Bias-temperature instabilities and radiation effects in MOS devices

We report the combined effects of irradiation and bias temperature stress (BTS) on MOS capacitors with HfO/sub 2/ dielectrics. Irradiation is found to enhance BTS-induced degradation in these devices; significant differences in the amounts of enhancement are observed for different irradiation biases. Zero-bias or positive-bias irradiation followed by negative BTS (NBTS) leads to much worse degradation than either irradiation or NBTS alone. This is primarily due to the formation of dipoles during irradiation and the electrostatic repulsion of electrons from the oxide during NBTS. In an integrated circuit application, the worst-case response for these gate stacks will be pMOS transistors irradiated in their "off" states, and annealed in their "on" states. The effects of irradiation and BTS are also reported for Al/sub 2/O/sub 3/-based MOS capacitors with Al gates and SiO/sub 2/-based MOS capacitors with NiSi gates for comparison with HfO/sub 2/. Somewhat less sensitivity to combined irradiation and BTS is observed for the Al/sub 2/O/sub 3/-based devices, and significantly less sensitivity to combined effects is observed for the thermal oxides with NiSi gates.

[1]  J. F. Conley,et al.  The radiation response of the high dielectric-constant hafnium oxide/silicon system , 2002 .

[2]  H. E. Boesch,et al.  Post-Irradiation Effects in Field-Oxide Isolation Structures , 1987, IEEE Transactions on Nuclear Science.

[3]  Daniel M. Fleetwood,et al.  Using laboratory X-ray and cobalt-60 irradiations to predict CMOS device response in strategic and space environments , 1988 .

[4]  F. B. McLean.  A Framework for Understanding Radiation-Induced Interface States in SiO2 MOS Structures , 1980, IEEE Transactions on Nuclear Science.

[5]  H. E. Boesch,et al.  The nature of the trapped hole annealing process , 1989 .

[6]  A. Lelis,et al.  Time dependence of switching oxide traps , 1994 .

[7]  R.,et al.  Challenges in hardening technologies using shallow-trench isolation , 1998 .

[8]  Daniel M. Fleetwood,et al.  Bulk oxide traps and border traps in metal–oxide–semiconductor capacitors , 1998 .

[9]  Ronald D. Schrimpf,et al.  Hydrogen-related defects in irradiated SiO/sub 2/ , 2000 .

[10]  Daniel M. Fleetwood,et al.  Effects of interface traps and border traps on MOS postirradiation annealing response , 1995 .

[11]  J.E. Seiler,et al.  Characterization of enhanced low dose rate sensitivity (ELDRS) effects using Gated Lateral PNP transistor structures , 2004, IEEE Transactions on Nuclear Science.

[12]  D. Fleetwood,et al.  Effects of oxide traps, interface traps, and ‘‘border traps’’ on metal‐oxide‐semiconductor devices , 1993 .

[13]  Ming Qin,et al.  Investigation of Polycrystalline Nickel Silicide Films as a Gate Material , 2001 .

[14]  M.A. Alam,et al.  Investigation and modeling of interface and bulk trap generation during negative bias temperature instability of p-MOSFETs , 2004, IEEE Transactions on Electron Devices.

[15]  E. Cartier,et al.  Threshold voltage instabilities in high-/spl kappa/ gate dielectric stacks , 2005, IEEE Transactions on Device and Materials Reliability.

[16]  D. Fleetwood,et al.  New insights into radiation-induced oxide-trap charge through thermally-stimulated-current measurement and analysis (MOS capacitors) , 1992 .

[17]  Ronald D. Schrimpf,et al.  Radiation-Induced Charge Trapping in Thin , 2003 .

[18]  N. Saks,et al.  Interface trap formation via the two-stage H/sup +/ process , 1989 .

[19]  O. Flament,et al.  The role of electron transport and trapping in MOS total-dose modeling , 1999 .

[20]  H. E. Boesch,et al.  Reversibility of trapped hole annealing , 1988 .

[21]  D. Schroder,et al.  Negative bias temperature instability: Road to cross in deep submicron silicon semiconductor manufacturing , 2003 .

