 .

[39]  Fu Liu,et al.  Preparation and characterization of poly(vinylidene fluoride) (PVDF) based ultrafiltration membranes using nano γ-Al2O3 , 2011 .

[40]  G. Oron,et al.  Immersed membrane bioreactor (IMBR) for treatment of combined domestic and dairy wastewater in an isolated farm. , 2009, Water science and technology : a journal of the International Association on Water Pollution Research.

[41]  M. Reis,et al.  Microbial population analysis of nutrient removal-related organisms in membrane bioreactors , 2011, Applied Microbiology and Biotechnology.

[42]  M. Amaral,et al.  Nanofiltration as tertiary treatment for the reuse of dairy wastewater treated by membrane bioreactor , 2014 .

[43]  Zhiwei Xu,et al.  Organosilane-functionalized graphene oxide for enhanced antifouling and mechanical properties of polyvinylidene fluoride ultrafiltration membranes , 2014 .

[44]  Francisco A. Riera,et al.  Recovery of dairy industry wastewaters by reverse osmosis. Production of boiler water , 2014 .

[45]  Bulent Keskinler,et al.  Cheese whey treatment performance of an aerobic jet loop membrane bioreactor , 2004 .

[46]  Guojun Zhang,et al.  Self-assembly of graphene oxide and polyelectrolyte complex nanohybrid membranes for nanofiltration and pervaporation , 2012 .

[47]  Fenglin Yang,et al.  Effect of graphene oxide concentration on the morphologies and antifouling properties of PVDF ultrafiltration membranes , 2013 .

[48]  Rostam Moradian,et al.  Novel antibifouling nanofiltration polyethersulfone membrane fabricated from embedding TiO2 coated multiwalled carbon nanotubes , 2012 .

[49]  M. Amaral,et al.  Treatment of dairy wastewater with a membrane bioreactor , 2013 .

[50]  V. Vatanpour,et al.  Preparation of a Novel Polyvinylidene Fluoride (PVDF) Ultrafiltration Membrane Modified with Reduced Graphene Oxide/Titanium Dioxide (TiO2) Nanocomposite with Enhanced Hydrophilicity and Antifouling Properties , 2014 .

[51]  Lianjun Wang,et al.  Preparation and characterization of ZrO2/PES hybrid ultrafiltration membrane with uniform ZrO2 nanoparticles , 2014 .

[52]  Juan M. Garrido,et al.  Feasibility of combined UASB and MBR system in dairy wastewater treatment at ambient temperatures , 2013 .

[53]  Mickael Vourch,et al.  Treatment of dairy industry wastewater by reverse osmosis for water reuse , 2008 .

[54]  Marc A. Deshusses,et al.  Direct observation of biofouling in cross-flow microfiltration: mechanisms of deposition and release , 2004 .

[55]  Ali Ashraf Derakhshan,et al.  Boehmite nanoparticles as a new nanofiller for preparation of antifouling mixed matrix membranes , 2012 .

[56]  Jaewoo Lee,et al.  Graphene oxide nanoplatelets composite membrane with hydrophilic and antifouling properties for wastewater treatment , 2013 .

[57]  M. Payraudeau,et al.  Simultaneous nitrification and denitrification in biofilters with real time aeration control. , 2001, Water science and technology : a journal of the International Association on Water Pollution Research.