[22]  D. Brown,et al.  OBSERVATION OF H + MOTION DURING INTERFACE TRAP FORMATION , 2004 .

[23]  E. Cartier,et al.  Threshold Voltage Instabilities in High- Gate Dielectric Stacks , 2005 .

[24]  N. Saks,et al.  Observation of H/sup +/ motion during interface trap formation , 1990 .

[25]  Ronald D. Schrimpf,et al.  Total-dose radiation response of hafnium-silicate capacitors , 2002 .

[26]  T. R. Oldham,et al.  Spatial Dependence of Trapped Holes Determined from Tunneling Analysis and Measured Annealing , 1986, IEEE Transactions on Nuclear Science.

[27]  peixiong zhao,et al.  Reactions of Hydrogen with Si-SiO 2 Interfaces , 2001 .

[28]  E. H. Nicollian,et al.  Mechanism of negative‐bias‐temperature instability , 1991 .

[29]  peixiong zhao,et al.  Hydrogen-Related Defects in Irradiated SiO , 2000 .

[30]  E. P. Gusev,et al.  Radiation-induced charge trapping in thin Al/sub 2/O/sub 3//SiO/sub x/N/sub y//Si(100) gate dielectric stacks , 2003 .

[31]  peixiong zhao,et al.  Physical mechanisms of negative-bias temperature instability , 2005 .

[32]  Daniel M. Fleetwood,et al.  Strategies for lot acceptance testing using CMOS transistors and ICs , 1989 .

[33]  Daniel M. Fleetwood,et al.  1/f noise, hydrogen transport, and latent interface-trap buildup in irradiated MOS devices , 1997 .

[34]  Young Hee Kim,et al.  Bias-temperature instabilities of polysilicon gate HfO/sub 2/ MOSFETs , 2003 .

[35]  peixiong zhao,et al.  Effects of hydrogen motion on interface trap formation and annealing , 2004, IEEE Transactions on Nuclear Science.

[36]  P. V. Dressendorfer,et al.  A Reevaluation of Worst-Case Postirradiation Response for Hardened MOS Transistors , 1987, IEEE Transactions on Nuclear Science.

[37]  William Eccleston,et al.  Positive bias temperature instability in MOSFETs , 1998 .

[38]  peixiong zhao,et al.  Hydrogen Model for Negative Bias Temperature Instabilities in MOS Gate Insulators , 2006 .

[39]  peixiong zhao,et al.  Reactions of hydrogen with Si-SiO/sub 2/ interfaces , 2000 .

[40]  Daniel M. Fleetwood,et al.  Total-dose radiation hardness assurance , 2003 .

[41]  Daniel M. Fleetwood,et al.  Stability of trapped electrons in SiO 2 , 1999 .

[42]  P. S. Winokur,et al.  Physical Mechanisms Contributing to Device "Rebound" , 1984, IEEE Transactions on Nuclear Science.

[43]  Dennis B. Brown,et al.  Experimental evidence of two species of radiation induced trapped positive charge , 1993 .

[44]  J. F. Conley,et al.  Electron spin resonance evidence that E'/sub /spl gamma// centers can behave as switching oxide traps , 1995 .

[45]  P. S. Winokur,et al.  Correlating the Radiation Response of MOS Capacitors and Transistors , 1984, IEEE Transactions on Nuclear Science.

[46]  L. Tsetseris,et al.  Common origin for enhanced low-dose-rate sensitivity and bias temperature instability under negative bias , 2005, IEEE Transactions on Nuclear Science.

[47]  E. Cartier,et al.  Ultrathin high-K metal oxides on silicon: processing, characterization and integration issues , 2001 .

[48]  Ronald D. Schrimpf,et al.  Negative bias-temperature instabilities in metal–oxide–silicon devices with SiO2 and SiOxNy/HfO2 gate dielectrics , 2004 .

[49]  Scofield,et al.  Evidence that similar point defects cause 1/f noise and radiation-induced-hole trapping in metal-oxide-semiconductor transistors. , 1990, Physical review letters.